Production of hot rolled dual-phase steel strip by coiling below martensite start temperature

The laboratory tests showed that a dual-phase steel can be produced on the basis of the chemical composition given here, providing the coiling temperature is below the martensite start temperature. It is then possible to dispense with an additional air cooling period on the runout table, which is mandatory with production concepts known up to now. The best mechanical properties are attained at a coiling temperature of 200°C. The final rolling temperature should be around A_r3 to avoid a heavy ferrite deformation without softening and, on the other hand, to reduce the yield stress increase caused by aging. Nitrogen aging can be suppressed by the addition of small amounts of titanium to bind nitrogen, forming a dispersion of titanium nitrides. The feasibility of this concept under production conditions was confirmed by means of hot rolling tests on a hot wide strip mill.     

Composition of oregano essential oil (Origanum vulgare) as affected by drying method

The influence of the drying method on volatile compounds of Origanum vulgare was evaluated. The drying methods tested were convective (CD) at 60 °C and vacuum-microwave (VMD), as well as a combination of convective pre-drying and VM finish-drying (CPD–VMFD). The volatile compounds of fresh and dried oregano were extracted by steam-hydrodistillation and analyzed by GC–MS. Oregano drying kinetics was described by a simple exponential model for CD and CPD–VMFD, while VMD kinetics consisted of two periods: linear until a critical point and exponential beyond that point. Thirty-four compounds were tentatively identified, with carvacrol, thymol, and γ-terpinene, being the major components. The total volatiles concentration of fresh oregano (33.0 g kg⁻¹) decreased significantly during drying, independently of the method used (CD: 10.2 g kg⁻¹, CPD–VMFD: 13.1 g kg⁻¹, and VMD: 27.9 g kg⁻¹). The final conclusion was that VM dehydrated Polish oregano was of better aromatic quality than that dried using hot air.     

Measurements and thermodynamic modeling of the solubility of squalene in supercritical carbon dioxide

The solubility of squalene in supercritical carbon dioxide (SC-CO₂) was measured and it was analyzed together with the values obtained by Catchpole and von Kamp (1997). The results showed that the experimental values obtained in this work agreed with the order of magnitude of those reported in the literature and correlated well with the Chrastil equation. The thermodynamic modeling using the Peng–Robinson equation of state only correlated well with the experimental values obtained when the critical properties and acentric factor reported by Ruivo et al. (2004) were used. The values predicted for the solubility of squalene in SC-CO₂ using modeling employing the GC-EOS, were only of the same order of magnitude as the experimental values for pressures below 200 bar, and its performance was influenced by the value of the critical hard sphere diameter.     

Species,roasting degree and decaffeination influence the antibacterial activity of coffee against Streptococcus mutans

Coffee beverage has been associated with antibacterial activity against Streptococcus mutans, a cariogenic bacterium. This study aimed at identifying natural compounds in coffee that contribute to such activity and investigate the influence of species, roasting and decaffeination on it. Coffee chemical compounds and aqueous extracts of green and roasted regular and decaffeinated Coffea arabica and Coffea canephora beans were tested. MIC, biofilm inhibition and biofilm reduction results were correlated with the concentration of coffee compounds in the extracts. 5-Caffeoylquinic acid, trigonelline and caffeic acid solutions showed bacteriostatic activity (MIC = 0.8 mg/mL). Lighter and regular extracts showed higher inhibitory activity than darker and decaffeinated extracts, with an inverse correlation between bacterial colony-forming units and roasting degree. Only regular C. canephora extracts showed biofilm formation inhibition. The joint effect of chlorogenic acids, trigonelline and caffeine or other compounds removed by decaffeination seems to be one of the causes for coffee antibacterial activity against S. mutans.     

Combined effect of enterocin AS-48 and high hydrostatic pressure to control food-borne pathogens inoculated in low acid fermented sausages

The single and combined effects of enterocin AS-48 and high hydrostatic pressure (HHP) on Listeria monocytogenes, Salmonellaenterica, and Staphylococcus aureus was investigated in fuet (a low acid fermented sausage) during ripening and storage at 7 °C or at room temperature. AS-48 (148 AU g⁻¹) caused a drastic 5.5 log cfu g⁻¹ decrease in L. monocytogenes (P < 0.001) and a significant (P < 0.01) inhibition (1.79 logs) for Salmonella at the end of ripening (10 d). After pressurization (400 MPa) and storage Listeria counts remained below 5 cfu g⁻¹ in all fuets containing AS-48 (pressurized or not). HHP alone had no anti-Listeria effect. HHP treatment significantly reduced Salmonella counts, with lowest levels in pressurized fuets with AS-48. S. aureus showed similar growth for all treatments and storage conditions. These results indicate that AS-48 can be applied alone to control L. monocytogenes and combined with HHP treatment to control Salmonella in fuets.     

Double-muscling character influences the trans-18:1 and conjugated linoleic acid profiles in concentrate-fed yearling bulls

Seventy-five yearling bulls of the “Asturiana de los Valles” northern-Spanish beef breed (double-muscled, mh/mh, n = 24; heterozygous, mh/+, n = 26; normal, +/+, n = 25) were produced under intensive conditions and the effects of double-muscling genotype on trans-18:1 and CLA isomer profiles were examined. Total trans-18:1 contents, measured as percentages of total fatty acid methyl esters, were 10.98–15.07% in backfat and 8.64–9.46% in muscle, and the major isomer was 10t-18:1 in all animals. In mh/+ animals, 11t-18:1 was the second most abundant trans isomer in muscle whereas in mh/mh and +/+ animals 11t-18:1 and 13t/14t-18:1 were relatively similar. Total CLA percentages were 0.71–0.85% in backfat and 0.32–0.40% in muscle. The highest total CLA percentage found was in mh/+, intermediate in +/+ and lowest in mh/mh animals (P < 0.05). Heterozygous animals had significantly higher percentages of 9c,11t- (P < 0.01), 11t,13c- (P < 0.01) and 9c,11c-18:2 (P < 0.05) and also significantly higher percentages of the sum of 9c,11t-/11t,13c-/11t,13t-18:2. Overall, mh/+ animals produced meat with a slightly better trans and CLA profile (i.e., less 10t-18:1 and more 11t-18:1 and 9c,11t-18:2) than other genotypes, however, further improvements would still be necessary to achieve a profile with a positive health image.     

Use of Lactobacillus plantarum and glucose to control the fermentation of "Bella di Cerignola" table olives, a traditional variety of Apulian region (Southern Italy)

The purpose of this study was to evaluate the use of Lactobacillus plantarum, isolated from table olives "Bella di Cerignola," a traditional variety of Apulian region (Southern Italy), as a starter for this kind of food. We focused on the interaction of the starter with the natural occurring microflora, the quantitative/qualitative composition of yeast population, the decrease of pH, and the content of organic acids. After a preliminary characterization, 3 strains of Lb. plantarum, selected for their probiotic and technological performances, were used as a multiple-strain starter and inoculated (approximately 2%) in olives, processed according to Spanish style, brined at 8% and 10% of NaCl and added with 0.5% of glucose. The combination of the starter and glucose assured a correct fermentation course, decreasing the pH up to a safe value (4.3 to 4.5) and controlled the growth of yeasts. The concentrations of both L- and D-lactic acids increased throughout the fermentation, while citric and malic acids (both the isomers D and L) remained at low levels (0.2 to 0.4 g/L). Concerning yeast species, Candida guilliermondii was mainly isolated at the beginning (7 to 14 d), while C. famata prevailed at the end of fermentation. PRACTICAL APPLICATIONS: To the question "How to standardize and maintain quality of "Bella di Cerignola" olives (Southern Italy)" we can suggest the following answer: use Lb. plantarum and a low amount of glucose (0.5%). The result is a decrease of the pH below the safety break point.     

Characterization and Implications of Enterobacter cloacae Strains, Isolated from Italian Table Olives "Bella Di Cerignola"

ABSTRACT:  Enterobacter cloacae  can be recovered in the spontaneous fermentations of Italian table olives. In this study, the effects of salt (20 to 100 g/L), temperature (10 to 37 °C), pH (4 to 5 and 8 to 10),  p -coumaric and vanillic acids (0.5 to 2 g/L), and the acidification of the medium through lactic, citric, and ascorbic acids were investigated on 15 strains of  E. cloacae , isolated from Italian table olives "Bella di Cerignola." Finally, a confirmatory experiment in synthetic brine was run. The strains were inhibited only by an NaCl amount of 70 to 80 g/L and by  p -coumaric acid; on the other hand, they showed the ability to grow also at low temperatures (10 to 15 °C). The confirmatory experiment highlighted their ability to survive both at 15 °C and at pH 5.  Enterobacter cloacae  could be a real problem for the fermentation of table olives in southern Italy; some hurdles could be used (salt or brine acidification), but some environmental conditions (for example, the temperature) should be controlled carefully to maintain olive safety at acceptable levels.     

Nutrition facts and functional potential of quinoa (Chenopodium quinoa willd.), an ancient Andean grain: a review

Quinoa, Chenopodium quinoa Willd., is an Amaranthacean, stress‐tolerant plant cultivated along the Andes for the last 7000 years, challenging highly different environmental conditions ranging from Bolivia, up to 4.500 m of altitude, to sea level, in Chile. Its grains have higher nutritive value than traditional cereals and it is a promising worldwide cultivar for human consumption and nutrition. The quinoa has been called a pseudo‐cereal for botanical reasons but also because of its unusual composition and exceptional balance between oil, protein and fat. The quinoa is an excellent example of ‘functional food’ that aims at lowering the risk of various diseases. Functional properties are given also by minerals, vitamins, fatty acids and antioxidants that can make a strong contribution to human nutrition, particularly to protect cell membranes, with proven good results in brain neuronal functions. Its minerals work as cofactors in antioxidant enzymes, adding higher value to its rich proteins. Quinoa also contains phytohormones, which offer an advantage over other plant foods for human nutrition. Copyright © 2010 Society of Chemical Industry