硫酸铈改性磷酸–硫酸铝合金阳极氧化膜耐腐蚀性研究

研究了稀土盐硫酸铈改性磷酸–硫酸阳极氧化处理对2A50铝合金表面耐腐蚀性能的影响。通过滴碱试验和铜加速乙酸盐雾(CASS)试验对改性前后阳极氧化膜的耐蚀性进行了研究,采用扫描电镜观察了不同阳极氧化膜的表面和截面形貌,测试了氧化膜的厚度,并对铈盐改性后的氧化膜进行了能谱分析,探讨了铈盐的作用机理。结果表明,稀土改性后得到的阳极氧化膜上孔分布均匀,孔隙率较高,其组成为Al2O3,氧化膜厚度由改性前的4.2μm提高到改性后的49.2μm,滴碱时间由35.9 s提高到186.9 s,CASS试验24、72和168 h的腐蚀评级分别由9、7和5级提高到10、9和8级。认为稀土盐的加入使氧化膜多孔层生长速率加快,阻挡层厚度增加,多孔部分结构更致密,从而提高了铝合金阳极氧化膜的耐蚀性能。     

金属波纹管真空釜用密封的结构设计及实验研究

提出了一种新型的真空搅拌釜用无泄漏密封结构设计。设计中提出了一种独特的传动机构 ,使密封波纹管经历最小变形以延长其使用寿命。对所设计的密封结构进行了实验室条件下的验证实验。实验结果表明 ,该结构的密封能保证介质的零泄漏 ,波纹管工作可靠 (经历 4 .3× 10 6次变形 ,波纹管无破坏迹象 ) ,传动机械效率大致与传统的机械密封相当。     

Lycopene from two food sources does not affect antioxidant or cholesterol status of middle-aged adults

Background

Epidemiological studies have reported associations between reduced cardiovascular disease and diets rich in tomato and/or lycopene. Intervention studies have shown that lycopene-containing foods may reduce cholesterol levels and lipid peroxidation, factors implicated in the initiation of cardiovascular disease. The objective of this study was to determine whether consumption of lycopene rich foods conferred cardiovascular protection to middle-aged adults as indicated by plasma lipid concentrations and measures of ex vivo antioxidants.

Methods

Ten healthy men and women consumed a low lycopene diet with no added lycopene (control treatment) or supplemented with watermelon or tomato juice each containing 20 mg lycopene. Subjects consumed each treatment for three weeks in a crossover design. Plasma, collected weekly was analyzed for total cholesterol, high density lipoprotein cholesterol (HDL-C) and triglyceride concentrations and for the antioxidant biomarkers of malondialdehyde formation products (MDA), plasma glutathione peroxidase (GPX) and ferric reducing ability of plasma (FRAP). Data were analyzed using Proc Mixed Procedure and associations between antioxidant and lipid measures were identified by Pearson's product moment correlation analysis.

Results

Compared to the control diet, the lycopene-containing foods did not affect plasma lipid concentrations or antioxidant biomarkers. Women had higher total cholesterol, HDL-C and triglyceride concentrations than did the men. Total cholesterol was positively correlated to MDA and FRAP while HDL-C was positively correlated to MDA and GPX. GPX was negatively correlated to triglyceride concentration.

Conclusions

The inclusion of watermelon or tomato juice containing 20 mg lycopene did not affect plasma lipid concentrations or antioxidant status of healthy subjects. However, plasma cholesterol levels impacted the results of MDA and FRAP antioxidant tests.     

铁离子改性碳分子筛对氮气/甲烷分离性能的研究

针对碳分子筛对氮气/甲烷分离体系分离比低的问题,采用浸渍法以市售空分碳分子筛（CMS）为基体,制备了分离氮气/甲烷的铁离子改性碳分子筛。通过静态吸附量、分离比、吸附动力学及热力学性质考察了铁离子负载量对碳分子筛吸附分离氮气/甲烷性能的影响。结果表明：铁（Ⅲ）的负载减小了CMS的比表面积、微孔体积和孔径,使CMS超微孔的孔径分布呈现更集中的趋势。这种集中性以动力学性能下降为代价,明显提高了碳分子筛对氮气/甲烷的吸附分离比。在303 K、0.7 MPa条件下,综合性能优异的0.3%铁改性CMS具有6.03的氮气/甲烷吸附分离比。     

斜入射平面SH波在层状饱和半空间中沉积谷地 周围的三维散射

为研究层状饱和场地中沉积谷地对斜入射地震波的三维散射问题,建立了求解问题的2.5维间接边界元方法。通过沿沉积谷地轴线方向的傅里叶变换将三维问题降为二维问题,进而在沉积谷地的截面内进行边界单元的离散和求解,求得沉积谷地截面内的动力响应,然后再将截面内计算结果沿沉积谷地轴线方向进行波数展开即可求得任意位置动力响应。通过与弹性情况的比较验证了方法的正确性,并以均匀饱和半空间和基岩上单一饱和土层中沉积谷地对斜入射平面SH波的三维散射为例进行了数值计算和分析。研究发现沉积谷地对SH波的三维散射与二维散射之间存在显著差异;饱和情况(透水或不透水)与干土情况沉积谷地附近地表位移的差别很大;另外层状饱和半空间中沉积谷地和均匀饱和半空间中沉积谷地对斜入射SH波的放大作用也存在显著差别。     

碳化对海砂混凝土中氯离子扩散的影响

选取海阳海砂、淡化海阳海砂和河砂三种细骨料,分别制备强度等级为C30和C50的混凝土,进行加速碳化与氯离子侵蚀复合试验的研究,测出混凝土试块不同深度的水溶性自由氯离子含量.结果表明:海砂混凝土、淡化海砂混凝土在碳化与氯离子侵蚀复合作用下的破坏规律与河砂混凝土基本一致.碳化时间对各种混凝土中氯离子的扩散影响都很大.混凝土强度等级,海砂中固有的氯离子等因素也影响混凝土各深度的水溶性自由氯离子含量.     

38CrSi合金钢表面纳米化中渗碳体相的细化分析

利用表面机械加工法在具有回火索氏体组织的38CrSi合金钢表面制备了纳米结构层,利用X射线衍射和透射电镜等分析技术,对距表面不同深度处渗碳体相的微观结构特征及物相组成进行研究,分析38CrSi合金钢表面纳米化过程中渗碳体相的细化过程.结果表明,铁素体基体细化过程中,渗碳体颗粒在切变力作用下形成细小颗粒的同时还发生了溶解.在应变量和应变速度较高的最表面,渗碳体颗粒溶解较严重,分析表明高密度位错产生的高界面能、应力集中以及能量波动是使得渗碳体颗粒发生切变和溶解主要原因.     

Effect of glass removal on the GMI effect of Co71.8Fe4.9Nb0.8Si7.5B15 amorphous glass-covered wires

During the past several years, giant magneto-impedance effect (GMI) in amorphous wires has generated growing interest in the science community because of theirapplications in sensors. The giant magneto-impedance effect in Co71.8Fe4.9Nb0.8Si7.5B15 amorphous glass-covered wires (AGCW) consists of strong changes in the high frequency impedance with a small DC magnetic field. When f =1 MHz, there is no GMI effect due to the fact that the magnetic penetration depth is higher than their radius. As the frequency increases, the GMI effect becomes important in both the glass-covered wire and the wire afterglass removal. Field dependence of the impedance has a similar behaviour to the AGCW ones, when a tensile stress is applied to the wire without glass cover.     

交流磁场对过共晶Al-2.89%Fe合金中含铁相分布的影响

在交流磁场作用下,过共晶Al-2．89％Fe（质量分数,％）合金中含铁相向样品的中心处富集．这是由于Al3Fe相的磁化率大于熔融铝的磁化率,使得Al3Fe相与铝基体相比受到指向试样轴线处更大的电磁力,从而聚集在试样中心．X射线衍射结果表明,在无磁场和交流磁场条件下,含铁相中只含有A13Fe相．交流磁场改变了析出相的分布,但没有改变析出相的类型．     

脉冲电流和脉冲磁场作用下LY12铝合金凝固组织的比较

以我们所做的实验结果为根据 ,发现脉冲磁场对 L Y12铝合金凝固组织的细化效果要好于脉冲电流 ,并比较了脉冲电流和脉冲磁场这两种新颖的脉冲电磁场技术对其凝固组织的细化和机理差别、工作原理和特点 ,指出了应用前景