A positive‐working photosensitive polyimide based on thermal cross‐linking and acidolytic cleavage

A novel positive‐working photosensitive polyimide (PSPI) based on a poly(hydroxyimide) (PHI), a crosslinking agent having vinyl ether groups, and a photoacid generator (PAG) was prepared. The PHI as a base resin of the three‐component PSPI was synthesized from 4,4′‐oxydiphthalic anhydride and 2,2′‐bis(3‐amino‐4‐hydroxyphenyl)hexafluoropropane through ring‐opening polymerization and subsequent thermal cyclization. 2,2′‐bis(4‐(2‐(vinyloxy)ethoxy)phenyl)propane (BPA‐DEVE) was used as a vinylether compound and diphenyliodonium 5‐hydroxynaphthalene‐1‐sulfonate was used as a PAG. The phenolic hydroxyl groups of the PHI and the vinyl ether groups of BPA‐DEVE are thermally crosslinked with acetal structures during prebake step, and the crosslinked PHI becomes completely insoluble in an aqueous basic solution. Upon exposure to UV light (365 nm) and subsequent postexposure bake (PEB), a strong acid generated from the PAG cleaves the crosslinked structures, and the exposed area is effectively solubilized in the alkaline developer. The dissolution behavior of the PSPI containing each 11.5 wt % of BPA‐DEVE and of the PAG was studied after UV exposure (365 nm) and PEB. It was found that the difference in dissolution rates between exposed and unexposed areas was enough to get high resolution. A fine positive pattern with a resolution of 5 μm in a 3.7‐μm‐thick film was obtained from the three‐component PSPI. © 2007 Wiley Periodicals, Inc. J Appl Polym Sci, 2008     

Tribological behavior of PTFE nanocomposite films reinforced with carbon nanoparticles

Carbon-based nanoparticles synthesized by heat treatment of nanodiamond in the temperature range of 1000–1900 °C were added to PTFE film to investigate the structural effect of the carbon particles on the tribological properties of PTFE composite film. Carbon-based nanoparticles were prepared by milling with micron sized beads in chemically treated water before their addition to PTFE film. The wear and frictional properties of PTFE nanocomposite film were measured by the ball on plate type wear test. The wear resistance of PTFE film was found to be enhanced by the addition of 2 wt% of carbon nanoparticles. The wear coefficient of PTFE film was decreased from 16.2 to 3.5 × 10⁻⁶ mm³/N m by the addition of carbon-based nanoparticles heat-treated at 1000 °C. Increasing the heating temperature of the nanodiamonds caused the extent of aggregation and particle size to increase. The wear resistance of PTFE nanocomposite film was enhanced by the addition of nanodiamonds heat-treated at 1000 °C, but decreased when the heat treatment temperature of carbon nanoparticles was further increased. Tribological behavior of PTFE nanocomposite films depending on the types of carbon nanoparticles were explained based on the structural, physical and chemical modification of carbon nanoparticles.     

Effects of chemical and plasma surface treatments on the O2-annealed Ni/Au contact to p-Gan

The effects of boiling Aqua Regia (AQ), N₂/Cl₂ plasma followed by AQ and O₂ plasma followed by AQ surface treatments prior to Ni/Au (20 nm/20 nm) metallization to p-GaN:Mg (∼ 3 × 10¹⁷ cm^− 3) have been investigated. N₂/Cl₂ plasma was employed in a bid to lower the Ga/N and O/Ga ratios of the GaN surface to improve the contact properties to p-GaN, while O₂ plasma was employed as an alternative to incorporate O into the Ni/Au system. Results show that a low Ga/N ratio does not necessarily correspond to a better contact. The positive effect of O₂ over N₂ anneal is observed only for the AQ-treated sample, although the mechanisms responsible for its positive effect: NiO formation and Ni/Au layer-reversal were observed for all O₂-annealed contacts. We conclude that the effect of O₂ anneal on the Ni/Au contact is dependant on the p-GaN surface prior to metallization.     

Design of electrically small ground planes for HF ground wave transmission

Electrically small spiral ground planes for a monopole and an electrically small antenna have been designed for HF ground wave transmission. Prototype ground planes have been built and tested. For the monopole, the transmission loss of the designed ground plane is 6 dB better than that of the same size ground radials. For the electrically small antenna, the transmission loss of the designed ground plane is 7 dB better than that of the same size solid ground plane at the antenna's operating frequency.     

Tuberculous meningitis: a 30-year review

Tuberculous meningitis remains an important illness that can be difficult to diagnose in a timely fashion and carries significant morbidity. We present a retrospective review of the cases of tuberculous meningitis diagnosed and treated at a single institution. Fifty-eight cases were identified and stratified according to stage of disease at presentation. Four patients (7%) died; three (5%) developed severe neurological sequelae. Poor outcomes were largely confined to cases presenting in an advanced stage and at the extremes of age. Corticosteroids were administered to 56 patients and may have contributed to the comparatively good outcome in these cases.     

An effect of voltage on binding of Na+ at the cytoplasmic surface of the Na(+)-K+ pump

This work utilizes proteoliposomes reconstituted with renal Na(+)-K(+)-ATPase to study effects of electrical potential (40-80 mV) on activation of pump-mediated fluxes of Na+ or Rb+ (K+) ions and on inhibitory effects of Rb+ ions or organic cations. The latter include guanidinium derivatives that are competitive Na(+)-like antagonists (David, P., Mayan, H., Cohen, H., Tal, D. M., and Karlish, S.J.D. (1992) J. Biol. Chem. 267, 1141-1149). Cytoplasmic side-positive diffusion potentials significantly decreased the K0.5 of Na+ at the cytoplasmic surface for activation of ATP-dependent Na(+)-K+ exchange but did not affect the inhibitory potency of Rb+ (K+) or any Na(+)-like antagonist. Diffusion potentials did not affect activation of Rb(+)-Rb+ exchange by Rb+ ions at the cytoplasmic surface and had only a minor effect on Rb+ activation at the extracellular surface. Previously, we proposed that the cation binding domain consists of two negatively charged sites, to which two K+ or two Na+ ions bind, and one neutral site for the third Na+ (Glynn, I. M., and Karlish, S.J.D. (1990) Annu. Rev. Biochem. 59, 171-205). The present experiments suggest that binding of a Na+ ion in the neutral site at the cytoplasmic surface is sensitive to voltage. By contrast, binding of Rb+ ions at the extracellular surface of renal pumps appears to be only weakly or insignificantly affected by voltage. Inferences on the identity of the charge-carrying steps, based on experiments using proteoliposomes, are discussed in relation to recent evidence that dissociation of Na+ or association of K+ ions, at the extracellular surface, represent the major charge-carrying steps.