Fenton试剂处理苯酚和甲醛废水的研究

用H2O2同Fe^2 结合的Fenton试剂处理有机废水是一种经典的催化氧化法，这种方法适合于处理废水中高浓度、难降解的有机物质。主要研究了Fenton试剂处理含苯酚和甲醛有机废水样的反应机理和影响因素，试验结果表明：废水中苯酚和甲醛的去除率均可达到95％以上，COD去除率达到85％以上，表明用Fenton法处理含苯酚和甲醛的有机废水是一种非常有效的方法。     

糖蜜酒精废液处理技术

介绍了甘蔗制糖生产中国内外糖蜜酒精废液的处理方法，对不同处理技术的特点进行了分析，认为焚烧法既能彻底处理糖密酒精废液，又能把废液处理和资源回收相结合，并概述了国内外废液焚烧技术。     

Simultaneous recovery of copper and surfactant by an electrolytic process from synthetic solution prepared to simulate a concentrate waste stream of a micellar-enhanced ultrafiltration process

Electroplating method was employed to recover copper and surfactant simultaneously from synthetic solutions prepared to simulate concentrated waste stream generated from micellar-enhanced ultrafiltration. Effects of surfactant and copper (II) concentrations, surfactant to copper (II) molar ratio (S/M), electroplating voltage and time, solution pH, and ionic strength on metal recovery and electrical current efficiency were investigated. Results show that at a fixed S/M ratio of 5, the first-order kinetic constant for Cu (II) removal by electroplating increases with decreasing SDS concentration. At fixed SDS concentration of 8.5 mM, increasing initial Cu (II) concentration increases both Cu (II) recovery and current efficiency. Electrolyte pH has profound effects on the metal recovery and current efficiency due to the difference in solution conductivity after pH adjustment and the extent of Cu (II) adsorption onto SDS at different pHs.     

生物质转化的共性问题研究——生物质科学与工程学的建立与发展

生物质资源的高值转化是研究热点。由于现有的生物质利用技术存在的技术单一,缺乏系统性理论指导等问题,导致原料利用率低,经济效益差,难以实现工业化生产,迫切需要建立新的理论体系。通过深入分析生物质转化过程中的共性问题,在综合多学科知识的基础上,提出了生物质科学与工程学这一理念,从生物质原料工程学,生物质转化过程工程学和生物质产品工程学三方面对生物质利用技术进行了全面、系统的研究,为生物质类可再生资源的高值化利用提供了新的研究思路。     

Biomass pyrolysis in a circulating fluid bed reactor for the production of fuels and chemicals

An approach for biomass flash pyrolysis in a circulating fluid bed (CFB) reactor with continuous solids regeneration is described in this study. The unit is capable of performing conventional and catalytic biomass pyrolysis with the proper solid selection. The production of improved quality liquid products in a direct step through catalytic pyrolysis is investigated in this work. Both conventional and catalytic biomass pyrolysis can be effectively performed in this CFB unit. Flash pyrolysis conditions were achieved and liquid product yields of ∼70 wt% (on biomass feed) were obtained. The effect of specific operating variables including the type of inorganic solid material and the solid/biomass ratio was established on the final liquid product quality and yield. Solid materials considered included silica sand, a commercial fluid catalytic cracking catalyst and a ZSM-5 additive. Catalytic biomass pyrolysis generally leads to the production of additional water, coke and gases compared to conventional pyrolysis. However, the obtained liquid product quality and composition is improved.     

中氮肥煤造气技术改造调查与评述（上）

重点调查了９０年代以来，全国以煤焦为原料的中氮厂造气工序技术改造的基本情况，对技术改造的效果和存在的问题作了全面的评述，为各企业技术改造提供了一份可借鉴和参考的资料     

国外废旧塑料的再生利用

简述了废旧塑料的处理方法。着重介绍了世界工业发达国家,如美国、西欧、日本等国家近年来废旧塑料再生利用的情况及部分公司废旧塑料的再生回收技术。在世界性节能和节约资源的浪潮中,我国有关部门与行业应努力借鉴国外经验,开发废旧塑料的再生利用技术。     

热法磷酸的发展趋势与研究方向

简述了工业制磷酸的生产方法和热法磷酸生产工艺的发展,分析了热法磷酸今后的发展方向,提出了热法磷酸燃烧塔结膜物的研究课题。     

利用城市垃圾焚烧飞灰煅烧水泥熟料初探

针对垃圾焚烧飞灰化学组成上的特点,进行了利用垃圾焚烧飞灰烧制水泥熟料的探索研究,通过试验研究了其对水泥生料的易烧性、烧制的水泥熟料的力学性能和水化速率等的影响规律。研究结果表明,垃圾焚烧飞灰可以用作水泥原料从而有效地降低其处置成本,减少其对环境造成的二次污染,硬化水泥浆体水化28d时各重金属浸出量低于鉴别标准规定的指标,是一种有待开发的潜在的水泥原料资源。     

厌氧发酵处理味精废水中氯离子的影响

在3L 的CSTR 型厌氧反应器中研究了味精废水厌氧处理中氯离子毒性的反应。试验证明,已中毒的厌氧过程只要Cl~-浓度降至抑制限以下,厌氧过程就可在15～20d 内恢复,在恢复期间加入新污泥有利于恢复过程。保持足够大的SRT 和污泥浓度对于处理含有毒物的废水很有效。对本研究,SRT 得大于20d,污泥浓度在15～24g/L 左右就可达到较好的处理效率。Cl~-的抑制浓度对污泥浓度分别为24.28g/L,15.18g/L 和6.07g/L 时,Cl~-的抑制浓度分别是7750mg/L,7250mg/L和6300mg/L。此外,本文提出以I=S_(Cl)/X_v~n作为判断Cl~-抑制的指标。当COD 去除率大于80%时,n=0.1519。因此,要使过程的COD 去除率分别大于80%,85%和90%时,I 就得分别小于4.7,4.1和3.6。并且污泥浓度必须大于6.07g/L。