600MW超临界机组锅炉冲渣水回用的深度处理

华能上海石洞口第二电厂600MW超临界机组锅炉冲渣水系统由开式排放改造成闭式循环系统后,为达到系统的水量平衡,必须要对冲渣水进行深度处理后作为工业水进行回用。为使冲渣水能达到工业水的水质指标,对冲渣水进行了混凝、沉淀处理工艺的试验、研究,探索出了合适的处理工艺并在现有的工业水澄清池中进行了处理调试,使出水水质完全达到了回用的要求,实现了连续的处理和回用。通过连续处理和回用,达到了冲渣水闭式循环系统的水量平衡,每年减少约330万t冲渣废水的外排和相同数量的长江水的取水,取得了较大的社会效益和经济效益。     

蒸发时间对两级凝胶法制备的聚醚砜膜结构和性能的影响

主要探讨了蒸发时间对用两级凝胶法(dual—bath coagulation method)所制得的聚醚砜(PES)超滤膜的性能和结构的影响．结果表明，随着蒸发时间的延长，水通量先减小后增大；肌肝和尿素去除率均是先升高而后降低，然后再升高的趋势；膜的孔隙率上升，平均孔径下降．在蒸发时间为10s时，肌肝和尿素去除率最高，且水通量适中，是血液净化用聚醚砜膜的最佳成形条件．     

冬季黄河水强化混凝方式的优化选择

通过生产性实验，比较了活性炭与聚合硫酸铁、活性炭与聚合氯化铝铁、活性炭与聚合硫酸铁和聚合氯化铝铁三种强化混凝方式的混凝效果。结果证明，对于冬季黄河水的处理，利用活性炭与聚合硫酸铁和聚合氯化铝铁的强化混凝方式效果最优。     

硫酸铁及助凝剂处理上海合流污水试验研究

以硫酸铁为混凝剂配合不同的助凝剂，对上海合流一期污水中的污染物进行了混凝处理研究。采用了阳离子型聚丙烯酰胺(PAM)、聚乙烯醇(PVA)、一种自制的有机高分子聚合物(AN)这3种有机物以及活化硅胶(AS)为助凝剂，研究了不同硫酸铁加入量以及多个硫酸铁加入量条件下各种助凝剂不同剂量时的混凝处理效果。研究结果表明，采用硫酸铁为混凝剂的处理工艺可以有效去除合流污水中的SS、COD．TP和PO4^3--P。     

Invited review: Genetics and modeling of milk coagulation properties

Milk coagulation properties (MCP) are conventionally measured using computerized renneting meters, mechanical or optical devices that record curd firmness over time (CF_t). The traditional MCP are rennet coagulation time (RCT, min), curd firmness (a₃₀, mm), and curd-firming time (k₂₀, min). The milk of different ruminant species varies in terms of CF_t pattern. Milk from Holstein-Friesian and some Scandinavian cattle breeds yields higher proportions of noncoagulating samples, samples with longer RCT and lower a₃₀, and samples for which k₂₀ is not estimable, than does milk from Brown Swiss, Simmental, and other local Alpine breeds. The amount, proportion, and genetic variants (especially κ-casein) of milk protein fractions strongly influence MCP and explain variable proportions of the observed differences among breeds and among individuals of the same breed. In addition, other major genes have been shown to affect MCP. Individual repeatability of MCP is high, whereas any herd effect is low; thus, the improvement of MCP should be based principally on selection. Exploitable additive genetic variation in MCP exists and has been assessed using different breeds in various countries. Several models have been formulated that either handle noncoagulating samples or not. The heritability of MCP is similar to that of other milk quality traits and is higher than the heritability of milk yield. Rennet coagulation time and a₃₀ are highly correlated, both phenotypically and genetically. This means that the use of a₃₀ data does not add valuable information to that obtainable from RCT; both traits are genetically correlated mainly with milk acidity. Moreover, a₃₀ is correlated with casein content. The major limitations of traditional MCP can be overcome by prolonging the observation period and by using a novel CF_t modeling, which uses all available information provided by computerized renneting meters and allows the estimation of RCT, the potential asymptotic curd firmness, the curd-firming rate, and the syneresis rate. Direct measurements of RCT obtained from both mechanical and optical devices show similar heritabilities and exhibit high phenotypic and genetic correlations. Moreover, mid-infrared reflectance spectroscopy can predict MCP. The heritabilities of predicted MCP are higher than those of measured MCP, and the 2 sets of values are strongly correlated. Therefore, mid-infrared reflectance spectroscopy is a reliable and cheap method whereby MCP can be improved at the population level; this is because such spectra are already routinely acquired from the milk of cows enrolled in milk recording schemes.     

Thromboelastography in healthy dairy cows

Thromboelastography is a whole blood-based coagulation assay that can be used to investigate hypocoagulability and hypercoagulability, as seen with thromboembolic diseases and disseminated intravascular coagulation. Numerous coagulopathies due to different causes are reported in cows. The objective was to establish reference intervals for thromboelastography using the TEG 5000 (Haemonetics GmbH, Munich, Germany) with citrated whole blood samples and kaolin activation in dairy cows and to investigate possible thromboelastographic changes between cows in different lactation periods. An additional objective was to test the stability of samples for up to 100 h. Sixty blood samples from healthy Holstein-Friesian cows were examined. The samples were allocated to 3 different lactation groups (≤30 d postcalving, 31–99 d postcalving, ≥100 d postcalving). Thromboelastography was performed by using the TEG 5000 analyzer with citrated whole blood samples with kaolin activation. The calculated reference intervals were as follows: reaction time = 2.2 to 6.2 min, coagulation time = 0.8 to 2.0 min, angle α = 58.2 to 81.8°, maximum amplitude = 64.3 to 89.2 mm, and clot rigidity = 9.2 to 41.2 dyn/cm². The 3 different lactation groups showed no significant differences in TEG parameters. No significant difference was seen in samples stored for up to 48 h at room temperature, which indicates that delays in processing samples, such as those arising during transit, are not an issue.     

Influences of diffusion coefficient of 1-allyl-3-methylimidazolium chloride on structure and properties of regenerated cellulose fiber obtained via dry-jet-wet spinning

The diffusion dynamics of the cellulose/1-allyl-3-methylimidazolium chloride ([Amim]Cl) solution during coagulation of regenerated cellulose fiber in a nonsolvent bath was investigated in detail. According to Fick's second law of diffusion, the experimental data were fitted to obtain the diffusion coefficients of [Amim]Cl (D). The cellulose concentration, bath type, and temperature were varied to analyze their influence on the diffusion coefficient of [Amim]Cl. Furthermore, the dependence of the structure and properties of the regenerated fiber obtained via dry-jet-wet spinning on the diffusion coefficients were analyzed. Many defects were formed in the surface and cross sections of the regenerated fibers prepared with high diffusion coefficients. The crystallization and mechanical properties deteriorated with the increase in the diffusion rate of [Amim]Cl. Therefore, the diffusion coefficients of [Amim]Cl should be kept relatively low to enable the preparation of uniform-structured regenerated cellulose fibers. © 2019 Wiley Periodicals, Inc. J. Appl. Polym. Sci. 2019 , 136, 47609.     

炭黑废水的处理现状与发展

主要阐述了炭黑废水的产生,危害和几种处理方法以及炭黑处理新的发展趋势。回收的炭黑可以变废为宝,重新被利用。     

间位芳纶溶解及凝固性能研究

以二甲基乙酰胺(DMAc)、二甲基甲酰胺(DMF)、二甲基亚砜(DMSO)、1-甲基-2-吡咯烷酮(NMP)为溶剂,分别加入LiCl和CaCl_2制备溶解体系,研究了间位芳纶在这几种溶解体系中的溶解性能。再以H_2O-DMAc、H_2O-DMF、H_2O-DMSO、H_2O-NMP为凝固浴,研究了溶剂种类、芳纶溶液质量分数、离子浓度等对间位芳纶溶液的凝固性能的影响。结果显示:Li Cl-DMAc溶解体系具有更强的溶解性能;凝固值随凝固浴中凝固剂H_2O的含量的增加不断减小,而临界浓度几乎没有变化;随着凝固浴温度的增加,凝固值增大,临界浓度减小;凝固值随凝固浴中离子浓度的升高而增大,但临界质量分数则不断降低。另外,间位芳纶溶液的扩散系数随着凝固浴中H_2O的含量的减少不断减小,随着芳纶浓度的增加不断减小。