渣油加氢催化剂孔结构对反应活性的影响

在3L中型加氢试验装置上考察了渣油加氢脱硫催化剂孔结构对反应活性的影响，试验结果表明，当孔结构发生变化时，催化剂的脱硫、脱氮、脱残炭及脱金属反应活性呈现不同的变化规律。     

多壁纳米碳管的超声短切处理

采用超声方法对多壁纳米碳管进行短切处理，比较系统地考察了超声时间对纳米碳管的长度、孔结构和形貌的影响。结果表明，超声粉碎可以有效地短切多壁纳米碳管，随超声时间的延长，纳米碳管的长度显著减小。在超声处理120min后，纳米碳管被短切到平均长度为400nm。超声短切后的纳米碳管比表面积和孔容均显著增加。进一步延长超声时间，其比表面积和孔容反而下降。     

Diffusion of lignin macromolecules within the fibre walls of kraft pulp. Part I: Determination of the diffusion coefficient under alkaline conditions

The intrinsic rate of diffusion of soluble lignin from fibre walls to bulk liquor has never been determined previously because of experimental difficulties; for example, the diffusion rate determined in a stirred cell is affected by the mechanical action of stirring. In our work, the intrinsic rate of diffusion of lignin macromolecules from the fibre walls of a softwood kraft pulp was determined under alkaline conditions using a displacement cell which eliminated external heat and mass transfer resistances and pulp fibre disturbances. The effects of such experimental conditions as pulp bed height and liquid flow rate were studied. The diffusion rate can be described by a diffusion model for a hollow cylinder with a very wide range of diffusion coefficients. The diffusion rate increased with increasing pH. Our results provide a new understanding of the lignin diffusion process in fibre walls, which is affected by the size of lignin molecules and the pores, and by the electrostatic interactions between intrafibre pore walls and lignin.     

大、中孔发达活性炭的研制

。以大同精选煤为原料 ,并在制造过程中加入适量化学溶液 ,采用斯列普炉炭化、活化 ,可制得大、中孔发达、吸附性能改善的活性炭。     

Detonation Velocity of Emulsion Explosives Containing Cenospheres

The detonation velocity of an emulsion explosive containing hollow alumosilicate microspheres (cenospheres) as the sensitizer is measured. The size of the microspheres is 50–250 μm. The relations between the detonation velocity and the charge density and diameter are compared for emulsion explosives containing cenospheres or glass microballoons as the sensitizer. It is shown that for a 55 mm diameter charge, the maximum detonation velocity of the composition with cenospheres of size 70–100 μm is 5.5–5.6 km/sec, as well as for 3M glass microballoons. The critical diameter for the emulsion explosive with cenosphere is 1.5–2 times larger than that for the emulsion explosive with glass microballoons and is 35–40 mm. __________ Translated from Fizika Goreniya i Vzryva, Vol. 41, No. 5, pp. 119–127, September–October, 2005.     

磷铝酸盐水泥浆体的抗冻性研究

抗冻性是砼耐久性的重要方面,尤其影响北方地区砼工程的使用寿命。引气能提高砼的抗冻性,但同时又存在气泡的稳定性问题和砼其他性能的受损问题。若能提高砼中水泥浆体的抗冻性,则对提高砼耐久性更有意义。作者从宏观和微观两方面研究了磷铝酸盐水泥浆体的抗冻性,同时与硅酸盐水泥、硫铝酸盐水泥浆体进行了比较;采用压汞测孔方法测试了三种水泥浆体冻融前后的孔结构,并用分形理论分析了各自特征。结果证实:磷铝酸盐水泥具有优越的抗冻融性能,其自身优良的水化特性以及体系的低碱度是良好抗冻性的内在原因。     

液相合成纳米氧化锌及其光催化性能探讨

以硝酸锌和氢氧化钠为原料,分别以水和醇作为溶剂,采用液相直接沉淀法合成纳米氧化锌。在以水为反应溶剂条件下,研究了反应时间、反应温度、反应物浓度和反应物配比对纳米氧化锌中位径和形貌的影响,得到制备较小中位径及合适长径比纳米氧化锌的最优反应条件,即:反应时间为3 h、反应温度为70 ℃、锌离子浓度为0.5 mol/L、锌离子与氢氧根浓度比为1:2。在上述最优反应条件下,研究了不同醇溶剂对纳米氧化锌中位径、形貌及其光催化性能的影响。研究发现,随着溶剂碳链长度的增长,纳米氧化锌中位径呈现上下波动,无明显变化规律,形貌由球状向柱状发展,光催化性能总体不断减弱。     

具有高粘度分散相的油-水分散体系的液滴破碎与粒径分布研究

对湍流搅拌槽中原油-水分散体系的液滴破碎进行了研究。在不同的温度下原油表现出不同的流变学特征，对分散过程中的液滴破碎产生不同的影响。实验研究对比了不同温度下原油-水分散体系的液滴分布及最大稳定粒径，分析了触变性对破碎过程及最大稳定粒径的影响。经过模型计算与实验结果比较，发现以初始粘度计算的理论值预测最大稳定粒径更为合适。     

不同助烧结剂及造孔剂对SiC多孔陶瓷的影响

采用真空烧结方法制备了SiC多孔陶瓷，研究了不同助烧结剂Al2O3-Y2O3、Si以及不同造孔剂丙烯酰胺聚合物、羧甲基纤维素（CMC）对SiC多孔陶瓷形貌和气孔率的影响。结果表明：与Si相比较，Al2O3-Y2O3更有利于促进SiC的烧结；以Al2O3-Y2O3为助烧结剂的试样比以Si为助烧结剂的试样具有较高的气孔率。