残留CO2对石灰在转炉初渣中溶解的影响

 在转炉炼钢过程中,石灰快速溶解对转炉高效脱磷具有十分重要的意义,石灰溶解过程中熔渣/石灰界面处形成的2CaO·SiO₂产物层被认为是阻碍石灰溶解的关键因素。制备了具有两种不同CO₂含量的部分煅烧石灰石,采用浸泡法研究了部分煅烧石灰石在转炉初渣中的溶解行为,并与纯石灰、石灰石的溶解行为进行比较。结果表明,石灰石溶解时在液态熔渣中CaO的传质系数为石灰的2.1倍,残留CO₂质量分数为10%的部分煅烧石灰石的传质系数高达石灰石的6.7倍。在CO₂质量分数为0～43.5%时,石灰的溶解速率先增大后减小。石灰溶解过程中形成的2CaO·SiO₂层严重阻碍了FeO_x的扩散,从而减缓了石灰的溶解。与石灰不同,石灰石分解产生的CO₂能够破坏2CaO·SiO₂层并破坏自身结构,有利于熔渣的渗透,这也适用于残留CO₂的部分煅烧石灰石。制备纯石灰的过程中为了确保石灰芯部完全煅烧,因此极易导致石灰外表面发生过烧,而制备部分煅烧石灰石能在一定程度上解决表面过烧的问题。此外,与石灰石相比,部分煅烧石灰石由于表面是石灰外壳,溶解初期其表面附近的炉渣温降相对更低,能够避免溶解初期出现停滞阶段。在转炉富余热量有限的情况下,部分煅烧石灰石的石灰替换比高于石灰石,这取决于部分煅烧石灰石中的CO₂残留量。     

不同品种磷肥在土壤中的退化研究

对钙镁磷肥（FMP）、过磷酸钙（SSP）和部分酸化磷肥（PAPR）在河南郑州西岗沙土和河南西华县潮土中的退化情况进行了研究。     

Preparation of glycol derivatives of partially hydrogenated soybean oil fatty acids and their potential as lubricants

Glycol diesters and mixtures of mono- and diesters have been prepared from methyl esters of partially hydrogenated soybean oil fatty acids and diethylene, dipropylene, neopentyl and triethylene glycols. The catalyst used in these reactions was a mixture of calcium acetate/barium acetate (3∶1, w/w). The reactions were carried out under nitrogen with 0.5% catalyst at temperatures in the range of 190–275°C. Borated esters of mixed mono- and diesters were prepared with 0.33 equivalent of boric acid per 1.0 equivalent hydroxyl group on the ester. Refractive indices, viscosities, and flash and fire points were determined for diesters, mixed mono- and diesters, and mixed diesters and borated esters. The viscosities, flash points and fire points indicate that these esters can be used as a component of lubricating oils. Wear-prevention characteristics of mixed diesters and borated esters indicated that they can be used as antifriction additives in lubricating oils. Lecture presented at the joint meeting of the International Society for Fat Research and the American Oil Chemists' Society in Toronto, May 10, 1992.     

随机非线性和部分转移概率未知时马尔科夫系统的H1控制

研究上述系统时: 1) 利用了非线性的概率分布信息; 2) 利用了转移概率中已知部分和未知部分的关系. 利用李雅普诺夫泛函方法和线性矩阵不等式方法, 本文得到了使得系统随机稳定的充分条件并得到了相应的反馈控制增益. 文中最后给出的例子表明了所建立模型和分析方法的有效性.     

阳离子表面活性剂对HPAM溶液表观粘度的影响

研究了不同的阳离子表面活性剂对部分水解聚丙烯酰胺(HPAM)溶液中的表观粘度的影响。     

用于光刻系统仿真的多边形处理算法

为提高光刻仿真效率,通过对光刻原理进行研究,提出了2种多边形处理算法,将掩模上的多边形图案进行切分优化,将其划分成若干矩形或三角形。在Linux环境下应用C语言设计出一个完整的光刻仿真系统,设计的具体光学参数为:光源波长为193nm,数值孔径为0.3~0.8,部分相干系数可调范围为0.2~0.8,可一次性仿真1μm×1μm到10μm×10μm范围内的45 nm~0.18μm工艺的复杂版图,并通过多次实验进行验证。实验结果表明:原版图图像的边缘细节得到保留,且该算法有效地减少了光刻模拟的计算复杂度与计算时间,整体效率提升20%以上,为当前智能传感器系统芯片的制造节省了宝贵时间。     

Comparison of single and coastal superphosphate for subterranean clover on phosphorus leaching soils

Coastal superphosphate, a partially acidulated rock phosphate (PARP), is being considered as an alternative fertilizer to single superphosphate for pastures in high rainfall (> 800 mm annual average) areas of south-western Australia. The effectiveness of single and coastal superphosphate, as P fertilizers, was measured in two field experiments using dry herbage yield of subterranean clover (Trifolium subterraneum). The experiments were started in April 1990 and were terminated at the end of 1993. In the years after P applications, soil samples were collected each January to measure Colwell soil-test P, which was related to plant yields measured later on that year, to provide soil P test calibrations.Relative to freshly-applied single superphosphate, the effectiveness of freshly-applied coastal superphosphate and the residues of previously-applied single and coastal superphosphate were less effective in some years (from 3% as effective to equally effective), and up to 100% more effective in other years. This large range in effectiveness values in different years is attributed to different climatic conditions. Soil P test calibrations were different for soils treated with single or coastal superphosphate. The calibrations were also different for different yield assessments (harvests) in the same year, and in different years. Consequently soil P testing can only provide a very crude estimate of the current P status of the soils.     

A discussion of the methods for comparing the relative effectiveness of phosphate fertilizers varying in solubility

Because various phosphate (P) fertilizers differ widely in their solubility, it is commonly observed that crop response to P fertilizers varies under the same soil and crop conditions. Furthermore, a major problem encountered in the methods for determining the relative effectiveness (RE) of water-insoluble P fertilizer (e.g., phosphate rock) with respect to water-soluble P fertilizers, e.g., single superphosphate (SSP) and triple superphosphate (TSP), is that their growth response curves are usually nonlinear and often do not share a common maximum yield. In this paper, we review and discuss the advantages and disadvantages of the three most commonly used methods for calculating the RE of phosphate rock with respect to TSP (or SSP). The three methods are vertical comparison, horizontal (substitution rate) comparison, and linear-response comparison.     

次氯酸钠氧化法测定聚丙烯酰胺浓度的研究

阐述了次氯酸钠氧化法（浊度法）测定部分水解聚丙烯酰胺浓度的反应机理，研究了聚丙烯酰胺的相对分子质量、次氯酸钠溶液浓度、反应时间对吸光度值的影响，针对大庆油田杏二中三元复合驱采出水中含有碱和表面活性剂、pH值高、黏度大、富集硫化物和亚硫酸根等特点，提出采用过硫酸铵一浊度法检测三元复合驱采出水中聚丙烯酰胺浓度。     

严寒地区大型倒虹吸工程管道应力及水力安全控制

新疆北疆供水工程跨越吉拉沟大洼槽的三个泉倒虹吸,跨度11 km,内径2.8 m,工作水头160m,是国内外同类工程中综合难度较高的大型倒虹吸工程,在结构强度、材料工艺、安装敷设、工程质量方面都有极高的要求,特别是高水头管道运行、充水、放空、水锤防护等各种工况下的水力安全控制问题,高温差与严寒条件下管道的应力应变问题尤为突出。对该工程设计、科研、施工及运行管理方面的经验进行介绍,对其在新技术、新材料、新工艺等方面取得的理论研究和技术创新成果进行总结,研究认为:工程总体布置合理,工程运行后监测资料及工程安全评价表明各项性状指标良好,通过模型试验研究确定的闸门开度、关闭速率、充水排气、放空排水等水力安全控制关键技术科学合理,为严寒地区大型倒虹吸工程的技术发展提供借鉴。