酸增殖源及其在化学增幅抗蚀剂体系中的应用

介绍了酸增殖机理、酸增殖源的种类、典型化合物在化学增幅抗蚀剂体系中的应用及对灵敏度的提高 ,提出在计算机直接制版版材研究中的应用     

丙烯酸接枝线形低密度聚乙烯的热学行为及结晶形态

利用差示扫描量热仪研究了丙烯酸接枝线形低密度聚乙烯（PE-LLD-g-AA）的热学行为，结果表明，与纯线形低密度聚乙烯（PE—LLD）相比，PE-LLD-g-AA的熔融温度（Tm）略有增加，结晶温度（Tc）增加大约4℃，熔融焓（AHm）随AA含量的增加而降低。还利用差示扫描量热仪研究了PE—LLD和PE—LLD-g—AA的等温结晶动力学，用扫描电子显微镜观察了PE—LLD-g—AA等温结晶形态。结果表明，PE-LLD-g-AA的结晶速率大于纯PE—LLD的，随着接枝率的增加，PE-LLD的球晶半径减小，接枝到PE—LLD分子链上的AA分子起到了成核剂的作用。     

大冶硫酸四系列干吸塔结构特点

以干燥塔为例，介绍大冶公司硫酸四系列干吸塔的结构特点。除捕沫层简体及出气管为316L不锈钢外，其余塔体均为碳钢内衬瓷砖结构。塔底为球形底，中心排酸。采用槽管式分酸器，分酸点密度为43个/m^2，设可调闸板以保证各槽酸量均匀；闸板外设置带孔板的分布板，以消除进口酸的冲击，保证槽内酸液面平稳。比较了该塔与常规塔的不同之处，强调了设备节点的优化设计。     

Synergistic Influence of Poly(4-Vinylpyridine) and Potassium Iodide on Inhibition of Corrosion of Mild Steel in 1M HCl

The corrosion and inhibition behavior of mild steel in 1 M HCl in the presence of poly(4-vinylpyridine)(P4VP) and potassium iodide (KI) was investigated using weight loss measurements, potentiodynamic polarization studies and impedance measurements. The inhibition efficiency increased with increasing P4VP concentration. The inhibiting action of P4VP is considerably enhanced by the addition of potassium iodide. The adsorption of this compound either alone or in combination with iodide ions on the metal surface is found to obey Lamgmir's adsorption isotherm. The experimental results suggest that the presence of iodide ions in the solution increases the surface coverage and, therefore, indicate the joint adsorption of P4VP and iodide ions. On the other hand, it was found that the inhibiting effect of P4VP and (P4VP + KI) increased with increasing temperature of the corrosion medium. The presence of these species in the solution decreases the double layer capacitance and increases the charge transfer resistance, both derived from Nyquist plots obtained from a.c. impedance studies. The variation of charge transfer resistance with time suggests that the inhibitive action of (P4VP + KI) depends mainly on the protective inhibitor film formed on the steel surface.     

甲氧胺盐酸盐的含量测定方法

提出了以酚酞为指示剂，氢氧化钠为滴定剂测定甲氧胺盐酸盐含量的方法。测定了甲氧胺盐酸盐的离解常数Ka，考察了干扰因素对测定的影响。结果表明，干扰物质NH4Cl在样品中的含量小于5％不影响测定。该方法具有简便、快速，准确等特点,测定了数批样品结果较满意。     

稀磷酸澄清槽泥浆泵改用单螺杆泵的实践

磷酸生产中输送稀磷酸澄清槽淤渣的泥浆泵，各厂的运行情况都不够理想。介绍了三种类型泥浆泵的运行情况，针对淤渣中会出现块结垢物影响泥浆泵长期运行，在单螺杆泵进料腔内设置破碎送料器后，取得了较理想的效果，从而提高了磷酸装置的运转率和磷得率。     

固体酸催化合成草酸二乙酯的应用研究

以粉煤灰、活化剂、硫酸为主要原料经活化、陈化、浸泡、焙烧等处理制得的固体酸催化剂，应用于草酸二乙酯的合成中取得了良好的催化效果。实验发现，当醇酸摩尔比为3．5、催化剂用量为草酸的5％、反应时间在4h时，酯产率可达81.8％，该催化剂具有贮存稳定性高、可重复使用、制备工艺简单、原料成本低廉等特点，是一种易于工业化应用的环境友好固体酸催化剂。     

电解法处理利福霉素SV钠废渣分离液的研究

根据电化学原理，采用电解法，利用铁屑与炭粒作电极，处理利福霉素SV钠药渣分离液，讨论各种因素对分离液污染物作效果的影响，COD去除率可达91．8％左右，脱色率可达95％左右。     

聚乙烯醇存在下耐尔蓝－铈钼、钪钼杂多酸体系连续光度测定铈和钪

在聚乙烯醇（ＰＶＡ）存在下，耐尔蓝（ＮＢ）与铈钼、钪钼杂多酸络阴离子形成离子缔合物，其最大吸收均位于５８５ｎｍ，表观摩尔吸光度分别为εｃｗ＝３．５２×１０６和εＳｃ＝３．５９×１０＿５Ｌ·ｍｏｌˉ１·ｃｍˉ１，铈和钪服从比耳定律的浓度范围分别为０～０．８μｇ／２５ｍｌ和０～２．０μｇ／２５ｍｌ，测定极限分别为１．３ｎｇＣｅ／ｍｌ（ｎ＝１０）和３．０ｎｇＳｃ／ｍｌ（ｎ＝７），对于０．０２μｇＣｅ／ｍｌ或０．０４μｇＳｃ／ｍｌ测定的相对标准偏差分别为２．７％（ｎ＝９）和２．８％（ｎ＝１０），离子缔合物的摩尔比分别为Ｃｅ：Ｍｏ：ＮＢ＝１：６：４和Ｓｃ：Ｍｏ：ＮＢ＝１：１２：３。本法用于地质标样分析，结果满意。     

Continual conversion of free fatty acid in rice bran oil to triacylglycerol by immobilized lipase

Rice bran oil containing 30–50% free fatty acid was continually converted to an oil containing more than 75% of triacylglycerol (TG) by means of immobilized lipase. The reaction was carried out at 60°C for 24 h with dehydration and reactant mixing by dry nitrogen flow under a positive nitrogen atmosphere. Enzymatic TG synthesis with evaporation by heating was not suitable because of the increasing peroxide value of the oil. Part of this article was presented at the annual meeting of the Japan Oil Chemists' Society at Sendai, Japan, October, 16, 1990.