回转窑托轮安装方案调整实践

山东东华水泥有限公司5000t/d熟料生产线三档支承回转窑为φ4.8m×74m,在其托轮安装到位并进行二次灌浆后,进行窑筒体吊装对接前检查发现,托轮与轮带的制造尺寸与设计图纸不符。对此,经过分析研究确定,采用适当调整回转窑的中心线高度(将回转窑中心线高度下降5mm)和托轮中心距的方法,来实现回转窑三档处中心点在一条直线上。生产实践表明,回转窑在此方案安装投产以来,没有出现掉砖和托轮轴承发热现象,回转窑运转良好,达到了使用要求。     

从稻米糠中提取植酸的研究

介绍了从稻米糠中提取植酸的方法,研究了浸取溶液酸度、浸取时间对提取率的影响,找出了提取的最佳工艺条件,提取率达9%。     

辊压机水泥联台粉磨系统生产设计应注意的问题

山水集团新建粉磨站均采用辊压机和水泥磨组成的联合粉磨工艺，全部采用了国产化设备，且所建生产线均在短期内顺利实现了达标达产。文章概要介绍了该类粉磨生产线的主机配置及工艺流程；重点分析了为确保该类生产线的快速建成、高效益运行．在设计和生产管理中应该注意的相关问题和细节。     

秸秆黄腐酸包膜尿素在水稻上的应用效果

在石灰性土壤上进行田间小区试验，结果表明，秸秆黄腐酸包膜尿素能满足水稻生长最大效率期对营养的要求，有利于有效穗的分化，提高结实率。等氮量试验平均增产9．6％，等重量试验平均增产7．4％。     

Effect of granule size and the placement geometry on the efficiency of urea supergranules for wetland rice grown on a permeable soil

In a laboratory experiment 5 cm depth of water was allowed to percolate daily down through a 15 cm thick soil (Typic Ustipsamment) layer. It was observed that leaching losses of urea supergranules (USG)-N could be decreased by about 20% by the placement of four 0.25 g granules at four points instead of one 1 g granule at one point. In field microplots, the placement of approximately 30 granules of 0.30 g size instead of 9 granules of 1.00 g size resulted in reduced leaching of USG-N and, in turn, increased rice yield. In a follow-up field study, the advantage of more frequently placed USG was confirmed. As compared with 1 g USG placed in the usual manner in the center of four rice hills, increasing the density of placement in soil produced 15% more rice grain. Further increase in rice yield could be obtained by increasing the number of USG placed in the soil and decreasing the size of the granule from 1.00 g to 0.70 or 0.35 g. With USG of 0.35 and 0.70 g yields were equal or sometimes even slightly higher than with split application of prilled urea on a heavily percolating, low-CEC, light-textured soil.     

An economical synthesis of the major sex attractant of the oak leaf roller—cis-10-tetradecenyl acetate

The major sex attractant of the oak leaf roller (Archips semiferanus Walker),cis-10-tetradecenyl acetate (I), was synthesized in 55–62% overall yield by a highly economical route from inexpensive azelaic acid (II).Authorized as Paper No. 4779 in the Journal Series of the Pennsylvania Agricultural Experiment Station.     

水稻全生育期应用腐植酸液肥的效果初报

腐植酸液肥——科力素(KLS)对水稻生长发育影响较大。试验表明,水稻苗床施用KLS明显刺激秧苗生长,处理区根长、根数、地上地下百株鲜重及带蘖率都好于对照区。不同生育时期喷施KLS,水稻发育加快,自返青期开始到成熟期都有不同程度提前,一般早熟3～5d。产量增加幅度为4.7%～21.1%,平均增产11.3%,亩增效37.44～204.48元,平均为99.2元,产投比约为12∶1。     

直播稻田化学除草试验

直播稻田用不同药剂在播种后各一次化除或播种后两次化除都具有很好的除草效果。播后前期是化学除草的关键时期播后前期每６６７米＾２用１０％苄嘧黄隆１５克＋６０％丁划胺６０毫升，１０％苄嘧黄隆１５克＋５０％杀草丹１５０毫升，１７．２％新幼禾葆２４０克或１５．８％幼禾葆２００克防铲均较好。     

Zero-<Emphasis Type="Italic">trans</Emphasis> shortening using palm stearin and rice bran oil

Several pilot-scale trials reported in this paper, using palm stearin-rice bran oil (PS-RBO) blends, obviously did not contain trans FA (TFA), whereas the commercial products were found to contain 18–27% TFA. The effects of processing conditions such as rate of agitation, crystallization temperature, and composition of the blends on the crystal structure of shortenings were studied. The products were evaluated for their physicochemical characteristics using DSC, X-ray diffraction (XRD), HPLC, and FTIR techniques. The formulation containing 50% PS and 50% RBO showed melting and cooling characteristics similar to those of hydrogenated commercial “vanaspati” samples. Analysis of the FA composition revealed that the formulated shortenings contained 15–19% C_18∶2 PUFA. Tocopherol and tocotrienol contents of the experimental shortenings were in the range of 850–1000 ppm with oryzanol content up to 0.6%. XRD studies demonstrated that the crystal form in the shortenings was predominantly the most stable β′ form, and there was less of the undesirable β form.     

Electroantennogram responses ofCampoletis sonorensis (hymenoptera: Ichneumonidae) to chemicals in cotton (Gossypium hirsutum L.)

Combined gas chromatography-electroantennogram (GC-EAG) recording ofCampoletis sonorensis (Cameron) responses to cotton plant volatile chemicals was performed.C. sonorensis antennal olfactory receptors respond differentially to green leaf, mono-, and sesquiterpene chemicals that have been identified previously in cotton. EAG depolarizations to green leaf chemicals were greater than to terpenes.