隧道窑烟气废热回收利用技术

本文主要介绍了该项目在湖南省铜官陶瓷总公司推广应用实例，论述本技术改革传统隧道窑预热带及冷却带的结构．开发利用隧道密的烟气度热．进一步挖掘冷却带余热的潜力．使隧道窑余热利用率由３０％左右提高到５０％以上。用来烘干陶瓷半成品、石膏模、匣体取代锅炉蒸汽干燥，节能显著。     

Hydrodynamic characteristics of a FCC regenerator

The hydrodynamic and gas mixing characteristics have been determined in a FCC regenerator (0.48 m I.D.x3.4 m high) with FCC particles. Solids holdup in the dense bed decreases with increasing gas velocity, but it increases in the freeboard region. The bubble/void fraction increases with an increase along the bed height at a given gas velocity and increases with increasing gas velocity at a constant bed height. Backmixed tracer gas at the wall region is higher than that at the center region of the bed. The gas backmixing coefficient decreases with increasing gas velocity.     

天然气年产4万吨甲醇联产年产2.5万吨合成氨代替重油设计

利用现生产重油制氨的1000m~3(V_n)(O_2)/h空分,建设天然气并联换热蒸汽转化串纯氧部分氧化制甲醇和氨两用合成气,成为4万吨/年甲醇联产2.5万吨/年氨的生产单元组合,既节能节气、降低投资和生产消耗及成本,又充分利用现有设备发挥生产能力,同时还可增加产品和产量。     

一种用于气液间传质的新型轴流式叶轮

一种用于气液间传质的新型轴流式叶轮黄庆民林齐浩李启恩（华南理工大学化学工程研究所，广州５１０６４１）关键词气液传质轴流式叶轮１前言在液体搅拌器中，轴流式叶轮由于功耗较小且泵吸量较大而被广泛采用。在气液两相搅拌器中，由于轴流式叶轮有气泛问题，一般均采...     

胺菊酯·高效氯氰菊酯气雾剂的气相色谱分析

介绍了 0 .2 8 %胺菊酯·高效氯氰菊酯气雾剂的气相色谱分析方法。选用 5 %SE - 30 ChromsorbWAW -DMCS(15 0～ 180um)色谱柱 ,以邻苯二甲酸二正辛酯为内标物进行定量分析测定 ,该方法简单、快速、准确、适用。结果表明胺菊酯和高效氯氰菊酯的标准偏差分别为 0 .2 4 %和 0 .11% ;变异系数分别为 0 .94 %和 1.74 % ;平均回收率分别为 99.6 4 %和 99.95 % ;线性回归系数分别为 0 .9999和 0 .9998。     

气—液鼓泡塔中流动域和气含率的分布

利用压力传感器测定了气、液两相鼓泡塔内不同轴、径向位置上压强的脉动信号,分析了压强的脉动特征,计算了各种操作条件下塔内不同轴向位置截面上的平均气含率,发现在不同操作条件下,塔内可能出现不同的流动域分布,即全塔均匀鼓泡域、全塔过渡域、全塔湍动鼓泡域以及均匀鼓泡域,过渡域和湍动鼓泡域中的相邻2种或3种流域同时出现在塔内不同高度上。提出了不同轴向位置流域转变的判据。并发现,同一截面的不同径向位置基本处于同一流域内。同时研究了鼓泡塔内气含率在轴向上的分布规律,给出了不同流动域内气含率的关系式。     

FORMATION AND FLOW OF GAS BUBBLES IN A PRESSURIZED BUBBLE COLUMN WITH A SINGLE ORIFICE OR NOZZLE GAS DISTRIBUTOR

The characteristics of gas bubbles in a 5 cm diameter bubble column equipped with a single orifice of 1,3 or 5 mm diameter were investigated under system pressure of 0.1-15 MPa. The formation of gas bubbles was strongly affected by the system pressure. Under high pressures a dispersed gas jet was formed at gas velocities where spherical gas bubbles would have been formed at atmospheric pressure. The critical gas velocity between the bubbling regime and the jetting regime was correlated with the liquid phase Weber number and the gas phase Reynolds number based on the gas velocity at the orifice. Bubble size and gas holdup in the main part of the bubble column were also affected by the bubble formation pattern at the distributor     

干气密封在炼油厂离心压缩机上的应用

介绍了 3种不同类型的干气密封形式及其在炼油装置中的使用情况,分析了干气密封的特点和实际使用中应注意的问题。     

A SIMPLE METHOD FOR STUDYING THE KINETICS OF GAS-SOLID REACTIONS IN A FLUIDIZED BED REACTOR

A methodology for studying the kinetics of gas-solid reactions in a fluidized bed reactor is presented. This procedure is based on the analysis of the response of the system (flue gases) when batches of solids of different weight are added to the reactor. The method has been applied to the study of limestone particle calcination. The calcination rate constants obtained are in good agreement with those found in the literature. The method offers the advantage of simplicity and avoids the use of model assumptions or empirical correlations.     

烟气轮机运行中动平衡破坏的原因分析及维护措施

对引发烟气轮机动平衡破坏的原因进行分析 ,并举例加以说明 ,进而提出了烟气轮机平稳运行的维护措施