Ⅰ型热致液晶聚芳酯纤维的耐酸碱性

用硫酸和氢氧化钠溶液对Ι型热致液晶聚芳酯(TLCPAR)纤维进行处理,研究了不同浓度和处理时间对TLCPAR纤维的影响。试验结果表明:氢氧化钠处理不会改变纤维的化学结构,硫酸处理会使纤维表面发生氧化;经过酸碱处理后,TLCPAR纤维表面出现了刻蚀现象。当硫酸质量分数小于40%、氢氧化钠质量分数小于20%时,处理180 min后,TLCPAR纤维强度保持率均在80%以上,表明TLCPAR纤维具有较好的耐酸碱性能。     

ECS-100 DCS控制系统在离子膜制碱装置中的应用

介绍某公司引进的离子膜制碱装置采用国产DCS系统的原由，系统的结构及特点。详细论述ECS-100 DCS在装置的特殊控制、顺序控制、联锁等方面的应用情况。     

Effect of alkali and alkaline earth metals on nitrogen release during temperature programmed pyrolysis of coal

Formation of HCN, NH₃, and N₂ during fixed-bed pyrolysis at 10K min⁻¹ has been studied using coal samples after partial demineralization followed by addition of metal hydroxides from aqueous systems. Without additives, NH₃ is the predominant product at ≤ 700°C, showing the two peaks in the formation rate profile, whereas N₂ is the only product at ≥ 800°C. The presence of NaOH, KOH and Ca(OH)₂ promotes considerable NH₃ formation between 450 and 600°C, but in contrast suppresses HCN formation in this region. The Ca shows the largest effect on both the promotion and suppression. It is likely that the NH₃ increased by Ca addition arises partly from HCN, but mainly from secondary reactions of tar-N. These hydroxides affect N₂ formation in quite different manners: the Na decreases the rate between 700 and 950°C, and the K changes it less significantly than the Na, but the Ca remarkably increases the rate in a low temperature region of 550–700°C. These different features are discussed in terms of solid-phase reactions of alkali metal carbonates with char-N and secondary decomposition reactions of tar-N on CaO particles. As a result, total conversion of coal-N to HCN, NH₃ and N₂ up to 1000°C increases in the sequence of Na < none < K < Ca.     

乙二醇单丁醚为溶剂制备共轭亚油酸的研究

以乙二醇单丁醚作为溶剂,KOH作催化剂,碱催化异构化法用豆油制备共轭亚油酸。通过正交设计,紫外光谱分析考察了4种因素对亚油酸转化率的影响,并得出制备高亚油酸油脂合适的工艺条件:反应温度135℃,反应时间3 h,强碱催化剂与原料质量比为0.4∶1,原料与溶剂质量比为2∶3。在此条件下,亚油酸的平均转化率达到96.8%。结果表明,该溶剂能使反应在均相体系中较为温和的温度条件下较短的时间内完成。     

沸石的碱处理溶解

晶体的溶解与晶体的生长存在着密切的联系，详细研究沸石晶体的溶解行为将有助于更好的理解沸石晶体的生长机理。鉴于目前对沸石晶体的碱处理溶解行为的研究尚处于初始阶段，所以从沸石碱溶解的几点关键内容出发，如沸石的硅铝比对沸石碱处理的影响，焙烧“活化”后沸石的碱处理溶解行为的变化，沸石与其无定形前驱物的溶解性差异以及沸石的溶解机理和溶解动力学方程方面，综述了有关沸石碱处理溶解研究方面的最新动态。     

龙须草碱木素特性的研究

用化学方法和波谱方法研究了龙须草减木素（ESL）的结构特性，并与杨木和麦草碱水素作了比较。ESL是一种绩合程度较高的木素，甲氧基含量较低，而酚羟基和羧基含量较高，结合相对分子质量测定结果可知，在蒸煮时生成较多的小分子产物，使相对分子质量分布较宽。C_9单元式表明ESL中的不饱和度较低，波谱分析表明，ESL中的共轭酯键已大部分断裂。与ESL相连的碳水化合物主要是聚阿拉伯糖降解生成的碎片。     

核工业专用橡胶型可剥掩蔽涂料的研制和应用

介绍了核电、核能工业专用橡胶型可剥掩蔽涂料的研制和应用,选用新型含有苯基的聚丁二烯弹性体为基料,加入耐酸、耐辐照的颜填料和防黏剂、偶联剂及N-13a固化剂配成JF系列常温固化的核电、核能工业专用橡胶型可剥掩蔽涂料,该涂料耐酸碱、耐辐照,防污性能优良。     

湿式空气氧化法处理乙烯废碱液装置的技术改造

针对中国石化齐鲁石化公司烯烃厂乙烯装置废碱液处理系统在试运转过程中存在的问题,通过分析原因,提出并实施改进工艺的相关措施,得到一组适宜的工艺操作参数,保证了废碱液湿式空气氧化装置的稳定运行。     

Evidence for non-site-isolation in ZSM-5 from ion-exchange and catalytic studies

Ion exchange of HZSM-5 samples with alkali metal cations, using metal chloride solutions, results in partially exchanged zeolites, MHZSM-5, M = Li, Na, K or Cs. The degree of exchange is found to increase with increasing ionic radius of the cations. The catalytic properties of the alkalized zeolites were evaluated using the reaction conditions under which the catalytic activity of the HZSM-5 samples in terms of n-hexane cracking is proportional to the aluminium content. From the residual catalytic activity exhibited by the Na-, K- and CsHZSM-5 samples it is concluded that each of the larger Na⁺, K⁺ and Cs⁺ ions is influencing more than one AlO ₄ ^– tetrahedron, implying that the aluminium sites in ZSM-5 are not isolated. The ion-exchange results are then interpreted in terms of non-isolated aluminium sites. The ion-exchange and catalytic properties of the zeolites as a function of aluminium content are also discussed.     

黄磷尾气净化脱除磷化氢、硫化氢中试试验

采用自制的催化剂JC-4,设计出碱洗-催化氧化工艺对黄磷尾气进行深度净化处理。中试试验结果表明:常压、100℃、尾气流量为36~50 m3/h、氧气体积分数为1.2%~1.5%时,PH3的脱除率接近100%,出口质量浓度低于1.0 mg/m3;碱洗单元可以除去90%的H2S,经过催化氧化单元可以进一步脱除H2S,净化效率接近100%,出口质量浓度低于1.0 mg/m3;催化剂经100~200 h需要再生,400 h后需要活化,再生和活化处理后的催化剂性能良好。