高碳醇磷酸酯加脂剂的合成与分析

以高碳醇为原料，采用P2O5溶剂法合成磷酸酯。探讨了P2O5溶剂的选择原则，确定10^#机油作为P2O5的分散溶剂，其10^#机油与P2O5质量比为2．5：1．0。实验表明，P2O5溶剂法解决了P2O5传统法加料时易吸潮、结块、炭化、反应不均匀和反应初期过于激烈等缺陷；其反应产物中磷酸单双酯的摩尔比、高碳醇转化率及总酸值均比传统法有了明显的提高，且产物色泽浅于P2O5传统法合成的磷酸酯；水解反应能进一步提高产物中磷酸单双酯的摩尔比和高碳醇转化率，水解后磷酸单双酯的摩尔比由3．96上升到4．16．高碳醇转化率由81．5％提高到88．7％。电位滴定法分析测定磷酸酯组分含量时发现，氯化钙溶液(10％)的最低加入量为11．0mL。     

染料分散剂新原料-高沸醇木质素的研制

采用1，4-丁二醇水溶液为溶剂的高沸醇溶剂法，从松木，杉木，稻草等原料制备纤维素与高沸醇木质素。使用上述原料，在70%-90%1，4-丁二醇水溶液中添加少量催化剂。并在190℃-220℃条件下蒸煮1-3小时后，分离反应产物，得到固体纤维素与高沸醇木质素-丁二醇溶液，不溶于水的高沸醇木质素通过加水沉淀的方法。从反应后的液体混合物中分离。高沸醇木质素具有较高的反应活性。灰分含量很低。适于制备新型染料分散剂，有广泛应用前景。     

Partition coefficient of diglycerides in crystallization of palm oil

Crystallization of palm oil with and without solvent was carried out over a temperature range of 10–25°C. The yields of olein, the diglyceride contents, and compositions of the stearin and olein phases were determined by thin-layer and gas-liquid chromatography. The three major diglycerides, analyzed as C₃₂, C₃₄, and C₃₆, are mainly dipalmitoyl glycerol, palmitoyloleoyl glycerol, and dioleoyl glycerol. In crystallization without solvent, C₃₂ (PP) had a strong affinity for the stearin fraction and C₃₆ diglycerides concentrated in the olein phase. The partition coefficient of diglycerides between the olein and stearin phases was temperature-dependent and was influenced by the type of solvent used. Although solvent enhances the diglyceride partition into the olein phase, partitioning is more effective at low temperatures and with acetone as the solvent for fractionation.     

室温固化双组分水性木器涂料

一种新颖的室温固化双组分水性木器涂料与相应的单组分涂料相比,其显著特点涂膜有极好的附着力、更高的硬度、优异的耐水、耐烫、耐溶剂和抗粘连及耐污渍性等。其配漆后的适用期室温下可达30d以上,涂料的综合性能可与溶剂型漆相媲美。     

静压支承技术在海水淡化旋转式能量回收装置中的应用

海水淡化旋转式能量回收装置（RERD）高、低压流体间的泄漏主要在转子与端盘的配合间隙中发生，这种泄漏直接影响到装置的能量回收效率水平。本文通过在平面端盘上引入阻尼孔和静压支承槽，构建了静压支承端盘方案，将静压支承技术应用到自主开发的电驱RERD装置中，以解决其运行过程中泄漏量大、能量回收效率低等问题。在转子与上、下端盘配合总间隙为0.04mm、转子转速为500r/min的条件下，RERD分别使用平面端盘和静压支承端盘进行对比实验研究。结果表明，在操作压力为4.5MPa和处理量为13m³/h的工况下，与平面端盘相比，采用1^#静压支承端盘（静压支承槽槽宽为2.0mm）时，装置的泄漏量从0.45m³/h减小至0.28m³/h，能量回收效率从91.3%提升至92.7%。采用2^#静压支承端盘（静压支承槽槽宽为3.0mm）的RERD在相同工况下，装置的泄漏量可降低至0.11m³/h，能量回收效率提升到95.0%。上述研究显示静压支承技术对于减小RERD装置泄漏量、提高装置效率具有显著的效果，对RERD装置密封结构设计与优化具有指导意义。     

两液相生物反应器研究进展

介绍了两液相反应器的进展及存在问题，两液相反应器仍处于试验阶段，其主要问题是生物催化剂在界面的聚集损失活性等。     

Solvent extraction of oil from soybean flour II— pilot plant and two-solvent extractions

The process of grinding soybeans to a fine flour and extracting the flour with hexane was studied on a pilot plant scale. The crude oil from the pilot plant study had 15 ppm phosphorus and was suitable for physical refining after a light acid pretreatment and bleaching. The refined oil showed a Lovibond color of 1.4 yellow and 0.3 red. The pilot plant study also showed that grinding of the soybeans and the separation of solid from miscella were the most difficult steps in solvent extraction with fine flour. A laboratory study on separation of miscella from meal by aqueous ethanol reduced the hold-up volume, but it did not remove all the miscella. A test with betacarotene showed that only the miscella outside the flour particles was displaced. Aqueous ethanol solutions used as a second solvent extracted additional nontriglyceride materials (primarily phospholipids) from the meal. Also, the free fatty acid content of the oil was increased with aqueous ethanol solution wash. The quality of the extracted crude oil was lowered by using a second solvent, but it had the advantage of needing only one centrifugation to separate miscella from meal.     

常减压蒸馏装置配剂方法比较

对常减压装置的三种配剂方法进行分析比较，从而选出经济、合理的配剂方法。     

丙碳脱碳溶剂的改进研究

介绍一种由丙碳、叔胺和少量活化剂构成的复合溶剂的开发，并详细地测定了不同压力和操作工况下，这种复合溶剂对ＣＯ２的吸收和解吸性能，以及溶剂的缓蚀性能和抗氧化性能．实验证明这种复合溶剂与纯丙碳相比，具有吸收容量大、速率快、脱碳净化度高、对设备无腐蚀等特点，对改进现行的丙碳脱碳工艺具有应用价值．