普通热轧钢材的合理洁净度及生产工艺探讨

钢凝固前、后生成的非金属夹杂物形貌和在钢中的分布特点不同,凝固前生成的夹杂物尺寸较大,在钢中随机分布,主要影响钢材的疲劳强度和延性等性能。凝固后生成的夹杂物尺寸小,主要在晶界富集析出。硅锰脱氧钢脱氧后钢液仍含有20×10-6以上溶解氧,这部分溶解氧在钢凝固后绝大多数会转变为微细的氧化物或氧硫化物夹杂。钢凝固后生成的夹杂物主要影响钢材的冲击韧性、韧-脆转换温度等性能。 对热轧长型材用普碳钢和低合金钢不必采用铁水脱硫预处理,对热轧钢板用普碳钢可采用铁水轻度脱硫预处理,对热轧钢板用低合金高强度钢可采用铁水脱硫预处理、炼钢过程抑制回硫和出钢过程脱硫的工艺。对超低硫低合金钢,在钢水炉外精炼脱硫处理过程钢-渣间须维持非常低的氧势,炉渣成分应控制在CaO:SiO2:Al2O3=60％～65％:4％-8％:30％～35％范围。 普通热轧长型材用钢脱氧后溶解氧含量可放宽至(30-50)×10-6,对中、厚板钢溶解氧含量必须较严格控制,最好采用铝脱氧将溶解氧控制在较低的水平,并将T[O]含量控制在50×10-6以下。采用降低炼钢终点钢水氧含量、出钢挡渣、CAS和CAB等较简易炉外精炼方法和防止铸坯夹渣等措施,能够生产满足普通热轧钢洁净度要求的高品质钢材。     

溜井振动放矿机的设计和使用维护

介绍了溜井振动放矿机设计时的埋设参数选择，阐述了其设计和安装的基本原则和要求，简明而系统地论述了振动放矿机使用维护的注意事项以及常见故障的处理方法。     

传统块状炭材料的发展概况

传统块状炭材料，如石墨电极、炼铝用阳极和阴极炭块、电炭制品、特种炭和石墨、炭砖等，在国民经济中占据不可替代的举足轻重的地位。本文简要概述了传统块状炭材料的国内外发展现状，在此基础上论述了我国相关领域中存在的问题，以期引起对传统但却十分重要的块状炭材料的进一步重视。     

The role of forest and bioenergy strategies in the global carbon cycle

Forest and bioenergy strategies offer the prospect of reduced CO₂ emissions to the atmosphere. Such strategies can affect the net flux of carbon to the atmosphere through 4 mechanisms: storage of C in the biosphere; storage of C in forest products; use of biofuels to displace fossil-fuel use; use of wood products which often displaces other products that require more fossil fuel for their production. We use the mathematical model GORCAM (Graz/Oak Ridge Carbon Accounting Model) to examine these mechanisms for 16 land-use scenarios. Over long time intervals the amount of C stored in the biosphere and in forest products reaches a steady state and continuing mitigation of C emissions depends on the extent to which fossil fuel use is displaced by the use of bioenergy and wood products. The relative effectiveness of alternative forest and bioenergy strategies and their impact on net C emissions strongly depend, for example, on the productivity of the site, its current usage, and the efficiency with which the harvest is used. When growth rates are high and harvest is used efficiently, the dominant opportunity for net reduction in C emissions is seen to be fossil-fuel displacement. At the growth rates and efficiencies of harvest utilization adopted in many of our base scenarios, the net C balance at the end of 100 years is very similar whether trees are harvested and used for energy and traditional forest products, or reforestation and forest protection strategies are implemented. The C balance on a plantation system that provides a constant output of biomass products can look different than the balance of a single parcel of land.     

ALGORITHMIC SYNTHESIS OF GENERAL NON-SHARP SIMPLE DISTILLATION COLUMN SEQUENCES

An algorithmic approach was used to select recoveries for non-sharp sequence designs. Simple distillation columns were employed. The non-key component distribution was modeled using the Fenske equation. The combination of producing impure products and allowing non-key component distribution, results in a large search space. With this large search space size and software limitations, five problems were solved (see summary table in the Design Examples sub-section). The optimal non-key component distribution was found to be significant but not necessarily maximal. Parallel processing was selected as optimal in contrast to the more traditional sequential processing.     

石膏制品防水防潮剂的研制与开发

本文提出采用高分子有机材料配合，生产石膏制品防水防潮剂的生产方法和工艺。该剂还可以应用到氧化镁系列板材，同时提出开发珠光或彩色防水防潮剂，能达到满足的装饰效果，值提开发推广。     

Monitoring non-carbonated (‘still’) mineral waters for aerobic colonization

Fifty samples each of two leading brands of French, non-carbonated (‘still’) mineral waters, packed in plastic bottles, were stored in the dark for one month at approximately 20°C to allow marked proliferation of their autotrophic microbial flora. Upon completion of this challenge test 1250 ml per bottle were filtered through five membranes, which were subsequently cultured on 1/10 strength nutrient agar for 48 h at a temperature favouring the growth of thermotrophic organisms only, i.e. 42 ± 0.5°C. The numbers of colonies per one litre were below 10³ in all samples and did not exceed 200 in 56–80%, depending on the brand. Identification of the isolates demonstrated strong inhibition of the psychrotrophic. Gram-negative types, predominating in the association flora of stored still waters and preponderance of Gram-positive, catalase-positive, facultatively anaerobic cocci. Consequently, a Reference Value for the thermotrophic autotrophic colony count per 1 ml in still, commercial mineral waters of the order m = 1 and M = 5 seems justified. It is emphasized that, besides examining for these trivial organism, the usual tests for marker bacteria (Escherichia coli and Lancefield group D streptococci) and Pseudomonas aeruginosa should always be carried out.     

Distribution of diethylstilboestrol in pigs

The synthetic growth promoter diethylstilboestrol (DES) administered orally to pigs can be detected by radioimmunoassay (RIA) analysis of kidney, liver, faeces, bile and urine from animals fed continuously to slaughter, but not in muscle, fat or plasma. If treated animals are fed on material not containing DES for 72 h prior to slaughter, then the levels of parent compound and metabolite in all products decrease to become not significantly greater than those in control animals. The gross metabolism of DES in pigs and bovines appears to be similar.     

用自射线照相技术研究放射性核素在岩石和矿物上的吸附

应用自射线照相和岩相照相技术联合图象法研究了锕系元素和长寿命裂变产物在岩石和矿物上的吸附行为，直接观察到不同矿物和化学成份对核素的吸附。应用这个方法，研究了＾２３９Ｐｕ、＾２４１Ａｍ在花岗岩上的吸附，＾９０Ｔｃ在辉锑矿、锑赭石和脆硫锑铅矿上的吸附以及＾１２５Ｉ在灰硒汞矿上的吸附，得到了一些有价值的结果。