Effect of particle size on the surface oxidation and flotation behavior of galena particles in lime system

ABSTRACT

In this research, the effect of particle size on the surface oxidation and flotation behavior of galena in the lime system was studied. Coarse (?0.074 + 0.038 mm), intermediate (?0.038 + 0.025 mm) and fine (?0.025 mm) galena particles were used in the experiment. The dissolution tests, flotation tests, and sorption tests were accomplished. Through further analysis by XPS, the effect of particle size and lime was observed. The decrease of mineral particle sizes increased the adsorption ratio of collector and the dissolution of galena, while the hydrophilic product OH^?/Ca(OH)⁺ produced by dissolution occupied the dominant position, which led to the minerals hydrophilic.     

局部颜色特征与工艺参数融合的铜浮选入矿类型识别

针对铜浮选过程中矿源变化频繁而造成的浮选工况难以识别、生产过程不稳定等问题,在分析铜浮选流程特点的基础上,提出了一种局部颜色特征与关键工艺参数融合的铜浮选入矿类型识别方法.首先采用多元图像处理方法提取泡沫图像局部颜色特征,然后采用混合滤波、时间配准算法将其与关键工艺参数进行数据融合,最后用融合后的混合特征进行模糊聚类,得到隶属度矩阵和聚类中心.工业数据仿真结果验证了本文所提方法的有效性.     

稠油污水的有机组成及可生化性研究

采用物化-厌氧-好氧法处理稠油污水,对物化生化处理各阶段出水的有机组分进行定性分析,并对稠油污水的可生化性进行了进一步研究。研究结果表明:不同处理工序出水的有机成分差异较大,经过气浮、厌氧处理后,稠油污水可生化性逐步提高,有利后续好氧生物处理。     

A MECHANISTICALLY BASED MATHEMATICAL MODEL OF SULFUR DIOXIDE ABSORPTION INTO A CALCIUM HYDROXIDE SLURRY IN A SPRAY DRYER

A mathematical model has been developed to predict So₂ absorption and removal during the constant rate drying period of a spray dryer. The model, based on film theory, treats the atomized slurry droplets as spheres containing discrete sorbent particles of slaked lime with the fluid uniformly distributed around the individual particles. The model includes gas and liquid phase mass transfer coefficients as well as resistance to Ca(OH)₂ dissolution. A sensitivity analysis has been conducted and a comparison was made between pilot-scale experimental data and model-predicted values of S0₂ removal efficiency.     

硫代硫酸钠合成条件的优化

优化了亚硫酸钠与硫磺反应制备硫代硫酸钠的合成条件，最佳反应条件为：亚硫酸钠与硫磺质量比为7：2，亚硫酸钠与水质量比为1：1，溶液pH=10，反应时间30min，此时亚硫酸钠转化率为95．9％，产品纯度98．9％，收率94．5％。     

水泥中硫的高频红外分析方法研究

采用高频红外吸收法测定了水泥中硫的含量,并对样品作测定前的预处理(物理处理),在测定中选用复合型助熔剂,解决了高频感应炉中因顶吹氧气流的作用而导致的样品喷溅问题。该法可准确测定水泥中0.001％～5％的硫,回收率为98.6％～102.5％,RSD为0.78％～1.35％。     

Assessment of Bitumen Re c overy from the Athabasca Oil Sands Using a Laboratory Denver Flotation Cell

A methodology was developed in this study to evaluate the effect of operating parameters on the processability of oil sands using small‐scale laboratory experimental devices. By subtracting bitumen recovered to the froth by entrainment with water, the concept of “true flotation recovery” is proposed to describe bitumen recovery resulting from bitumenbubble attachment. The experimental results indicated that “true flotation recovery” is a more sensitive and meaningful marker than overall bitumen recovery to evaluate the processability of oil sands using small‐scale laboratory test units.     

Sulfur transformation during rapid hydropyrolysis of coal under high pressure by using a continuous free fall pyrolyzer☆

The behavior of sulfur transformation during rapid hydropyrolysis of coal was investigated using a pressurized, continuous free fall pyrolyzer under the conditions of temperature ranging from 923 to 1123 K and hydrogen pressure up to 5 MPa. The yields of sulfur converted to gas, tar and char were determined, together with the analyses of sulfur form distributions in coals and chars. The results showed that the decomposition of inorganic sulfur species was affected only by the temperature, while the increases in temperature and hydrogen pressure obviously enhanced the removal of organic sulfur from coal. The extent of organic sulfur removal was proportional to the coal conversion, depending on coal type. A significant retention of gaseous sulfur products by the organic matrix of the char was observed during hydropyrolysis of a Chinese coal above 1023 K, even under the pressurized hydrogen atmosphere. The kinetic analysis indicates that the rate of organic sulfur removal from coal was 0.2th-order with respect to the hydrogen pressure, and the activation energy for total sulfur removal and organic sulfur removal is 17-26 and 13-55 kJ/mol, respectively. The low activation energies suggest that the transformation and removal of sulfur from coal might be controlled by the diffusion and/or thermodynamic equilibrium during hydropyrolysis under the pressurized conditions.     

新型膨化硝铵硫磺工业炸药的研究

用膨化硝酸铵、硫磺、木粉和柴油作原材料，通过建立工业炸药配方设计及最优化数学模型，得到新型膨化硝胺硫横工业炸药配方。通过几种工业炸药的理论参数和实际爆炸性能的比较，得出新型膨化硝铵硫磺工业炸药具有低的成本和优良的爆炸性能。     

Hydrogen and Oxygen Bubble Attachment to a Bitumen Drop

Air bubble – bitumen attachment is a critical step in the flotation of bitumen from mined oil sand. In this study, single bubble – bitumen drop attachment was observed directly using a novel experimental technique. Induction time is determined and used as an indication of bubble‐bitumen attachment potency for both hydrogen and oxygen bubbles. The attachment tests were conducted in deaerated municipal water (City of Edmonton tap water) at temperatures ranging from 22–50°C. Induction times measured for hydrogen bubble attachment were shorter than those for oxygen bubbles. Coalescence tests were also conducted in the absence of bitumen, and showed that hydrogen bubbles coalesced more rapidly than oxygen bubbles in both deaerated municipal water and clear (solids‐free) process water.