酸化水解-活性污泥-生物接触氧化工艺处理有机污水

介绍了采用酸化水解——活性污泥——生物接触氧化工艺处理含有山梨醇、甘露醇、蔗糖、醋酸乙烯、甲基纤维素的有机污水。该工艺具有出水水质稳定，操作简单、管理方便，能耗低等优点，是处理该类有机污水的有效方法。     

碳化二亚胺的制备及其水解稳定作用

简要介绍了可用于水解稳定剂的碳化二亚胺的性质、制备和在聚氨酯、聚酯树脂中的应用。     

凝胶过滤色谱法研究酶解过程中木聚糖分子结构的变化

采用凝胶过滤色谱法研究了木聚糖在酶解过程中分子量分布的变化。结果表明,木聚糖酶对高分子量组分的木聚糖的降解能力较差,而主要降解分子量介于15000～3000之间组分的木聚糖,使得这部分木聚糖变为分子量更低的木聚糖组分。随着酶解时间的延长,酶解得率上升,酶解产物中低聚木糖含量增多,未被酶解的木聚糖的平均聚合度上升,当酶解时间超过4h时,这种变化趋势缓慢。随着酶解轮次的增加,酶解产物中可溶性木聚糖的含量越来越少,木聚糖被降解的难度越来越大。在实际生产中,用来作为低聚木糖生产的木聚糖其聚合度应在20～100之间,酶解时间以4h为宜,重复利用未水解木聚糖的轮次以2轮为宜。     

高碳醇磷酸酯加脂剂的合成与分析

以高碳醇为原料，采用P2O5溶剂法合成磷酸酯。探讨了P2O5溶剂的选择原则，确定10^#机油作为P2O5的分散溶剂，其10^#机油与P2O5质量比为2．5：1．0。实验表明，P2O5溶剂法解决了P2O5传统法加料时易吸潮、结块、炭化、反应不均匀和反应初期过于激烈等缺陷；其反应产物中磷酸单双酯的摩尔比、高碳醇转化率及总酸值均比传统法有了明显的提高，且产物色泽浅于P2O5传统法合成的磷酸酯；水解反应能进一步提高产物中磷酸单双酯的摩尔比和高碳醇转化率，水解后磷酸单双酯的摩尔比由3．96上升到4．16．高碳醇转化率由81．5％提高到88．7％。电位滴定法分析测定磷酸酯组分含量时发现，氯化钙溶液(10％)的最低加入量为11．0mL。     

AMMONIA CATALYZED ORGANOSOLV DELIGNIFICATION OF POPLAR

A parametric investigation of NH₄OH catalyzed solvent delignification of poplar was conducted to define pretreatment conditions which would yield an optimal separation of the biomass components and an enzymatic susceptible solid carbohydrate phase. Delignification parameters of interest included concentration of NH₄OH, time and temperature of the reaction, and type of solvent. The addition of 0.82 M NH₄OH to the delignification liquor increased lignin removal and decreased carbohydrate degradation, but increasing NH₄OH concentration had no additional effect. At lower reaction temperatures, the extent of delignification increased with reaction time; at higher temperatures, a “relignification” of the pretreated wood was observed. The delignification and hemicellulose solubilization were modelled and rate constants reported. No major difference between three potential pulping solvents—ethanol, butanol, phenol—was observed. The enzymatic susceptibility of pretreated wood samples was approximately 6-fold greater than that of the untreated poplar. UV absorbance was used to qualitatively characterize the soiubilized lignins.     

二次酸水解法从黄姜中提取薯蓣皂甙元的工艺

薯蓣皂甙元是合成甾体激素药物和甾体避孕药物的重要原料,是黄姜中的主要活性物质。采用正交实验的方法,探讨了经过二次酸水解法从黄姜中提取薯蓣皂甙元的工艺条件,结果表明该方法提取的薯蓣皂甙元产率达到了2.41%,比直接水解法(2.20%)提高了9.55%。另外,采用熔点、元素分析法、红外、核磁等一系列的手段对产品进行表征,结果表明该法是可行的,提取的薯蓣皂甙元的质量纯度达到了工业的要求。     

林地腐殖土腐植酸对毒死蜱水解影响及吸附作用

采用平衡振荡法研究腐植酸对毒死蜱水解的影响和毒死蜱在腐植酸上的吸附特征及其影响因素.结果表明,在试验浓度范围内腐植酸可促进毒死蜱的水解,腐植酸浓度为120 mg/L时,毒死蜱的水解速率常数k明显增大,为不加腐植酸时的2.53倍,腐植酸浓度增加毒死蜱的水解速率降低.毒死蜱在腐植酸上的吸附行为均可用Linear方程和Freundlich方程来描述,拟合效果均达到显著水平;试验条件下温度为15℃时毒死蜱在腐植酸上的吸附量最大,随温度的升高吸附量呈现出先降低后增大的趋势;pH值减小,腐植酸对毒死蜱的吸附能力增大;而离子强度对毒死蜱的吸附影响不明显;腐植酸添加量越大,吸附量越大,但单位质量的腐植酸吸附量越小.     

硫酸尿素系统化学反应的研究

研究了硫酸尿素系统在不同配比和不同温度的化学反应。结果表明，常温下硫酸与尿素的摩尔比为1：1．0和1：2．0时，可形成有固定熔点的晶体。其相变点温度在硫酸和尿素相变温度之间，相变热远远小于尿素。80～90℃时，硫酸尿素水溶液系统会发生水解反应，过程速率为二级，且水解速率远大于尿素水溶液系统；150℃以上时，硫酸尿素系统发生反应生成氨基磺酸硫酸铵。在工程设计和应用中，应严格控制硫酸尿素系统在80～90℃的停留时间，并保证系统温度不超过150℃。     

微波促进二氯菊酸甲酯的水解新工艺研究

采用微波技术对二氯菊酸甲酯在NaOH溶液中水解为二氯菊酸工艺进行了研究。结果表明,微波促进下最佳水解条件为:反应温度90℃,功率100 W,反应时间10 m in,物质的量比n(二氯菊酸甲酯)∶n(C2H5OH)∶n(NaOH)=1∶4∶1.5,重结晶后收率高达99.6%。与传统条件相比,时间缩短30倍,收率提高24.6%,无水乙醇用量减少60%,NaOH用量减少17%。并用红外光谱和熔点对二氯菊酸进行表征。     

Hydrolysis of fats and oils with moist oat caryopses

To improve the economic feasibility of hydrolyzing fats and oils with moist oat caryopses, various factors affecting the efficiency of the process were studied. Caryopses produced with an impact-type dehuller exhibited greater lipase activity than those produced by a wringer-type dehuller. Abrasion of oat caryopses against each other in a fluidized bed released particles rich in lipase. Such lipase concentrates could be added to moist caryopsis reactors to speed fat hydrolysis. Beef tallow, lard, soybean oil and crambe oil were hydrolyzed more efficiently than corn oil, castor oil and milk fat. The poor hydrolysis of castor oil was attributed to the formation of esters with the hydroxy group of ricinoleic acid, and the hydrolysis of castor oil was increased by dilution of the substrate with hexane. Diglycerides inhibited the hydrolysis and accounted for the slower hydrolysis of corn oil. Hydrolysis of milk fat by moist oat caryopses resulted in preferential hydrolysis of C₆ to C₁₀ acids. Erucic acid was released from crambe oil at significantly slower rates than the other acyl groups. High conversions of fats and oils to free fatty acids could be attained by (i) exposing the fats and oils to two to three lots of moist caryopses, (ii) the use of special oat varieties with elevated lipase content, (iii) the addition of oat lipase concentrates to moist caryopsis reactors, and (iv) dilution of the substrate with hexane. Estimates of the cost of producing free fatty acids with these processes indicated that the first three should be profitable. Growth ofClostridium sporogenes spores could not be demonstrated in caryopsis reactors. During the incubation of moist oat caryopses immersed in oil, the free fatty acid content of the internal caryopsis lipid increased only slightly, but there were changes in its fatty acid composition.