累托石矿物提纯工艺探讨

以B03作分散剂,对湖北省钟祥县杨榨累托石粘土矿物进行了机械搅拌擦洗,使累托石矿物微粒较充分地分散解离,然后通过离心力场的作用,使累托石与水云母、叶腊石、绿泥石、石英等脉石矿物分离,累托石精矿纯度达90％左右,B03的使用为工业生产高纯累托石产品奠定了基础。     

2种方法检测食品模拟物中矿物油含量的比较研究

目的 考察离线固相萃取-气相色谱-氢火焰离子化检测器法(off-line solid phase extraction-gas chromatography-flame ionization detector,off-line SPE-GC-FID)与高效液相色谱-气相色谱-氢火焰离子化检测器在线联用法(on-line...     

Effects of various phytase sources on phytic acid content,mineral extractability and protein digestibility of tarhana

Changes in phytic acid (PA), HCl-extractability (HCl-E) of some minerals and in vitro protein digestibility (IVPD) during the production of tarhana prepared with the addition of different phytase sources (bakers’ yeast, barley malt flour and microbial phytase) were investigated. PA content of tarhana decreased significantly (p < 0.01) after addition of the yeast, malt and phytase. With respect to wheat flour used as raw material, PA content of tarhana decreased by 95.3%. After tarhana production, average values of HCl-E of Ca, Mg, Zn and K, and also IVPD of tarhana increased up to 80.2%, 86.4%, 73.9% and 92.6%, and 91.9%, respectively. Significant negative correlation coefficients were found between the PA and HCl-E of the minerals, and also IVPD. Tarhana production processes, including fermentation, drying and grinding, were able to remove the antinutritional effects of PA. Each one of the phytase sources used alone decreased the PA content to a limited extend. The results show that tarhana has good potential in the total amounts and bioavailability of the minerals and proteins.     

Heat and Mass Transfer in Unsaturated Porous Cake with Heated Walls

The mineral granules in the industrial drying units such as rotary dryer or fluidized dryer or the membrane in the PEMFC experience transient multiphase heat and mass transfer with transient heating mode. In particular, the transport process within mineral granules in the dryer is difficult to model owing to effects of complicated granule-granule collision and granule-heated surface. This article presents a comprehensive model consisting of continuity and heat and mass balances of three phases in an unsteady state. Numerical results revealed the flow patterns and temperature distributions of gas and liquid phases in mineral granule over time. The thermal response of the heated medium will be very different under low and high mixing intensities. The development of a recirculation liquid zone to balance the yielded capillary suction gradient enhances local evaporation and vapor accumulation rates, thus determining the overall evaporation rate form medium.     

含砷金矿石工艺矿物学特征及其应用

通过典型实例分析,对含砷金矿石的工艺矿物学特征及应用进行了探讨,对金矿石除砷具有重要意义．     

The effect of delaying autumn incorporation of green manure crop on N mineralization and spring wheat (Triticum aestivum L.) performance

The use of legumes as green manuring crops does involve a potential riskof N leaching losses over the winter period. The susceptibility of cropresidue-derived N to losses and the pre-crop value of a green manuring crop canbe manipulated by proper timing of incorporation into soil. In this study,mineralization of C and N was investigated in a range of low temperatures,including thawing and freezing, that are characteristic to autumn green manureincorporation and its decomposition. The pre-crop effect of green manuring wasfurther tested with spring wheat under field conditions. We hypothesized thatdelaying green manure incorporation in the autumn would reduce the risk of Nlosses from the field and maximize the N transfer to a successive spring wheatcrop. To test the hypothesis, N mineralization was followed in alaboratory experiment where red clover (Trifoliumpratense L.) shoots were incubated at 4–8 °Cfor 40–80 days to simulate early autumn, delayed autumn and late autumnincorporation of a green manuring crop, followed by an incubation at–2 °C or at –2 °C to+4 °C for 25 days to simulate winter conditions. In asimultaneous field experiment, we measured the effect ofdelayed autumn incorporation of common vetch (Vicia sativaL.) green fallow on spring wheat performance. In the laboratoryexperiment, significant N mineralization during incubation wasdetected when simulating both early autumn and delayed autumn incorporation. Incontrast, no net N mineralization was detected when simulating lateincorporation. In the field experiment, the N supply fromsoil to spring wheat was higher in the late and delayed incorporationtreatmentsthan in early or spring incorporation of green manure. Late incorporationalso produced most wheat grain. We conclude that different amounts of N becomeavailable to wheat, depending on the time of incorporation of green manureresidues in soil. This difference is due to temperature. Late or delayedincorporation of green manure residues has the potential to reduce thesusceptibility of mineral N to leaching and yields more N available to asubsequent crop.     

Mineral admixtures in mortars: Effect of inert materials on short-term hydration

This work is the first part of an overall project the aim of which is the development of general mix design rules for concrete containing different kinds of mineral admixtures. The separation of the different physical effects responsible for the modification of cement hydration, when chemically inert quartz powders are used in mortars, is presented. The phenomenological approach, based on semi-adiabatic calorimetry, is only associated with first-order phenomena, and the study excludes the complex physicochemical details involved in the chemistry of cement. The results, obtained for a wide range of fineness (between 180 and 2000 m²/kg) and replacement rates (up to 75%), show that short-term degrees of hydration in mortars containing a chemically inert mineral admixture (quartz) are always higher than for a reference mortar. This study confirms that cement hydration is enhanced by inert mineral admixtures. The two main physical effects responsible for the modification of the hydration of cement are identified as the dilution effect and heterogeneous nucleation. The dilution effect of the cement is highlighted with a coarse mineral admixture. The heterogeneous nucleation effect, although it increases with fineness of mineral admixtures, presents an optimum depending on the replacement rate. In the following part of this work, these results will be used for the development of an empirical model allowing us to quantify both physical effects.     

水玻璃激发粉煤灰、矿粉活性的试验研究

以水泥为主要胶凝材料,掺加工业废渣粉煤灰、矿粉作为替代物,同时添加一定量的水玻璃激发剂,研究其对矿物掺合料的激发机理及合理掺量。结果表明:水玻璃对矿物掺合料的活性激发效果表现良好,改善了水泥基材料的强度,实现了保护环境和节约经济的目的。     

Thermochemical Conversion of Sewage Sludge by TGA-FTIR Analysis: Influence of Mineral Matter Added

Thermal treatments, such as combustion, gasification, and pyrolysis, have been proven to be a convenient alternative to conventional sludge disposal technologies. Today, process development implies scaling up and so improving the reactor's design. In continuously operated reactors, fresh sewage sludge is in contact with solid residues (reacted material rich in mineral matter and char). Mineral matter has been reported to catalyze the thermo-chemical reactions involved but few works focus on this aspect. In this work, sewage sludge residues were added to fresh sewage sludge. Non-isothermal thermo-gravimetric analysis (TGA) coupled with infrared spectrometry (FTIR) showed that added residues reduce the characteristic reaction temperatures during char combustion and gasification (air, air-N₂, and CO₂ atmospheres). However, any considerable influence of residues was observed during pyrolysis experiments (N₂ atmosphere). The analysis of gas produced during those experiments revealed further details about the solid decomposition, showing considerable differences between different atmospheres.     

工业废渣的性能及其在建筑陶瓷中的应用

本文系统地叙述了多种工业废渣的化学组成、矿物组成和主要性能。论述了部分废渣在建筑陶瓷生产中的加工工艺。比较详细地介绍了国内在建筑陶瓷工业中应用工业废渣的研究实例及其化学组成。