重钙装置改产磷铵反应与尾气洗涤系统设备出现的问题

介绍瓮福磷肥厂重钙(TSP)装置改产DAP后,反应与尾气洗涤系统料浆泵、搅拌器、反应器、洗涤泵、重要阀门在运行中出现的问题及处理措施.     

中低品位膨润土的有机化及在泥浆中的应用

以新疆乌兰陵格产中低品位钠基膨润土为原料,用十六烷基三甲基铵盐(氯化物D1631和溴化物CTAB)作插层剂,制备有机膨润土。通过实验确定了制备有机膨润土的季铵盐加入量是85～90mmol/100g土。用红外(FTIR)、X-衍射(XRD)和扫描电镜(SEM)表征了有机土结构。FTIR谱显示有机插层剂已进入膨润土的层间,XRD特征峰位移表明膨润土的层间距由1.23nm增加到3.26nm。SEM观察到有机土形貌显著改变,颗粒松散。结果表明膨润土的层间距增大,粒层厚度约为72nm左右。测试了有机膨润土的钻井油基泥浆性能,结果表明,其塑性粘度为7.0mPa·s,表观粘度为8.5mPa·s,动切力为1.5Pa,滤失量40.0mL,均已达到钻井液用有机土的质量指标要求。     

磷酸铵生产中高温冷凝水密闭循环回收与应用

针对目前磷酸铵生产排出的高温冷凝水的热能未得到充分利用及由此产生的热污染，介绍了一种把排出的高温冷凝水密闭循环回收利用技术，可使蒸汽热力系统的运行效率提高10％以上。分析了该技术的特点和运行状况，认为采用该技术对蒸汽能力系统进行改造，投资少、见效快，投资回收期短、经济效益好，又消除了热污染现象，在磷酸铵生产中有推广价值。     

一种含壳聚糖的有机硅纺织柔软剂的研制

以三甲胺、环氧氯丙烷、壳聚糖为原料，合成了N-壳聚糖季铵盐；并将其与氨基硅油、三种非离子型表面活性剂、一种有机硅两性表面活性剂进行复配，制成了一种新型有机硅柔软剂。经检测，产品的离心稳定性、酸碱稳定性及阴离子型表面活性剂稳定性较好；经其整理的纯棉白布不仅具有良好的柔软性和吸湿性，而且具有一定的抗茵活性。     

The comparative effect of a mixed urea,ammonium nitrate,ammonium sulphate granular formulation on the efficiency of N recovery by perennial ryegrass

The¹⁵N isotope was used to study the mode of action of individual nitrogen sources in a 30% urea:30% ammonium nitrate: 10% ammonium sulphate:30% filler (w/w) granular fertilizer for perennial ryegrass in a greenhouse pot experiment. The fertilizer consisted of two types of granules, one containing 80% urea and 20% filler and the second containing 48% ammonium nitrate (AN), 16% ammonium sulphate (AS) and 36% filler. In addition the effect of dolomite compared with silica as the filler was investigated on nitrogen recovery from the 30:30:10:30 formulation.Dolomite adversely affected the recovery of nitrate N from the system and evidence suggested that MgCO₃ was the active component. Granules containing dolomite resulted in a lower dry-matter yield than those containing silica, however the difference was not significant as nitrate contributed only 20% of the N in the formulation. AN gave the greatest DM yield and urea the lowest with AS being intermediate. The¹⁵N budget in shoots, roots and soil indicated that only 65% of the N from urea was recovered at the end of the experiment compared with 86% for AN and 91% for AS. The dry-matter yield of the 30:30:10:30 formulation using silica as the filler was intermediate between urea and AN; however, the apparent N recovery was significantly higher than expected from the sum of the individual components. The use of¹⁵N labelling indicated that using separate granules for ammonium N and urea the recovery of urea was improved by 11% in the triple N mixture when both AN and AS were present in the second granule compared to the recovery on its own. The enhanced recovery of urea appeared to be a function of AN and AS acting together as neither source in double combination with urea had any effect on urea N recovery.Urea enhanced the recovery of nitrate N by 10% but decreased the recovery of AS by 6% (in the 30:30:10:30 formulation) in comparison with the single sources on their own. The results indicate that interactions can occur between N sources even when they are physically separated by being in different granules.     

石油化工装备“后果分析”方法的介绍

石油化工装备的失效,由于所处理的物料常常是易燃易爆的化学品,所以往往导致发生燃烧、爆炸等,还可以波及附近的其它装置和设备发生连锁的失效和爆炸。为了分析这种严重事故可能造成的影响,研究防止这种事故的发生,近年来研究和发展了一种定量估计这种失效后果严重程度的方法,称为后果分析(Consequence Analysis)。通过分析,从这些设备的失效概率、可能发生的失效形式,研究设备内物料的泄漏形式、可能发生的后果、影响范围的大小、对周围装置、环境和人员的危害程度等,从而提出在设备设计、工厂的总图设计中采取的措施,以减轻其危害的程度。     

由粗氧化锌制备纳米活性氧化锌的研究

采用碳酸氢铵法由粗氧化锌制备纳米活性氧化锌。研究了用碳酸氢铵法由粗氧化锌制备活性氧化锌的热力学、中间体碱式碳酸锌的主要组成和碱式碳酸锌热分解的温度对形貌的影响;考察了中间体碱式碳酸锌的热分解温度和时间对纳米活性氧化锌的纯度、白度、比表面积和表观密度的影响。碱式碳酸锌焙解生成纳米活性氧化锌适宜的温度和时间分别为600℃和1h时,产品中氧化锌的质量分数为97.6%,粒度<100nm,比表面积50m2/g,表观密度0.21g/cm3。     

染料分散剂新原料-高沸醇木质素的研制

采用1，4-丁二醇水溶液为溶剂的高沸醇溶剂法，从松木，杉木，稻草等原料制备纤维素与高沸醇木质素。使用上述原料，在70%-90%1，4-丁二醇水溶液中添加少量催化剂。并在190℃-220℃条件下蒸煮1-3小时后，分离反应产物，得到固体纤维素与高沸醇木质素-丁二醇溶液，不溶于水的高沸醇木质素通过加水沉淀的方法。从反应后的液体混合物中分离。高沸醇木质素具有较高的反应活性。灰分含量很低。适于制备新型染料分散剂，有广泛应用前景。     

氟化铵溶解含氟硅渣制备氟硅酸铵的实验研究

以氟化铵溶液和含氟硅渣为原料,通过化学溶解的方式,制备氟硅酸铵产品。考察了反应温度、反应时间、氟化铵溶液浓度和物料配比（氟化铵与二氧化硅的物质的量比）等不同工艺条件对氟硅酸铵收率、二氧化硅转化率的影响。实验结果表明：反应温度为93 ℃、反应时间为60 min、氟化铵溶液质量分数为20%~30%、物料配比为6∶1.1、反应体系搅拌速度为200~300 r/min时,氟硅酸铵的收率和氟化铵的转化率可控制在90%以上。     

酸性铵盐沉钒条件实验研究

以温度、时间、搅拌强度为变量，以沉淀率、抽滤后滤饼含水量、烘干后多钒酸铵(APV)中杂质含量等作为评价指标，对酸性铵盐沉钒条件进行了研究. 结果表明：以含钒30 g/L左右的溶液为原料，加硫酸铵后用硫酸调节pH至2.2左右，沸水浴(95℃)中沉淀120 min左右，桨式搅拌转速300 r/min，可获得99%以上的沉淀率，抽滤滤饼含水量20%以下，烘干后APV含Na 0.70%~ 1.08%, S 0.78%~1.20%.