降凝剂乙烯-醋酸乙烯酯对蜡晶Zeta电位的影响

通过微电泳仪研究了降凝剂乙烯-醋酸乙烯酯（EVA）对蜡晶Zeta电位的影响。结果表明,当降凝剂用量低时,蜡晶的Zeta电位随降凝剂用量的增加而增加;降凝剂用量达到600μg/g时,蜡晶Zeta电位（9.8mV）不随降凝剂用量的变化而变化;在乙烯链节的平均碳原子数为30左右,蜡晶Zeta电位值最大,最大值为10.86mV;降凝剂EVA分子结构中VA链节质量分数在45%时,蜡晶Zeta电位最大,最大值15mV;EVA支化度的增加,蜡晶Zeta电位变小;平均相对分子质量为1.2×104,蜡晶Zeta电位值最大,最大值为11.8mV。     

1-溴乙基乙酸酯合成工艺研究

研究了用溴化氢溶液与乙酸乙烯酯反应生成1-溴乙基乙酸酯的合成工艺,考察了物料配比、反应时间、反应温度、萃取剂等对反应的影响,得出了1-溴乙基乙酸酯的最佳合成条件。当反应温度0~10°C,溴化氢和乙酸乙烯酯配比为1.2：1,反应时间1 h,用二氯甲烷作萃取剂时反应收率最高。产品经红外和质谱确定,气相色谱分析产品纯度达99.7%。     

原花青素/醋酸纤维素可降解包装薄膜的结构与抗氧化性能

将原花青素(PC)添加到醋酸纤维素(CA)制膜溶液中,制得具有抗氧化性的可降解包装薄膜。通过红外光谱、X射线衍射和原子力显微镜对薄膜表面形貌、膜结构和结晶情况进行表征。以新鲜猪油为内装物、采用油脂氧化稳定性的检测方法Schaal烤箱法,测试薄膜在不同PC添加量时的抗氧化性。结果表明:当添加质量分数为2%PC时,薄膜的抗氧化性最佳,其对油脂的抑制率达到了37.65%,可在常温下延长油脂保质期两个多月。     

Study of the influence of reaction conditions on the degree of substitution,intrinsic viscosity,and yield of oxidized cellulose acetate by factorial experimental design

A half‐fraction, two‐level, four‐factor factorial experimental design was used to study the effects of the acetic anhydride concentration, reaction temperature, reaction time, and sulfuric acid concentration on the degree of substitution, intrinsic viscosity, and yield of oxidized cellulose acetate (OCA). Oxidized cellulose containing 20% (w/w) carboxylic acid was used as the starting material. The data were fitted by multiple regression analysis with SAS software. The correlation coefficients obtained from plots of the predicted and observed values for the degree of substitution, intrinsic viscosity, and yield were 0.985, 0.993, and 0.991, respectively. Residual normal plots of the regression models showed a linear relationship. Lenth and main‐factor‐effect plots revealed an increase in the degree of substitution of OCA with an increasing concentration of acetic anhydride. The latter had no effect on the intrinsic viscosity and yield of OCA. An increase in the reaction temperature led to an increase in the degree of substitution and a decrease in the intrinsic viscosity and yield of OCA. The influence of the reaction time on the degree of substitution and intrinsic viscosity followed a trend similar to that observed with the reaction temperature, but the yield of OCA was unaffected. Increasing the concentration of sulfuric acid reduced the degree of substitution, intrinsic viscosity, and yield of OCA. © 2005 Wiley Periodicals, Inc. J Appl Polym Sci 96: 696–705, 2005     

Characterization of Pheromone Blend for Grapevine Moth, Lobesia botrana by Using Flight Track Recording

The behavioral responses of Lobesia botrana males to calling females, pheromone gland extracts, and synthetic sex pheromones were recorded in a wind tunnel. Gland extracts and synthetic pheromones were released from a pheromone evaporator. The numbers of males reaching the source and their flight tracks in response to calling females and pheromone gland extracts were compared to those of synthetic blends. Upwind flights to natural sex pheromone were straighter and faster than to a three-component blend of (E)-7,(Z)-9-dodecadienyl acetate (E7,Z9–12:Ac), (E)-7,(Z)-9-dodecadien-1-ol (E7,Z9–12:OH), and (Z)-9-docecenyl acetate (Z9–12:Ac) (100:20:5). The optimum ratio of E7,Z9–12:OH and Z9–12:Ac to E7,Z9–12:Ac was found to be 5% and 1%, respectively. An additional seven compounds identified in the sex pheromone gland were investigated for their biological activity. Two unsaturated acetates, i.e., (E)-9-dodecenyl acetate (E9–12:Ac) and 11-dodecenyl acetate (11–12:Ac), increased the number of males reaching the source as well as straightness, linear velocity, and decreased the track angle of upwind flight. Optimum response was obtained by releasing 10 pg/min E7,Z9–12:Ac in a mixture with 0.5 pg/min E7,Z9–12:OH, 0.1 pg/min Z9–12:Ac, 0.1 pg/min E9– 12:Ac and 1 pg/min 11-12–Ac. The saturated acetates previously identified in the female glands were biologically inactive.     

Aggregation pheromone characterization and comparison inDrosophila ananassae andDrosophila bipectinata

(Z)-11-Octadecenyl acetate (Z11–18Ac) and (Z)-11-eicosenyl acetate (Z11–20Ac) were identified as the aggregation pheromones ofDrosophila ananassae, andZ11–20Ac was identified as the aggregation pheromone ofDrosophila bipectinata. Z11–18Ac andZ11–20Ac were not attractive alone; however, in combination with fermenting food odors, the acetates attracted flies of both sexes in a wind-tunnel olfactometer. The pheromones were present in the ejaculatory bulb of sexually mature male flies and transferred to the female during mating. MaleD. bipectinata released little if anyZ11–20Ac to the food; however, recently mated females releasedZ11–20Ac to the surrounding surfaces in just a few hours after mating.D. ananassae males, on the other hand, appeared to release moreZ11–18Ac andZ11–20Ac to the surroundings than mated females. AlthoughD. bipectinata males had noZ11–18Ac, flies were as attracted toZ11–18Ac as to an equal quantity ofZ11–20Ac.D. ananassae were attracted toZ11–18Ac but not toZ11–16Ac orZ11–20Ac. However,Z11–20Ac in combination withZ11–18Ac was significantly more attractive thanZ11–18Ac alone.     

醋酸正丁酯生产中硫酸用量对中和操作的影响

研究了在醋酸正丁酯工业化生产中催化剂硫酸用量对中和反应的影响，分析了产生这种影响的原因。     

Reuse of carwash water with a cellulose acetate ultrafiltration membrane aided by flocculation and activated carbon treatments

A reuse system for carwash water with a cellulose acetate (CA), hollow-fiber-type ultrafiltration membrane with the aid of flocculation and activated carbon treatments was proposed. The multi-blended flocculating agent containing bentonite, Al₂(SO₄)₃, sodium alginic acid and a cationic polyacrylamide showed higher removals of COD and turbidity for carwash wastewater compared with Al₂(SO₄)₃ or a water-soluble polymer individually. The effect of pure water permeability of the membrane on permeation flux in pretreated carwash wastewater by this agent was examined using three kinds of CA membranes whose molecular weight cut-offs were 150,000 Dalton. Permeation flux showed a higher value in the case of the membrane with higher pure water permeability. Practical scale experiments with a membrane area of 32 m² and 48 m² were conducted under a membrane pressure of 20 kPa. When carwash wastewater was pretreated with 50 mg/L of this multi-blended flocculating agent, permeation flux through the CA membrane with pure water permeability of 0.78 m³/(m²/h) at 100 kPa showed 1.0 m³/(m²/d) for more than 6 months. The COD, BOD and extract by n-hexane values of reuse water were 3.7-15.7 mg/L, 2.5-14.0 mg/L and below 0.5 mg/L, respectively.     

稀土固体超强酸催化合成乙酸异戊酯的研究

制备出一系列稀土固体超强酸催化剂 ,用于催化以乙酸和异戊醇为原料合成乙酸异戊酯的反应。研究了稀土固体超强酸的催化性能 ,同时 ,考察了影响合成反应的因素。结果表明 ,稀土固体超强酸不仅具有一般超强酸的性能 ,而且催化活性更高 ,性能更稳定。     

聚醋酸乙烯酯乳液胶粘剂的改性研究

介绍了醋酸乙烯酯-丙烯酸酯多元共聚乳液的合成工艺,讨论了单体组成、乳化剂组成、反应温度等对乳液性能的影响。