基于模糊感官评价的大豆品种对豆浆加工品质影响分析

以黑龙江产区6?个大豆品种为原料,测定了大豆籽粒的百粒质量和粗蛋白质、粗脂肪、钙、磷水平等理化指标以及加工制成豆浆的得率、理化品质,并基于模糊感官评价方法分析了不同品种大豆的豆浆感官品质,进一步分析了大豆籽粒与豆浆理化指标和感官品质之间的相关性。结果表明：6?个大豆品种中‘中龙606’制得的豆浆综合感官品质最佳,且具有甜度高、豆香味浓郁、色泽良好、豆腥味和涩感相对较弱的特点;在现有的品种中蛋白质量分数低于40%,且脂肪质量分数较高的品种更有利于加工高品质豆浆。     

Fermentation and Properties of Calcium-fortified Soy Milk Yogurt

Calcium-fortified soy milk yogurt containing 190 mg calcium/100g was produced and evaluated for textural and microstructural properties. The soy milk base contained 10% full fat soy flour, 2.25% soy protein isolate, 2.75% high fructose corn syrup, 1.55% calcium lactogluconate, and 1.25% potassium citrate. The mixture was heated 5 min at 80°C, cooled to 42°C, and inoculated with yogurt cultures. Calcium-fortified soy milk required a higher rate of inoculation (5%) than non-fortified soy milk (2.5%) and had higher titratable acidity and more syneresis. Calciumfortified soy milk yogurts showed comparable gel strength with that of commercial regular yogurt. Gels from nonfortified soy milk yogurts were hard and brittle. Addition of calcium did not significantly affect microstructure of the yogurts.     

Incorporation of Soymilk Lipid into Soy Protein Coagulum by the Addition of Calcium Chloride

ABSTRACT: The effect of protein composition on the lipid incorporation into protein coagulum (tofu curd) was investigated using soymilk prepared from mixtures of glycinin-rich and β-conglycinin-rich soybeans. The lipid incorporation takes place with the addition of CaCl₂ so that a particulate fraction of the protein is aggregated. The incorporation occurred by less addition of CaCl₂ with increasing glycinin in soymilk. The protein particle content and the glycinin content of the particles increased along with increasing glycinin. The lipid incorporation took place at lower CaCl₂ concentration when the particulate glycinin content was high. The mechanism of the lipid incorporation into soybean curd is discussed from these results.     

大豆酸凝乳的研制

通过对乳酸菌和双岐杆菌在豆乳中生长情况的研究，利用综们对豆进行发酵，制备酸凝豆乳，并确定了主要工艺参数。     

Conversion of isoflavone glucosides to aglycones in soymilk by fermentation with lactic acid bacteria

ABSTRACT:  Four lactic acid bacteria (LAB), Lactobacillus paraplantarum KM, Enterococcus durans KH, Streptococcus salivarius HM and Weissella confusa JY, were isolated from humans and tested for their capabilities of converting isoflavone glucosides to aglycones in soymilk. Changes in growth, pH, and titratable acidity (TA) were investigated during fermentation at 37 °C for 12 h. After 6 to 9 h of fermentation, each population of 4 LAB reached 10⁸ to 10⁹ CFU/mL. The initial pH of 6.3 ± 0.1 decreased while the TA of 0.13%± 0.01% increased as fermentation proceeded, resulting in the final range between 4.1 ± 0.2 and 4.6 ± 0.1 for pH and between 0.51%± 0.02% and 0.67%± 0.06% for TA after the 12 h of fermentation. The glucoside concentrations were significantly decreased in soymilks fermented with either L. paraplantarum KM, S. salivarius HM, or W. confusa JY with fermentation time ( P < 0.05). L. paraplantarum KM was the best in percent conversion of glucosides to corresponding aglycones, resulting in 100%, 90%, and 61% hydrolysis of genistin, daidzin, and glycitin, respectively, in 6 h. Consequently, the aglycone concentrations in soymilk fermented with L. paraplantarum KM were 6 and 7-fold higher than the initial levels of daidzein and genistein, respectively, after 6 h of fermentation. Changes in the daidzin and genistin levels were not significant in soymilk fermented with E. durans KH. The rates of hydrolysis of glucosides varied depending on the species of LAB. Especially, L. paraplantarum KM seems to be a promising starter for bioactive-fermented soymilk based on its growth, acid production, and isoflavone conversion within a short time.     

Effect of Ohmic Heating of Soymilk on Urease Inactivation and Kinetic Analysis in Holding Time

To verify the effect of the ohmic heating on the urease activity in the soymilk, the ohmic heating methods with the different electrical field conditions (the frequency and the voltage ranging from 50 to 10 kHz and from 160 to 220 V, respectively) were employed. The results showed that if the value of the urease activity measured with the quantitative spectrophotometry method was lower than 16.8 IU, the urease activity measured with the qualitative method was negative. The urease activity of the sample ohmically heated was significantly lower than that of the sample conventionally heated (P < 0.01) at the same target temperature. It was concluded that the electrical field enhanced the urease inactivation. In addition, the inactivation kinetics of the urease in the soymilk could be described with a biphasic model during holding time at a target temperature. Thus, it was concluded that the urease in the soymilk would contain 2 isoenzymes, one is the thermolabile fraction, the other the thermostable fraction, and that the thermostable isoenzyme could not be completely inactivated when the holding time increased, whether the soymilk was cooked with the conventional method or with the ohmic heating method. Therefore, the electric field had no effect on the inactivation of the thermostable isoenzyme of the urease.     

Effect of thermal processing on genistein,daidzein and glycitein content in soymilk

Soymilk was subjected to various heat treatments at 95, 121 and 140 °C for various lengths of time. The contents of the aglycones of isoflavone (daidzein, glycitein and genistein) of the soymilk were determined using C₁₈ reversed‐phase high‐performance liquid chromatography. Genistein showed greater stability to heat treatment than daidzein and glycitein. Both the daidzein and glycitein contents decreased rapidly during the early stage of heating, but on continued heating the rates of decrease were much slower. Heating may cause an increase or decrease in the genistein content of soymilk depending on the temperature and time used. Upon heating at 95 and 121 °C, there was an increase in the genistein content in the early stage of heating, possibly due the conversion of genistin to genistein. Heating at 140 °C for more than 15 s and prolonged heating at 95 and 121 °C, however, caused a slow decline in the genistein content. Copyright © 2006 Society of Chemical Industry     

Fermented tofu: Enhancement of keeping quality and sensorial properties

In this study a new way to produce tofu by means of soymilk fermentation by specific lactic acid bacteria, Lactobacillus casei and Lactobacillus acidophilus alone or in combination, and subsequent precipitation has been developed, in order to prevent undesired microbial and chemical spoilage, as well as improve the stability and the quality of the product. In particular, the combination L. casei and L. acidophilus generated tofu having shelf life exceeding 20 days and able to prevent the growth of the spoilage strains inoculated. This fermented tofu was characterized by the production of antimicrobial molecules, such as acetic acid, limonene, 2-nonen-1-ol, 1-nonanol, 2(5H)-furanone, benzyl alcohol, phenylethyl alcohol and heptanoic acid. Depending on the Lactobacillus species used, the fermentation process generated different metabolites profiles and sensorial properties. Another promising properties conferred by the lactic acid bacteria fermentation was the inhibition of unsaturated fatty acids (UFAs) peroxidation or reduction of the aldehydes originated to their corresponding alcohols.     

Effect of electroporation on viability and bioconversion of isoflavones in mannitol‐soymilk fermented by lactobacilli and bifidobacteria

BACKGROUND: The aim of this study was to evaluate the effect of electroporation (2.5–7.5 kV cm^?1 for 3.0–4.0 ms) on the growth of lactobacilli and bifidobacteria, membrane properties and bioconversion of isoflavones in mannitol‐soymilk. RESULTS: The viability of lactobacilli and bifidobacteria decreased immediately after electroporation. This was attributed to lipid peroxidation, which led to alterations in the membrane phospholipid bilayer, specifically at the polar head, interface and apolar tail regions. Such alterations also resulted in decreased membrane fluidity and increased membrane permeability upon electroporation (P < 0.05). However, the effect was reversible and treated cells showed better growth than the control upon fermentation for 24 h at 37 °C (P < 0.05). Additionally, electroporation increased the bioconversion of glucosides to bioactive aglycones in mannitol‐soymilk, which was attributed to increased intracellular and extracellular β‐glucosidase activities of cells upon treatment (P < 0.05). CONCLUSION: Application of electroporation on lactobacilli and bifidobacteria could be beneficial for the development of fermented soymilk with enhanced bioactivity. Considering the enhanced bioactive aglycones, this soymilk could be useful for the prevention of hormone‐dependent disorders. Copyright © 2012 Society of Chemical Industry