低(等)压合成氨的最佳H2/N2与催化活性的关系

采用高压催化剂性能评价实验装置，在压力分别为7.0,10.0和15.0MPa，温度分别为350,400和450℃条件下，在H2／N2为1.6-3.0范围内研究了H2／N2对A301，ZA－5和A110－2型催化剂的活性和合成塔出口氨浓度的影响。在压力和空速一定的条件下，最佳H2／N2随反应温度而异。在350，400和450℃下，最佳H2／N2分别为1.8-2.2,2.2-2.5和2.5-3.0。由此可见，合成氨反应的速率达到最大值时的最佳H2／N2值与反应的进程有关。为此提出了催化剂效率K（Catalysis efficiency)的概念来表征在催化剂作用下反应器出口氨浓度趋近平衡的程度，即K＝CNH3／C^*NH3。根据实验结果，得到了最佳H2／N2与催化剂效率的定量关系：（H2／N2）m=1.5(1 CNH3/C^*NH3)=1.5(1 K)。由此可以根据催化剂在不同反应条件下的催化剂效率来确定最佳H2／N2。凡是会降低催化剂效率的因素，都会使最佳H2／N2降低。各种影响因素对最佳H2／N2的影响中，反应温度的影响最大，其次是空速和催化剂的活性，而压力和惰性气体含量的影响相对较小。在低温（低压）下合成氨，宜采用较低的H2／N2。     

The role ofAzolla in curbing ammonia volatilization from flooded rice systems

By the year 2020, an additional 300 million tons of rice are needed annually to meet the demands of a growing population. If our natural resource base is to be preserved, intensification strategies should rely on integrated nutrient management, making full use of biological nitrogen fixation. TheAzolla-Anabaena complex is amongst the most effective systems of fixing nitrogen. In this paper we present evidence from greenhouse studies on the potential ofAzolla to curb the volatilization of NH₃ following the application of urea to a mixedAzolla-rice culture, providing a new incentive for developing ways of integratingAzolla in intensive rice cultivation systems.The results of a series of short term greenhouse experiments show that a full cover ofAzolla can significantly reduce losses of applied urea-N from 45 and 50% to 20 and 13% for the 30 and 60 kg N ha^–1 treatments, respectively. About one-quarter of the applied N was tied up in theAzolla biomass. The applied N inhibitedAzolla growth as well as the amount of N fixed. Inoculation with smaller quantities ofAzolla allowing for more vigorousAzolla multiplication was equally effective in reducing NH₃ volatilization and doubled the amount of¹⁵N tied-up byAzolla. The reduction in NH₃ volatilization is largely related to the depression byAzolla of the floodwater pH, which in its absence may reach values between 9 and 10 as a result of algal activity.Early rice growth responded positively to urea as well as the large quantities of appliedAzolla and increased the yield potential of the crop. Smaller quantities ofAzolla alone were not effective in this regard. The conservation of fertilizer N byAzolla, particularly when it fully covered the water, was reflected in a synergistic effect on rice dry matter production, amounting to 9% at the 30 kg N rate and 16% at the 60 kg N rate. In all likelihood this interaction is attributable to the higher efficiency of the applied N. The benefits ofAzolla in conserving basal urea-N even in small quantities (200-500 kg fresh material ha^–1), outweighed competition for the applied N and may be as important as its BNF. The most promising integratedAzolla/rice management systems emerging from our studies should be given further attention under field conditions.     

湿式氨法脱硫工艺及应用

随着二氧化硫对环境的污染越来越严重,国家环保总局对烟气二氧化硫排放控制严格,烟气脱硫显得日益重要。简单介绍了湿式氨法烟气脱硫技术的工艺流程及实际应用情况。湿式氨法脱硫工艺具有原料易得、脱硫塔不易结垢、不产生废水、副产品硫酸铵可作为农用肥料,减少了对环境的二次污染等特点,是较适合我国国情的烟气脱硫技术。     

15万t/a双甲氨合成联合装置设计

从工艺路线的比较、压力等级的选择、主要设备的选型等方面阐述了双甲氨合成联合装置的设计特点。结合生产运行实践,分析了双甲氨合成工艺路线的运行参数,与采用不同工艺的生产消耗和产品成本进行了对比。结果表明,该工艺吨氨节约成本80元,精醇成本为1112.6元/t,经济效益显著且生产运行稳定。     

探讨回收污水中有用的物质

重油催化裂化等的污水含汽油、硫和氨，将汽油、硫和氨回收是哈尔滨石化分公司具有发展前景的项目。     

氮化硅结合碳化硅管状制品的研制

简介了氮化硅结合碳化硅管状制品研制的必要性 ,确定了原材料及粒度配比 ,选择了合适的成型方法及添加剂 ,介绍了氮化烧成机理。研制出的制品其质量和使用性能接近同类进口产品 ,具有良好的市场前景和广泛的推广应用价值。     

Increasing urea-N efficiency for transplanted lowland rice by pneumatic injection: Yield and economics at the farm level

To increase the fertilizer-N efficiency in lowland rice (Oryza sativa L.) cultivation, new management practices are needed. Main cause of the present low efficiency is the low N recovery by plants, as a considerable part of the N applied is lost; deep placement techniques improve the recovery. A pneumatic injector, with which urea prills can be point-placed at a depth of 5–10 cm in paddy soils, was tested in 38 on-farm trials in 1989/90, mostly during the wet season. The experiments, located in Africa and Asia, focussed on differences in grain yield between conventional methods of broadcasting urea and injection by the pneumatic injector, at recommended N-rates. The study shows that the pneumatic injector is effective as a tool to improve the N fertilizer efficiency. The average yield increases per region, resulting from the use of the injector, ranged from about 250 to 1300 kg grain ha^–1. The value of the yield increase would allow most farmers to recover the costs of the injector within one season, even if labour was hired to carry out the injections. The average labour requirement of the injector was 40 hours ha^–1. In Indonesia, injection of prilled urea gave yields similar to those obtained with urea briquettes.     

Nitrogen fertilizer use in rainfed agriculture

Agronomic efficiency (AE) is defined as the increase in economic yield of a crop per unit fertilizer applied. Components of AE are physiological efficiency and apparent recovery fraction. The latter can be further separated into uptake efficiency and availability index. Ways to increase the nitrogen fertilizer use efficiency in rainfed agriculture through fertilizer management are discussed.     

Reduction of NO2 stored in a commercial lean NO x trap at low temperatures

Isothermal storage of NO₂ and subsequent reduction with different reducing agents (H₂, CO or H₂ + CO) in a lean NO _x trap catalyst was tested by Temperature Programmed Desorption (TPD) and Temperature Programmed Reduction (TPR) experiments at temperatures representative of automotive “cold-start” conditions (<200 °C) using a commercial NO _x trap catalyst. Results from the TPR experiments revealed that no reduction of stored NO₂ to N₂ was observed at 100–180 °C, and at 200 °C 10% reduction only of NO₂ to N₂ was measured. A special affinity of H₂ to form NH₃ was observed during the reduction of stored NO₂. The formation of NH₃ increases with increasing amount of stored NO₂ and decreases with increasing storage temperature. Direct relation exists between the amount of adsorbed and/or stored NO₂ and the formation of H₂O and NH₃.     

玉米黄粉酶解液在黄原胶发酵生产应用的研究

以玉米黄粉酶解液为氮源应用于黄原胶发酵培养基，探讨了蛋白酶种类、玉米黄粉酶解液添加量和酶添加量等因素对其发酵黄原胶粘度和产胶率的影响，并优化了复配氮源的种类及其复配比例。结果表明，碱性蛋白酶水解液作为氮源发酵黄原胶的粘度和产胶率优于其它蛋白酶解液；当酶解液添加量为6%、碱性蛋白酶添加量为8kU时，发酵黄原胶的粘度和产胶率可以达到4235cp和24.4g/L。大豆蛋白与玉米黄粉酶解液复配效果优于与棉籽粉、豆粕粉、花生粉的复配；玉米黄粉酶解液与大豆蛋白复配比为3:7时，发酵黄原胶的粘度和产胶率可以达到5833cp和32.4g/L，与单独以大豆蛋白为氮源无明显差异。本研究为提高玉米黄粉资源利用率、降低黄原胶的发酵生产成本提供了新思路。