无隔膜槽中ACF电极成对电解脱色活性艳蓝KN-R

采用恒电流模式,同时以活性炭纤维(ACF)为阳极和阴极,在无隔膜电解槽中研究了不同电流密度下蒽醌染料活性艳蓝KN-R的电化学脱色。结果表明在1.0~1.5mA.cm-2时,电解槽中发生阳极电氧化和阴极电还原同时进行的成对电解脱色。成对电解的发生,可以提高电解槽的工作处理能力。当电流密度为1.1mA.cm-2时,脱色率达到87%。     

航天推进剂废水超临界水氧化反应法处理研究

采用新兴的绿色坏保技术-超临界水氧化反应法，对含偏二甲肼的航天推进剂废水进行了处理研究。试验结果表明，采用小型的管道式连续SCWO反应系统能够迅速将该类推进剂废水中的毒害成分-偏二甲肼彻底分解为无害的CO2和N2。反应温度和反应停留时间是影响偏二甲肼去除率的主要因素，当反应温度超过500℃，停留时间达到95s时，偏二甲肼的COD去除率大于99．9％，完全达到了国家航天推进剂水污染物排放标准的要求。     

中空纤维超滤膜去除乳酸钙中蛋白质的研究

发酵法联合生产乳酸-乳酸钙工艺中,分离出的乳酸钙产品含有蛋白质、还原糖、重金属等杂质,影响产品的品质。本实验研究了中空纤维膜对乳酸钙中蛋白质的去除,并分析了压差、温度、浓度及pH值等因素的影响。得到了较好的工艺操作条件为Δp=0.05MPa,Δ=30g/L,30°C,pH=4。进一步提出用多步超滤能提高蛋白质的去除率15%～27%。     

改良MEA脱碳技术在小氮厂变换气脱碳中的应用

介绍了改良MEA脱碳技术的基本原理、工艺特点以及在工业中的应用情况，实践表明，改良MEA提高了溶液的吸收能力，降低了再生热耗，解决了MEA易降解损耗等问题。     

A2O工艺缺氧生物磷去除

A lab-scale anaerobic-anoxic-oxic （A^2O） process used to treat a synthetic brewage wastewater was investigated. The objectives of the study were to identify the existence of denitrifying phosphorus removing bacteria （DPB）, evaluate the contribution of DPB to biological nutrient removal and enhance the denitrifying phosphorus removal in A^2O bioreactors. Sludge analysis confirmed that the average anoxic P uptake accounted for approximately 70% the total amount of P uptake, and the ratio of anoxic P uptake rate to aerobic P uptake rate was 69%. In addition, nitrate concentration in the anoxic phase and different organic substrate introduced into the anaerobic phase had significant effect on the anoxic P uptake. Compared with conventional A^2O processes, good removal efficiencies of COD, phosphorus, ammonia and total nitrogen （92.3%, 95.5%, 96% and 79.5%, respectively） could be achieved in the anoxic P uptake system, and aeration energy consumption was saved 25%. By controlling the nitrate recirculation flow in the anoxic zone, anoxic P uptake could be enhanced, which solved the competition for organic substrates among poly-P organisms and denitrifiers successfully under the COD limiting conditions. Therefore, in wastewater treatment plants the control system should be applied according to the practical situation to optimize the operation.     

载锰氮化碳催化臭氧法降解水中草酸研究

草酸是废水中多种有机物氧化降解的中间产物,与臭氧反应速率很低,难以直接氧化去除。本研究通过热解法煅烧不同摩尔比例的三聚氰胺与醋酸锰(Ⅲ)二水合物,制备出不同负载量的载锰氮化碳催化剂,并研究了不同条件下载锰氮化碳催化臭氧法对草酸的降解效果,考察三聚氰胺与醋酸锰摩尔比、催化剂投加量、p H值、臭氧浓度等因素以及叔丁醇对草酸去除效果的影响。实验结果表明:相对于单独臭氧氧化而言,载锰氮化碳催化臭氧法可以极大的提高草酸的去除率,在投加0.15 g/L三聚氰胺与醋酸锰20∶1的催化剂后,草酸在60 min的TOC去除率可达到89.1%。叔丁醇加入对草酸的去除率影响较小,表明·OH在载锰氮化碳催化氧化草酸的过程中起作用但不是唯一因素。     

Absorption of carbon dioxide in alkanolamines in the presence of fine activated carbon particles

The rates of absorption of CO₂ into water and 0.1 kmol/m³ aqueous solutions of MEA, DEA and AMP were measured in a stirred cell with a flat gas-liquid interface in the presence of fine activated carbon particles. Experiments showed that the rates of absorption increased significantly with increases in the loading of activated carbon up to about 6 kg/m³ and thereafter remained constant.     

Influence of anode material on the electrochemical oxidation of 2-naphthol: Part 2. Bulk electrolysis experiments

The electrochemical oxidation of 2-naphthol has been studied by galvanostatic electrolysis, using a range of electrode materials such as lead dioxide, boron-doped diamond (BDD) and Ti-Ru-Sn ternary oxide anodes. The influence of some operating parameters, such as current density, flow-rate and chloride concentration on naphthol oxidation has been investigated in order to find the optimum experimental conditions. Measurements of chemical oxygen demand, HPLC and total organic carbon have been used to follow the oxidation. The experimental data indicate that on PbO₂ and BDD, naphthol oxidation takes place by reaction with electrogenerated hydroxyl radicals and is favoured by low current density and high flow-rate. On the contrary, on a Ti-Ru-Sn ternary oxide the mineralisation of naphthol occurs only in the presence of chloride ions that act as redox mediators and COD removal is affected by chloride concentration and is not significantly influenced by the current density and mass-transfer coefficient. From a comparison of the results of the three electrodes it has been found that boron-doped diamond gives a faster oxidation rate and better current efficiency.     

γ-Al2O3载体制备中水洗脱氯工艺的连续化

通过正交实验，研究了γ-Al₂O₃载体制备中拟薄水铝石水洗的连续化。方差分析表明，第一阶段洗水的pH是影响脱氯效果的关键因素，初步得出水洗连续化的优化条件。与国内外传统的间歇式水洗相比，收率从80%提高到99.7%，所需洗水量仅为原来的1/3，而处理500 kg物料的生产周期也从10 h缩短到2～3 h。