低位真空冷却装置在磷酸系统中的应用

葛丰化工厂磷酸萃取槽反应热不能有效移出,限制了生产能力的提高,通过采用低位真空冷却装置移走反应热,并同时改造水循环系统。改造后,投矿浆量达16t/h〔矿浆w(H2O)35%〕,生产能力从技改前2.67tP2O5/h提高到4.56tP2O5/h,萃取温度稳定控制在83～85℃。由于结晶状况改善,萃取率、洗涤率分别提高达96.33%、99.04%,能耗从181.3kW·h/tP2O5降低到149.8kW·h/tP2O5,含氟废气排放量从30000m3/h减少到小于6000m3/h。     

水泥生产除尘效果模糊综合评价研究

文中阐述了基于层次分析的水泥生产除尘效果模糊综合评价方法。利用层次分析将复杂的决策系统分解成若干个简单的决策系统，将模糊数学应用于判别水泥生产除尘效果的优劣，使得难以量化的质量评价问题转化成定量的结果。     

环氧丙烷-苯乙酮二元体系的恒温汽液平衡研究

采用改进的“p x法”汽液平衡测定装置测定二物质沸点差达 167.7℃的环氧丙烷 苯乙酮二元体系在3 0 0K、 3 0 5K下的p x数据 ;并用直接法计算确定平衡汽相组成y。     

Thermoelectric properties of SbNCa3 and BiNCa3 for thermoelectric devices and alternative energy applications

Thermoelectric properties of two antiperovskites SbNCa₃ and BiNCa₃ are calculated using first principles calculations. High values of Seebeck coefficients are observed for these materials. Electrical and thermal conductivities are also calculated. Increase in thermal conductivity and decrease in electrical conductivity are found with increasing temperature. The maximum values of thermal conductivity are 92×10¹⁴  W/m K s and 88×10¹⁴  W/m K s for SbNCa₃ and BiNCa₃ respectively at a temperature of 900 K. The peak values of 5×10²⁰/Ω m s and 5.2×10²⁰/Ω m s are achieved for n-type SbNCa₃ and BiNCa₃ respectively at a temperature of 300 K. Figure of merit is achieved for these materials at room temperature which shows that these materials can be useful for thermoelectric devices and alternative energy sources.     

余热锅炉省煤器技术改造

由于原设计缺陷，该余热锅炉省煤器的管束易发生爆管。经改造，省煤器高温段按沸腾式设计，中温段和低温段按非沸腾式设计，并采用热管省煤器技术，消除了爆管现象，使该余热锅炉蒸汽产量由8t/h提高到15t/h，能耗(折算成标准燃料油)下降了4．0kg／t。     

Performance of floating cum tilted-wick type solar still with the effect of water flowing over the glass cover

A simple transient performance of floating cum tilted-wick type solar still has been presented by incorporating the effects of water flowing over a glass cover, heat capacity of tilted-wick water surface and floating-wick water surface. Explicit expressions for flowing water, glass, tilted-wick water surface and floating-wick water surface temperature and efficiency of the system have been derived. Numerical calculations have been carried out for a typical day in the month of March 2004. The relative standard deviations between the numerical and experimental results of different temperature components of the proposed still have been found. The results indicate that the relative standard deviations between theoretical and experimental results are less than 8% (glass cover), 2% (tiltedwick water surface), 1% (floating-wick water surface) and 2% (flowing water at the lower end of the glass cover) an average for the working hours of the day. Moreover, based on the numerical results, the following conclusions have been drawn: (i) glass cover temperature decreases significantly; (ii) the effect of water flowing over the glass cover has a fascinating effect on the production of distillate output during peak sunny hours; (iii) water flow rate of 1.5 m/s is optimum, and beyond it the efficiency decreases. Experimental investigations have been performed at Sri Ramakrishna Mission Vidyalaya College of Arts and Science, Coimbatore, India.     

臭氧氧化处理法对聚丙烯表面涂装性的改良 Ⅱ.臭氧浓度及臭氧发生气组成对聚丙烯表面氧化过程的影响

讨论了用臭氧氧化法对聚丙烯表面进行涂装性改良时,臭氧浓度和臭氧发生气组成对聚丙烯表面氧化过程的影响。我们发现,随臭氧浓度的增加,各种聚丙烯表面上COOH基的生成速率变大,而OH基的生成速率变小,且表面上COOH基和OH基的生成比变大。在相同的臭氧浓度下,COOH基的生成速率和聚丙烯种类无关,各种聚丙烯表面上COOH的生成速率大体相等。而OH基的生成速率及COOH基、OH基生成比和聚丙烯的种类有关,就COOH基和OH基生成比而言,其大小顺序为均聚物>嵌段共聚物>无规共聚物。臭氧发生气组成对聚丙烯表面氧化过程有很大的影响。和臭氧发生气为空气时的情况相比,当臭氧发生气为氧气时,即使其体系中臭氧浓度的变化很小,也会引起较大的表面氧吸收量或表面氧化分解量的变化。     

Single-phase gold/palladium catalyst: The nature of synergistic effect

The liquid phase oxidation of glycerol with oxygen has been studied using mono and bimetallic catalysts based on Au and Pd metals supported on activated carbon, in order to study the effect of the metal on the distribution of the products and on activity of catalysts. It was found that by using bimetallic catalysts (Au–Pd) a strong synergistic effect was shown. By using a preformed nucleating centre we were able to obtain a single alloyed phase, which allowed us to address the synergistic effect to the presence of alloyed Au/Pd. The advantage of using this latter catalyst lies not only in the high activity but also in a prolonged catalyst life. Although a partial leaching of palladium and assembling of the particles have been revealed by ICP and HRTEM respectively, activity after 10 re-cycles decreased less than expected (about 10%).     

活性炭变压吸附回收环氧乙烷装置排放气中的乙烯

以活性炭为吸附剂，对工业环氧乙烷装置排放气中乙烯的回收进行了研究。测定了环氧乙烷装置排放气中主要组分的吸附等温线及脱附性能，发现活性炭对乙烯的吸附量较高，与氧气、氮气和氩气等组分的分离度较大。在此基础上，研究了活性炭的变压吸附性能，在常规真空脱附工艺条件下，乙烯的回收率较低，但通过提高脱附真空度或进行甲烷反向吹扫，可以大大提高乙烯回收率和惰性气体的脱附率。     

Unipol气相法聚烯烃液体催化剂技术进展

介绍了Unipol气相法聚烯烃工艺液体催化剂的成分、加入反应器的方式和喷嘴结构及控制催化剂液滴尺寸方法等方面的最新进展情况。