西门子OP170B操作面板在重型车床上的应用

介绍了西门子(SIEMENS)的SIMATICHMI(人机界面)操作面板OP170B的主要特性和使用方法以及在CC61250×160重型车床大修及电气改造上的应用。     

基于以太网的PLC与PC机通信

该文介绍了如何实现富士MICREX—FF70SPLC通过富士MICtLEX—FFFU170B以太网模块与PC机的以太网通信。FujiFFU170B以太网支持四种通信模式,本项目中使用了命令设置模式来实现PC与PLC之间的以太网通信。实现了PC机对PLC的远程控制。     

Performance of heat pumps charged with R170/R290 mixture

In this study, thermodynamic performance of R170/R290 mixture is measured on a heat pump bench tester in an attempt to substitute R22. The bench tester is equipped with a commercial hermetic rotary compressor providing a nominal capacity of 3.5 kW. All tests are conducted under the summer cooling and winter heating conditions of 7/45 °C and −7/41 °C in the evaporator and condenser, respectively. During the tests, the composition in R170/R290 mixture is varied from 0% to 10% with an interval of 2%. Test results show that the coefficient of performance (COP) and capacity of R290 are up to 15.4% higher and 7.5% lower, respectively than those of R22 for two conditions. For R170/R290 mixture, the COP decreases and the capacity increases with an increase in the composition of R170. The mixture of R170/R290 mixture at 4%/96% composition shows the similar capacity and COP as those of R22. For the mixture, the compressor discharge temperature is 17–28 °C lower than that of R22. For R170/R290 mixture, there is no problem with mineral oil since the mixture is composed of hydrocarbons. The amount of charge is reduced up to 58% as compared to R22. Overall, R170/R290 mixture is a good long term ‘drop-in’ candidate from the view point of energy efficiency and greenhouse warming to replace R22 in residential air-conditioners and heat pumps.     

大型火电厂可编程调节器的调试与实践

在大型火电厂（１２５ＭＷ 机组） 使用９０ 年代高新科技产品热控ＹＳ１７０ 可编程调节器有利于热控的顺利投入和安全经济运行。由于是国内首次采用此可编程调节器，笔者根据在桥头发电厂现场调试的实践，对该设备的概况和调试中的一些问题做一介绍。     

西门子OP170B操作面板在重型车床上的应用

介绍了西门子(SIEMENS)的SIMATIC HMI(人机界面)操作面板OP170B的主要特性和使用方法以及在CC61250×160重型车床大修及电气改造上的应用.     

MLS3-170型采煤机牵引部液压系统分析

采煤机是综合机械化采煤工作面的主要设备,采煤机故障能否及时排除关系到生产量能否完成。液压牵引部结构复杂,故障不易排除,把牵引部液压系统分解为十大回路,并对十大回路功能、作用及组成做了详细分析,有利于故障检查、分析及排除。     

A new type of quaternary ammonium salt containing siloxane group and used as favorable dispersant in the surface treatment of C.I. pigment red 170

C.I. pigment red 170 is an important type of organic pigment. A new type of quaternary ammonium salt containing siloxane group was prepared and then used as a favorable dispersant in the surface treatment of pigment red 170. The quaternary ammonium salt was achieved from the reaction of N-(β-aminoethyl)-γ-aminopropyl-methyl-bimethoxy-silane and 3-chloro-2-hydroxypropyl-bimethyl-hexadecyl ammonium halide in isopropanol, and its structure was characterized by IR and NMR techniques. The flowability, dispersing extent, particle size, and wetting behaviors of pigment were determined and the results showed that a small amount of the above dispersant could bring to the high flowability, good dispersing stability, small particle size and excellent wettability of pigment red 170. We also proposed the scenarios of dispersing process of pigment red 170 based on the information obtained from above characterizations.     

170 GHz兆瓦级回旋管TE25,10准光模式变换器设计

为满足聚变用170 GHz回旋管高功率输出和高效率传输的要求,需将高阶工作模式TE_25,10转换为高斯波束;针对这一技术需求,完成了170 GHz、TE_25,10模式高效准光模式变换器的设计,准光模式变换器由辐射器和镜面系统组成。基于几何光学和耦合波理论,完成了Denisov型辐射器相关设计;基于矢量衍射定理和相位校正算法,设计了由一个抛物面镜面、一个准椭圆镜面及一个相位校正镜面组成的镜面系统;使用Surf3D软件对辐射器进行了优化和计算,使用三维全波仿真软件FEKO对镜面系统进行了优化和计算,主要对辐射器微扰幅值、位置分布及相位差进行了优化。所设计准光模式变换器系统的能量转换效率约为95.2%,波束在输出窗处的标量高斯含量约为97.6%,矢量高斯含量约为91.8%,达到了回旋管的应用要求。     

HEHEHP-煤油溶液淋洗的阴离子交换色层法分离稀土元素的研究

引言 用与水不相混溶的有机萃取剂作淋洗剂的离子交换色层法提出于1975年。1979年杨伯和等人用三脂肪胺硫酸盐的煤油溶液从吸附有铀的阴离子交换树脂上洗脱出高纯度的铀。1980年何寿椿等人用四苯硼钠的甲基异丁基酮等的溶液作淋洗剂在阳离子交换树脂柱上实现了Rb和Cs的分离。与此同时,江林根等人用HDEHP的煤油溶液作淋洗剂,在阳离     

BCJL-16倍尺飞剪控制系统的设计

主要介绍了BCJL～16倍尺飞剪控制系统的设计,包括系统的控制过程、系统的配置、PLC和TP170A的数据交换及其在倍尺飞剪控制程序中的应用。