尾矿和Na_2O对包钢稀选尾矿微晶玻璃的影响

利用熔融浇注法对包钢稀选尾矿微晶玻璃在生产过程中的流动性进行了研究,利用DSC,XRD,SEM等手段研究了尾矿和Na2O含量对微晶玻璃的析晶特性及其他物理性能的影响.结果表明,当其它成分不变时,随着尾矿含量的增加,流动性增强;当其它成分不变时,随着Na2O含量的增加,流动性增强;在本实验条件下,尾矿加入量较佳范围为40%~50%;Na2O较佳范围为3%~6%.     

Application of open-pit and underground mining technology for residual coal of end slopes

Given the conditions of residual coal from the boundary of a flat dipping open-pit mine,which uses strip areas mining and inner dumping with slope-covering,we propose an open-pit and underground integrated mining technology for residual coal of end slopes.In the proposal a conveyance road and ventilation conveyance near the slope are built,corresponding to the pit mining area and the surface coal mine dump,as well as an interval haulage tunnel and air-inlet tunnel.The outcome shows that such mining method may reduce the effect to slope stability from underground mining,it does not affect the dumping advance and has a high recovery rate of residual coal resources.The working face is timbered by single hydraulic props,transported by a scraper conveyor and supported by coal walls.This method of mining is one of layered top coal caving,with high resource recovery,low production cost where positive economic benefit can be realized.     

钼矿尾矿铜铅重金属离子溶出规律研究

为了评估钼矿尾矿的环境危害,通过105 d连续静态浸泡试验,定期监测钼矿尾矿浸泡液的pH值及其铜铅重金属离子浓度,研究了尾矿的离子溶出规律.结果表明,尾矿对酸性溶液有很强的中和能力,可将pH=3.5～6的酸性溶液在8 d内中和到pH=7的中性状态,并维持不变.液固比为1:10的浸泡液中Cu~(2+)和Pb~(2+)的浓度都在25 d内达到最大值(分别为29.52和9.40μg/L),此后浓度下降,并发生震荡,但Cu~(2+)和Pb~(2+)的浓度随时间的变化趋势不同.浸泡液中Cu~(2+)和Pb~(2+)的平均浓度分别为19.37和4.29μg/L,尾矿中Cu和Pb的平均溶出率分别为0.097%和0.043%.钼矿尾矿可在中性条件下长期释放Cu~(2+)和Pb~(2+),且Cu比Pb更容易溶出.     

Movement characteristics of Karst water in a deep mining area

In order to study the movement characteristics of groundwater in a deep mining area and solve the dispute of the distri-bution rule of hydro-chemical zoning which is contradicted by lixiviation water zoning in a horizontal direction, we directed our attention to the source of deep groundwater, its seepage and hydro-chemical characteristics in a typical mining area. We used a neotectonic water-control theory, chemical and isotope methods, as well as a method for analyzing dynamic groundwater conditions. The results indicate that 1) Karst water in the deep and medium parts of this mining area is recharged by vertical leakage through neotectonic fractures rather than seepage along strata from subcrop parts or surrounding flows; 2) from surface to deep leakage paths, the variation in the types of chemical groundwater agrees with the normal lixiviation water distribution rule and the age of mixed groundwater increases; 3) the water-rich zones along neotectonic fractures correspond with water-diluted zones in a hori-zontal direction; 4) the leakage coefficient and water capacity of aquifers increases during the flow process of Kant water along the antidip direction (from west to east) and 5) Karst water in shallow mining areas forms a strong runoff belt along strikes and quickly dilutes the water from deep and medium mining areas. Overall, chemical and dynamic water characteristics actually agree with in terms of the entire consideration for differences in vertical leakage and abnormalities in the zone of water chemical distribution, along a horizontal runoff direction.     

Explosion limits for combustible gases

Combustible gases in coal mines are composed of methane, hydrogen, some multi-carbon alkane gases and other gases. Based on a numerical calculation, the explosion limits of combustible gases were studied, showing that these limits are related to the concentrations of different components in the mixture. With an increase of C4H10 and C6H14, the Lower ExplosionLimit (LEL) and Upper Explosion-Limit (UEL) of a combustible gas mixture will decrease clearly. For every 0.1% increase in C4H10 and C6H14, the LEL decreases by about 0.19% and the UEL by about 0.3%. The results also prove that, by increasing the amount of H2, the UEL of a combustible gas mixture will increase considerably. If the level of H2 increases by 0.1%, the UEL will increase by about 0.3%. However, H2 has only a small effect on the LEL of the combustible gas mixture. Our study provides a theoretical foundation for judging the explosion risk of an explosive gas mixture in mines.     

Selected elements of rock burst state assessment in case studies from the Silesian hard coal mines

Exploitation of coal seams in the Upper Silesian Coal Basin is conducted in complex and difficult conditions. These difficulties are connected with the occurrence of many natural mining hazards and limitations resulting from the existing in this area surface infrastructure. One of the most important problems of Polish mining is the rock burst hazard and reliable evaluation of its condition. During long-years' mining practice in Poland a comprehensive system of evaluation and control of this hazard was de-veloped. In the paper the main aspects of rock burst hazard state evaluation will be presented, comprising: 1) rock mass inclination for rock bursts, I.e., rock strength properties investigation, comprehensive parametric evaluation of rock mass inclination for rock bursts, prognosis of seismic events induced by mining operations, methods of computer-aided modelling of stress and rock mass deformation parameters distribution, strategic rock mass classification under rock burst degrees; 2) immediate seismic and rock burst hazard state evaluation, I.e., low diameter test drilling method, seismologic and seismoacoustic method, comprehensive method of rock burst hazard state evaluation, non-standard methods of evaluation; 3) legal aspects of rock burst hazard state evaluation. Selected elements of the hazard state evaluation system are illustrated with specific practical examples of their applica-tion.     

淮水北调输水管道关键技术研究与应用

介绍了输水主管道的设计制造关键技术问题,通过比较备选管材特性,研究了选用的PCCP管道设计制作技术、空气阀布置设计和管道基座安装技术,对管道铺设方案、煤矿塌陷区的地基变形进行了分析。     

广西老堡铅锌矿褶皱形成机制及其控矿规律

老堡铅锌矿床主要赋存在陡山沱组白云岩或老堡组硅质岩中,顺层产出,受地层与褶皱的双重控制。矿区主干褶皱为一复式向斜,由2个次级向斜和1个次级背斜组成。从构造几何学、运动学角度,运用现代测试技术,对矿区的小构造、显微构造和组构进行构造分析后揭示,老堡褶皱构造的形成机制是以弯滑作用为主、兼具弯流作用的纵弯褶皱作用的产物。铅锌矿体主要赋存在褶皱的转折端虚脱部位及两翼滑移量较大的层间滑动破碎带中。     

矿井通风机西门子无刷同步机电控系统分析

给出了矿井通风机西门子无刷同步电动机电控系统的硬件设备的结构图和基于功率因数cosφ、励磁电流if双闭环统计系统的控制结构图,分析了在恒功率因数控制时励磁电流随负载变化的调节过程;论述了本电控系统的风机准备启动、定子电源合闸、亚同步投励、停车等控制程序和风机运行参数检测、故障报警、故障保护的程序。本系统具有技术性能好、可靠性与可维性高的显著优点。对从事此类技术工作的人员具有参考意义。     

尾矿坝渗流场与应力场耦合作用的数值分析

在分析岩土介质渗流场与应力场耦合的用机理的基础上,建立二者耦合模型。以此为基础,针对具体的尾矿坝,进行渗流场与应力场相互耦合的数值模拟。模拟计算了单独考虑渗流场,单独考虑应力场以及两场耦合情况,并将三种情况进行了对比分析。结果表明:在耦合场中渗流量比单独计算时小;耦合场中沉降量比单独计算时大,且最大沉降量发生区域大致相同;耦合场中各向应力总量最大值比非耦合场中大,局部出现应力集中现象;耦合场中应力等值线分布规律与非耦合场基本一致。