一次风机节能改造

为解决一次风机出口风压低、火焰无力度、系统功耗高等问题,采用空气悬浮风机对其进行节能改造。拆除原有的一次风机备用风机,在原有底座上安装空气悬浮风机,整体设计安装悬浮风机出口管道。改造后,一次风机出口风压明显增大,煤粉燃烧充分,火焰调整灵活,每小时可节电30kWh,两处对空排放管道加装消声器,降噪效果显著。     

高纯天然石膏水热法制备硫酸钙晶须研究

以高纯天然石膏为原料，加压水热法制备高品质硫酸钙晶须。采用常规分析方法、XRD和扫描电镜等手段分析和表征石膏原料和硫酸钙晶须产品。结果表明，制备硫酸钙晶须的最优条件为：料浆质量分数为6.0%，转晶剂氯化镁加入量为石膏质量的0.05%，硫酸加入量为水体积的1.0%，反应时间为4.0 h，快速过滤干燥即得硫酸钙晶须产品。分析结果表明：硫酸钙晶须长度最大为280.4 μm，最小为19.59 μm，平均长度为80 μm；硫酸钙晶须直径最大为5.86 μm，最小为0.20 μm，平均直径为2.67 μm；通过统计分析可知，长径比范围为10～80。     

Tensile Stress Relaxation of Alumina at High Temperature

The development of a tensile testing methodology for ceramics which enables a stress vs strain-rate response to be measured at high temperature is described. The test involves a carefully controled stress relaxation test at constant total strain using an experimental procedure and phenomenological analysis previously developed for metallic materials. It is demonstrated here with preliminary tests on alumina at 1050° and 1150°C. This offers, with further development, the possibility of establishing design stresses associated with low strain-rate behavior for structural applications. The results demonstrate that data covering four decades of strain rate may be generated in tests lasting a few hours. The inelastic strain consists of substantial anelastic recoverable strain in addition to a permanent creep strain.     

高效液相色谱法测定烟叶提取物中茄尼醇的含量

采用高效液相色谱法测定烟叶提取物中茄尼醇含量的方法。条件为:HypersilC18色谱柱,流动相为异丙醇∶乙腈=60∶40(V/V),流速1.0mL/min,紫外检测波长210nm,柱温30℃。实验结果表明,该方法在茄尼醇进样量为1-10μg时有良好线性关系(Y=1.66×105X-3.25×103,r=0.9998);加标回收实验(n=5)的平均回收率为99.3%,RSD为0.93%。该方法简便、精密、准确。     

高浓度烤烟专用肥肥效试验

介绍高浓度烤烟专用肥肥效试验。结果表明：楚雄磷肥厂生产的高浓度烤烟肥，可以代替进口的同类化肥。     

Proposal of a uniform color scale for virgin olive oils

A new color scale was developed from a broad data set of 1700 virgin olive oil samples over four crop seasons, which can be considered highly representative of the whole color range of virgin olive oils available in Spain. This color scale provides a new set of 60 color standards, improving the results achieved by the old 60-color standards proposed by the bromthymol blue method. Seeking the greatest possibility of including a near match between colors of virgin olive oils and proposed standards, we developed our new color scale using a recent uniform color space, with standards placed in a regular rhombohedral lattice like the one employed by the Uniform Color Scales of the Optical Society of America. The average color difference between each of the 1700 virgin olive oils and its nearest standard is reduced from 8.17 CIELAB units, using the bromthymol blue standards, to 3.99 CIELAB units using the new standards. Within a color tolerance of 7.0 CIELAB units, 93.2% of our virgin olive oils can be classified with the new standards, but only 59.1% with the bromthymol blue ones. In the interest of future adoption, the performance of the new color standards should be tested by industry and researchers.     

高固体分丙烯酸树脂相对分子质量的研究

采用溶液聚合法合成高固体分丙烯酸树脂,用凝胶渗透色谱(GPC)法分析引发剂的种类和用量、反应温度及聚合工艺对丙烯酸树脂的相对分子质量及其分布的影响。结果表明,选用偶氮二异丁腈和过氧化苯甲酰两种引发剂进行复配可提高聚合物的相对分子质量;采用“饥饿态”聚合工艺进行聚合反应可有效控制聚合物的相对分子质量,且相对分子质量分布均匀,分散度小于2;当引发剂用量为2%,在110℃的反应条件下制得的丙烯酸树脂的综合性能优异,固含量超过70%,相对分子质量可达4万。     

压缩感知中高斯矩阵的优化研究

为了优化高斯矩阵,对部分哈达玛矩阵与高斯矩阵的统计学参数作了对比分析,确定了导致部分哈达玛矩阵信号重构能力好的主要因素,并提出了高斯矩阵优化算法.验证了优化算法对不同规模高斯矩阵的通用性和有效性,确定了优化矩阵对各种稀疏信号重构算法的适用性.最后对优化矩阵的性能作了初步的理论和实验分析,优化矩阵的信号重构能力可达到、甚至超过哈达玛矩阵.研究成果为测量矩阵的分析、设计和优化提供了新的思路和方法.     

Harnessing the Melting Peculiarities of Ultra‐High Molecular Weight Polyethylene Fibers for the Processing of Compacted Fiber Composites

Summary: Compacted fiber composites offer unique properties due to their lack of an extraneous matrix. The conditions of processing ultra‐high molecular weight polyethylene (UHMWPE) fibers were simulated in a heated pressure cell. In situ X‐ray diffraction measurements were used to follow the relevant transitions and the changes in the degree of crystallinity during melting and crystallization. The results strongly support the suggestion that the hexagonal crystal phase, in which the chain conformation is extremely mobile on the segmental level, constitutes the physical basis of compaction technologies for processing UHMWPE fibers into a single‐polymer composite. This report suggests that using a pseudo‐phase diagram outlining the occurrence of different phases during slow heating and the degree of crystallinity can provide valuable insight into the technological parameters relevant for optimal processing conditions.

Degree of crystallinity as a function of pressure and temperature in a region relevant to compaction processes.     

聚偏氟乙烯/聚丙烯酸酯复合乳液的合成与性能

在含氟表面活性剂存在下，将聚偏氟乙烯超声分散于甲基丙烯酸甲酯和丙烯酸丁酯的混合单体中进行乳液聚合，制备了聚偏氟乙烯／聚丙烯酸酯复合乳液。采用动态光散射DLS、透射电镜TEM和红外光谱FT—IR对乳液组成及乳胶粒子的形态进行了表征，并对聚合物胶膜的性能进行了测试分析。结果表明：聚偏氟乙烯的加入，使复合乳液膜的拉伸强度显著增大，吸水率减小。