泡沫玻璃窑炉温度控制系统的设计与应用

针对泡沫玻璃生产线窑炉温度控制的工艺要求,设计并应用了P L C温度控制系统、P I D控制算法。现场应用表明,该系统运行稳定可靠,设计先进,界面友好,控制精度高,具有较高的实用价值,从而保证了产品的质量,降低了能耗,提高了企业竞争力。     

FBG传感器在水下结构工程中的应用

近年来,光纤光栅传感技术在我国发展很快,已经在桥梁、土建等多个领域中得到了应用,但在水工领域的应用还很少.本文结合白鹤梁工程实例,探索该项技术在这一领域应用的可行性.开展的光纤光栅应变、温度传感器在水下工程领域中较大规模的应用研究结果表明：FBG具有很好的防水性能,测试精度高,长期稳定性好,信号传输距离远,为水下结构的长期监测提供了一种可靠有效的手段.     

基于动态BP网络的实验电炉温度控制系统

针对一类不允许出现超调的工艺参数,提出了采用动态BP网络对工艺参数进行控制,可以达到良好的效果。并以实验电炉为对象,用工控机对其炉温进行控制,结果表明,采用动态BP网络进行控制,可以无超调地无限逼近给定值,控制精度高,控制时间较短。因此可以认为,用动态BP网络对这一类工艺参数的控制是有效的。     

Abnormal growth of austenite grain of low-carbon steel

Niobium is an important alloying element for the steel. To know further the effect of Nb in the steel, the contrast experiments on the austenite grain growth of the 0.015%Nb and free Nb steels were carried out using Gleeble 1500 thermomechanical simulator. The experimental results indicate that the austenite grain of 0.015%Nb steel is finer than that of Nb free steel at 1150–1230 °C. And when the heating temperature arrives the critical temperature 1240 °C, the austenite grain of Nb steel suddenly grows up, while the austenite grain of Nb free steel changes little. Finally, the austenite grain of Nb steel is obviously coarser than that of Nb free steel. By transmission electron microscopy (TEM) using a carbon extraction replica technique, the precipitates of Nb(C,N) were not observed in the 0.015%Nb steel. It is concluded that the grain-boundary internal adsorption of Nb atoms leads to the result.     

Particularities of condensation of atoms with increased kinetic energy

Novel universal method for measurement of the condensation coefficient α is developed. Using this method, noticeable difference between measured (α≈0.8) and expected (α≈1) values of the condensation coefficient for sputtered Cr atoms was revealed for the first time. The effect is assumed to be a result of considerable elevation of the surface temperature during atomic condensation induced by the energy delivered to the condensation surface by sputtered atoms and from the plasma.     

High temperature piezoelectric materials: Defect chemistry and electro-mechanical properties

Langasite (La₃Ga₅SiO₁₄, LGS) and gallium orthophosphate (GaPO₄) resonators exhibit piezoelectrically exited bulk acoustic waves at temperatures of up to at least 1400^∘C and 900^∘C, respectively. Their mass sensitivity at elevated temperatures has been found to be about as high as that of quartz at room temperature. Within its operation temperature range, GaPO₄ shows significantly lower losses than LGS. Factors restricting application relevant properties of LGS at elevated temperatures, such as the mass resolution, include excessive viscous damping. Therefore, the effective viscosity is determined as a function of the temperature by fitting the calculated complex impedance to the experimental data in the vicinity of the resonance frequency. The viscosity shows an Arrhenius-like behavior if a temperature independent contribution is subtracted. The activation energies of the viscosity for LGS and GaPO₄ correspond to those of the bulk electrical conductivity for each material. Viscosity and conductivity are obviously correlated. Therefore, it is highly likely that the predominant conductivity mechanism also controls the mechanical damping. First attempts to minimize the viscosity of LGS by doping are undertaken. Very light doping does, however, not change the conductivity and viscosity of LGS. Higher doping levels have to be applied and tested. Based on the electromechanical properties given for undoped LGS, the applicability of this material as resonant gas sensor at 600^∘C is demonstrated.     

多元回归分析在电热式平板硫化机热板温度场中的应用

分析电热平板硫化机热板温差大的主要影响因素,重点研究热源分布情况对温差的影响.以400×400电热平板硫化机为例,应用多元回归的二次响应曲面模型及其子模型,对热源间距(电热管间距)与热板表面最大温差之间的函数关系进行预测,检验并分析预测结果(拟合曲线)的可靠程度,从而得出较合理的数学模型,即完整二次响应曲面模型.此模型可为工程设计提供参考依据.     

活性污泥生物吸附性能的研究

探讨了活性污泥生物吸附作用的影响因素。吸附性能随温度升高而降低,在20~30min之间,可达到吸附平衡,且温度越高,达到吸附平衡的时间越长;活性污泥对悬浮性有机物的吸附性能高于对溶解性和胶体性有机物的吸附;对高浓度污水吸附性能高于低浓度污水的吸附性能;抑制剂对污泥的吸附作用有影响。     

从EOS/MODIS数据中提取夜间强对流云团的闪电信息

主要探索用EOS/MODIS极轨卫星监测闪电的可行性,应用大气和云辐射原理以及云中水滴mie散射的原理,从EOS/MODIS的中红外通道及热红外通道中提取夜间强对流云团产生的闪电信息,并可由强对流卫星云图的云顶温度确定可能出现冰雹的区域,对减灾、预警提供宏观信息。     

用于现场测试的温湿度采集系统软件

介绍了用于现场测试的温湿度采集系统软件新的特点、功能及其设计和使用.