首钢2号高炉的技术进步

介绍首钢2号高炉大修采用的新技术、开炉操作和投产以来的生产情况。     

CX6112车铣复合机床设计方案的研究与探讨

文章较系统地论述了车铣复合机床设计方案的形成过程，同时分析了该设计方案的持点，并简要介绍了该产品的主要技术参数和用途，简评了该产品的技术水平。     

Al2O3对唐钢高炉炉渣性能的影响

针对唐钢近2年提高进口矿配比后，Al2O3含量升高对炉渣流动性带来的不利影响，对唐钢高炉的炉渣性能进行了试验研究。并结合国内同行业的生产实践经验，从理论上分析了炉渣中Al2O3及MgO的适宜含量范围，着重论述了唐钢所处冀东矿区条件下降低Al2O3的主要途径及适应高Al2O3炉渣的具体措施。     

板式换热器在中小高炉炉体冷却中的应用探讨

中小高炉炉体软水冷却采用的空冷器冷却效果随季节变化而波动，夏天时最高进高炉水温达到70℃以上，影响了高炉的安全高产和使用寿命。板式换热器以波纹板为传热面，传热系数高、体积小、拆装清洗方便，换热强度高，换热效果好，根据中小高炉炉体冷却软水系统流量大、温差小等特点，宜选用316或316L不锈钢材质、结构矮胖型、开二备一、3台并联的板式换热器。济钢2^#355m^3高炉采用BR1．IXC(1．0／100)200．2型水-水板式换热器，软化水进高炉温度全年稳定在34～39℃。     

厅堂音质评价参量的相关性分析

当代室内声学专家经常选用的评价厅堂音质的物理参量，其间有几个量是相关的。作为室内音质设计的依据．必须寻找基本相互独立的参量，才有更大的实用意义。     

多面体含能材料的爆速和爆压预估

当采用R-P经验方法预估多硝基笼状化合物最大理论密度下爆速和爆压时,需要修正F因子中与分子结构有关的A/3项,使F因子包含有来自笼状分子高晶体密度和分子内部高张力能的贡献。与K-J方法相比,改进R-P方法既保持了原式的优点,又使预估结果获得明显改善。把K-J方法预估结果作为基础数据,利用改进R-P方法估算25种多硝基笼状化合物的爆速和爆压,结果表明该方法的相对误差分别为±1.9％和±5.2％。而用R-P方法时,预估爆速和爆压的相对误差分别为±14.0％和±21.4％。     

Design and Characterization of the CLIMPAQ,Chamber for Laboratory Investigations of Materials,Pollution and Air Quality*

A test chamber has been developed in order to provide a small and simple emission testing facility capable of testing construction products in a climate where the important climatic parameters such as temperature, ventilation rate and air velocity can be varied independently around typical indoor values. The test chamber CLIMPAQ is made of panes of window glass. Other main surface materials are stainless steel and eloxated aluminium. The chamber has a volume of 50.9 litres and is designed to meet the requirements for quantifying air pollution. In this investigation human subjects acted as air pollution judges, and chemical characterization of the air pollution was carried out. Carpet, linoleum, wall paint and seal- ant were tested simultaneously in the CLIMPAQ and in four other chambers ranging from a full-scale chamber of 28 m³ to a field and laboratory emission cell of 3.5· 10^?5m³. Product ranking is the same in all chambers for the sensory measurements. Emission rates based on sensory measurements differ for all products less than 100 % except for tests in a 3-litre chamber where emission rates were higher. Chemical measurements differ up to approximately 10 times for the same product in different chambers. Deviations appear to be the result of different environmental parameters in the various chambers. Low air concentrations or high specific ventilation rates seem to increase emissions, while differences in air velocities and sink properties may also be the cause of differences in emission rates.     

高炉煤气干法除尘技术发展现状及宝钢应用前景

在对高炉煤气干法除尘技术应用现状进行综合分析的基础上结合宝钢实际，提出宝钢应用此技术的相关建议。     

马钢热电总厂高炉煤气综合利用问题研究与思考

介绍马钢热电总厂高炉煤气综合利用的情况及所产生的经济和社会效益，剖析综合利用过程中的问题，提出进一步高效、安全、优化高炉煤气综合利用的建议和思路。     

响洪甸电站引水隧洞进口水下岩塞爆破施工

响洪甸抽水蓄能电站水下岩塞爆破施工要求高,技术新,难度大.由于施工准备充分,并进行了一系列材料及施工试验,工程进展顺利,排孔造孔、导洞药室开挖、药管与起爆体加工、装药与堵塞、网络施工、充水补气等工程施工质量符合设计要求,岩塞爆破准时成功起爆.