三石─堇青石匣钵的研制

引入“三石”改善堇青石质匣钵性能,提高匣钵使用寿命。     

Thermal Shock Failure in Thick Epoxy Coatings

In this paper we describe an apparatus for reproducibly measuring thermal shock resistance of thick polymer layers bonded to metals. The thermal shock behavior is discussed in terms of epoxy samples bonded to an aluminum substrate. It was found that both high resin toughness and low resin thermal expansion coefficient improved thermal shock resistance of thick coatings, but only a sample containing 60wt. % glass beads did not develop a failure crack. Effects of sample thickness, temperature gradient, and resin composition on thermal shock behavior are discussed.     

微粉对矾土基超低水泥浇注料性能的影响

以高铝矾土熟料为主原料 ,加入 2 %的铝酸钙水泥及总量为 6 %的Al2 O3 微粉和SiO2 微粉 ,配制了矾土基超低水泥浇注料 ,研究了微粉对浇注料的烧结性能、力学性能及热震稳定性的影响。结果表明 :(1 )SiO2 微粉对浇注料的促烧结作用优于Al2 O3 微粉。这是因为与Al2 O3 微粉相比 ,由气相沉积生成的SiO2微粉的粒度小 ,比表面积大 ,活性较高。 (2 )随着SiO2微粉加入量的增加 ,在 1 1 0 0℃和 1 4 0 0℃处理后的常温强度以及在 1 30 0℃和 1 4 0 0℃下的高温抗折强度和抗热震性明显提高。这是由于引入的SiO2 微粉在高温下与Al2 O3 反应生成的针状莫来石穿插进入刚玉骨架 ,起着明显的强化和韧化作用     

Adaptive model predictive inventory controller for multiproduct warehouse system

An inventory control system has been developed for a distribution system consisting of a single multiproduct warehouse serving a set of customers and purchasing products from multiple vendors. Purchase orders requesting multiple products are delivered to the warehouse in a process referred to as joint replenishment. The receipt of customer orders by the warehouse proceeds in order intervals and in order quantities that are subject to random fluctuations. The objective of warehouse operation is to minimize the total cost while maintaining inventory levels within the warehouse capacity by adjusting the purchase order intervals and quantities. An adaptive model predictive control algorithm is developed using a periodic square wave model to represent the material flows. The adaptive concept incorporates a stabilized minimum variance control-type input calculation coupled with input/output stream parameter predictions. The boundedness of the control output under the suggested algorithm is mathematically proven under the assumption that disturbances in the orders are bounded. The effectiveness of the scheme was demonstrated using simulations.     

熔制玻璃用坩埚抗热震性的改进

在粘土 -蜡石质玻璃用坩埚的配方基础上 ,研究了蜡石的粒径和加入量的变化对试样抗热震性的影响。结果发现 :减小蜡石的粒径与加入量均可提高试样的抗热震性 ,但减小蜡石粒径对提高试样的抗热震性更有效 ;在配料中引入少量的蓝晶石细粉 ,可明显提高试样的抗热震性。     

加热炉用喷补料的研制及应用

介绍了ＨＹＪ—０１喷补料的实验室研制及工业应用。实践表明，该喷补料粘接强度好，抗热震性好。喷补衬使用时间已超过１４个月，无明显破损现象。     

二维坡面雨洪水动力模型研究

由降雨产生的坡面洪水运动过程复杂,其可靠模拟仍有待深入。该文建立了基于浅水方程的二维坡面雨洪动力过程模拟的动力波模型,选用单坡、三阶坡面和复杂起伏多变坡面的雨洪运动为数值算例,进行了数值检验并与忽略惯性项的扩散波模型进行了对比分析。结果表明:动力波模型可以较好地模拟洪水过程,在峰现时间,洪峰水位的捕捉和退水过程等方面都表现出优良的特性;而且动力波模型在复杂坡面雨洪过程计算的适应性方面表现更佳。而扩散波模型在计算精度和稳定性方面都相对要差。虽然扩散波模型在单坡面算例中的计算精度也较高,但因受忽略惯性项的影响,退水过程有明显偏离。     

层析法分离提取葡萄籽原花青素的进一步研究

以吸附量和解吸率为指标,比较了7种大孔吸附树脂对原花青素的静态吸附解吸性能并考查了AB—8树脂对原花青素的吸附特性及机理。实验结果表明:AB—8树脂是较理想的吸附剂;在溶液中AB—8树脂对原花青素的吸附达到平衡的时间为240 min,吸附行为符合Langmuir等温方程;最佳动态吸附参数原花青素提取液浓度4.0 mg/mL,吸附流速2 BV/h(1BV=13.03 mL)用40%乙醇溶液洗脱。AB—8树脂适合于柱层析操作分离原花青素。     

The role of pressure on thin amorphous carbon films deposited using microwave surface wave plasma CVD

We report the effects of gas composition pressure (GCP) on the optical, structural and electrical properties of thin amorphous carbon (a-C) films grown on p-type silicon and quartz substrates by microwave surface wave plasma chemical vapor deposition (MW SWP CVD). The films, deposited at various GCPs ranging from 50 to 110 Pa, were studied by UV/VIS/NIR spectroscopy, atomic force microscopy, Raman spectroscopy, X-ray photoelectron spectroscopy and current–voltage characteristics. The optical band gap of the a-C film was tailored to a relatively high range, 2.3–2.6 eV by manipulating GCPs from 50 to 110 Pa. Also, spin density strongly depended on the band gap of the a-C films. Raman spectra showed qualitative structured changes due to sp³/sp² carbon bonding network. The surfaces of the films are found to be very smooth and uniform (RMS roughness < 0.5 nm). The photovoltaic measurements under light illumination (AM 1.5, 100 mW/cm²) show that short-circuit current density, open-circuit voltage, fill factor and photo-conversion efficiency of the film deposited at 50 Pa were 6.4 μA/cm², 126 mV, 0.164 and 1.4 × 10^− 4% respectively.     

单扫描极谱法快速测定胱氨酸的研究及应用

在pH 9.6的H3BO3-NaOH介质中,胱氨酸于-0.56 V(vs.SCE)处产生一灵敏的吸附还原波。用于胱氨酸的测定,波高与0.8~10μmol/L的胱氨酸有线性关系,检测限为0.4μmol/L。许多氨基酸在较高浓度共存情况下不干扰胱氨酸的测定。应用该法测定了人发及胱氨酸片剂中胱氨酸的含量。