Augmentation of boiling heat transfer from horizontal cylinder to liquid by movable particles

This paper presents a series of experimental results on a passive augmentation technique of boiling heat transfer by supplying solid particles in liquid. A cylindrical heater 0.88 mm in diameter is placed in saturated water, in which a lot of mobile particles exist, and the nucleate and film boiling heat transfer characteristics are measured. Particle materials used were alumina, glass, and porous alumina, and the diameter ranged from 0.3 mm to 2.5 mm. Particles are fluidized by the occurrence of boiling without any additive power, and the heat transfer is augmented. The maximum augmentation ratio obtained in this experiment reaches about ten times the heat transfer coefficient obtained in liquid alone. The augmentation ratio is mainly affected by the particle material, diameter, and the height of the particle bed set at no boiling condition. The augmentation mechanism is discussed on the basis of the experimental results. © 2001 Scripta Technica, Heat Trans Asian Res, 31(1): 28–41, 2002     

Supercritical fluid extraction of fungal oil using CO2, N2O,CHF3 and SF6

The extraction of oil from fungi (Mortierella ramanniana var.angulispora) was studied using carbon dioxide (CO₂), nitrous oxide (N₂O), trifluoromethane (CHF₃) and sulfur hexafluoride (SF₆) under supercritical conditions. The oil solubility was highest in SC-N₂O followed by SC-CO₂, while both SC-CHF₃ and SC-SF₆ showed poorer solvent power. The recorded oil solubilities at 333 K and 24.5 MPa were 2.3 wt% in N₂O, 0.48 wt% in CO₂, 0.0099 wt% in CHF₃ and 0.0012 wt% in SF₆. The oil solubilities in SC-N₂O and SC-CO₂ were measured over the pressure range 15.7–29.4 MPa and at temperatures ranging from 313–353 K. N₂O always showed greater solvent power than did CO₂ at the same temperature and pressure. The solvent power of a supercritical fluid increases with density at a given temperature, and increases with temperature at constant density. The change in neutral lipid composition of the extracted oil with the extraction ratio was measured. Free fatty acids or diglycerides were extracted more easily than triglycerides or sterol esters. The change in fatty acid composition was also measured. The proportion of γ-linolenic acid in the extract remained constant throughout the extraction.     

Simultaneous detection of burned areas of multiple fires in the tropics using multisensor remote-sensing data

Fires associated with recurrent El Niño events have caused severe damage to tropical peat swamp forests. Accurate quantitative information about the frequency and distribution of the burned areas is imperative to fire management but is lacking in the tropics. This article examines a novel method based on principal component analysis (PCA) of the normalized difference water index (NDWI) from multisensor data for simultaneously detecting areas burned due to multiple El Niño–related fires. The principal components of multitemporal NDWI (NDWI-PCs) were able to capture the areas burned in the 1998 and 2003 El Niño fires in NDWI-PC3 and 2, respectively. The proposed method facilitates the reduction of dimensionality in detecting the burned areas. From 22 image bands, the proposed method was able to accurately detect the burned areas of multiple fires with only three NDWI-PCs. The proposed method also shows superior performance to unsupervised classifications of the principal components of combined image bands, multitemporal NDWI, NDWI differencing and post-classification comparison methods. The results show that the 1998 El Niño fire was devastating especially to intact peat swamp forest. For degraded peat swamp forest, there was an increase in the burned area from 1998 to 2003. The proposed method offers the retrieval of accurate and reliable quantitative information on the frequency and spatial distribution of burned areas of multiple fires in the tropics. This method is also applicable to the detection of changes in general as well as the detection of vegetation changes.     

New bleeding model of additives in a polypropylene film under atmospheric pressure II

Many additives are commercially used to add more favorable qualities to films. The bleeding process by which the additive in a film comes to the surface is considered. A new bleeding model of additives in a polypropylene film under atmospheric pressure was investigated. Solubility and diffusion are found to be important for explaining this bleeding process. It was found that the experimental results were explained more precisely by assuming a two‐step transport process between the crystalline regions and the amorphous ones. The solubilities and diffusion coefficients of UV‐stabilizers such as 2‐(2H‐benzotriazol‐2‐yl)‐4‐(1,1,3,3‐tetramethylbutyl)phenol and 2‐(2H‐benzotriazol‐2‐yl)‐4‐methylphenol were determined at 40°C. The difference between the saturation solubilities and the diffusion coefficients of UV‐stabilizers was discussed by comparing with the results of molecular dynamics (MD) simulation. © 2007 Wiley Periodicals, Inc. J Appl Polym Sci 2007     

Mice lacking the IFN-gamma receptor have impaired ability to resolve a lung eosinophilic inflammatory response associated with a prolonged capacity of T cells to exhibit a Th2 cytokine profile

To investigate the modulatory role of IFN-gamma on the induction and maintenance of Th2 mucosal immunity in vivo, experiments were performed in mice lacking the IFN-gamma R. Aerosol OVA challenge of immunized wild-type mice resulted in an infiltration of eosinophils into the lung, associated with the ex vivo production of Th2 cytokines (IL-4 and IL-5) from purified lung Thy1.2+ cells stimulated via the CD3/TCR complex. However, while immunized IFN-gamma R-deficient mice exhibited elevated levels of IgE, IgG1, and reduced levels of IgG2a compared with wild-type mice, there was no difference in the recruitment of eosinophils into the lung or the production of IL-4 and IL-5 from lung T cells on day 3. In contrast, up to 2 mo after a single Ag challenge, eosinophils were still present in the lungs of IFN-gamma R-deficient, but not wild-type, mice. Likewise, lung-derived T cells from IFN-gamma R-deficient mice produced higher levels of IL-4 and IL-5, both at 1 and 2 mo after OVA challenge compared with T cells from wild-type mice. We conclude that endogenous IFN-gamma regulates the humoral isotype Ab pattern, but does not modulate the commitment of T cells to a Th2 phenotype in vivo or the acute infiltration of eosinophils to the lung. However, in the absence of IFN-gamma-mediated signaling, there is a transition from a spontaneously resolving to a persisting eosinophilic inflammation of the lungs, associated with a sustained capacity of lung T cells to secrete a Th2 cytokine profile.     

Sludge depositions in a long tube-high flow MSF test plant

During the operation of a multistage flash (MSF) evaporation plant, a rather rapid decrease was observed in the economy ratio of the plant when the dissolved oxygen (DO) content of the circulating brine was at a high level. This phenomenon was brought about by the reduction of heat transfer coefficients of condenser tubes due to sludge formation on the inside tube surface by the co-precipitation of ferric hydrous oxide with silica, alumina, and organic materials. The chemical analysis of the sludge and circulating brine showed a close relationship to DO values in the brine, the concentration of iron in the sludge, and the decreasing value of the heat transfer coefficient. The lowering of DO was found very effective for avoiding the sludge trouble.