Formation of toxic aldehydes in cod liver oil after ultraviolet irradiation

Formaldehyde, acrolein, malonaldehyde (MA), acetaldehyde and propanal produced from cod liver oil upon ultraviolet irradiation (λ_max=300 nm) were derivatized into nitrogenor sulfur-containing compounds and then analyzed by capillary gas chromatography with a nitrogen-phosphorus detector or a flame photometric detector. Acrolein and MA were formed at levels of 10.9±3.06 and 190.2±38.4 nmol/mg of fish oil, respectively. Maximum levels of formaldehyde, acetaldehyde and propanal formed were 7.0±0.90, 49.1±4.5 and 35.8±4.0 nmol/mg of oil, respectively. Formation of propanal in large quantities corresponded to the high content of ɛ-3 fatty acids in cod liver oil.     

Solids Extraction of Cod Frame and Effects on Ultrafiltration of the Aqueous Extract

Grinding, pH adjustment, heat treatment and centrifugation were studied to recover solids from ground cod frames and to apply ultrafiltration (UF) to the resulting aqueous phase. Early heat treatment (90°C/20 min) dissolved collagen into aqueous phase resulting in a very low UF flux. A pH adjustment to 4.5 after grinding (～0.32 cm die), with no heat resulted in efficient separation after centrifuging. UF of the aqueous phase showed an increase in initial flux (23 L/hr m²). However, when the same aqueous material was heated and then centrifuged (1–2% solids removed), UF flux was further increased to 46 L/hr m²and this process gave highest solids recovery (90%).     

A novel technique for the preparation of secondary fatty amides

A technique for the synthesis of monosubstituted fatty amides at low temperature and ambient pressure was developed. This method involved the condensation of an amine with a triacylglycerol. The primary amine (ethyl,n-butyl,n-hexyl andn-octyl were tested) acted as reagent and solvent for the fatty substrates. No additional organic solvent or catalyst was added. Tallow, vegetable oils and fish oil all served well as substrates, as did pure tripalmitin. The rate of amidation was dependent upon temperature and the ratio of fat to amine. In a series of experiments conducted with tallow andn-butylamine at a fat:amine molar ratio of 1:16, amidation could be carried out at 20°C, producingn-butyltallowamide in 83% yield in 24 hr. When the fat:amine molar ratio was reduced to 1:8, and the temperature raised to 45°C, the amide yield was 87.6% in 24 hr. When the reaction was carried out at the boiling point ofn-butylamine (78°C) and at a fat:amine ratio of 1:8, the amide yield was 93.2% in 4 hr. The reaction progressed more rapidly with higher molecular weight amines. The identity and purity of the amides was assessed by thin-layer chromatography and confirmed by elemental analyses and infrared and C¹³ nuclear magnetic resonance spectroscopy.     

Nuclear DNA barcodes for cod identification in mildly-treated and processed food products

Gadoids are a group of fish with historical importance in the fishing industry. The high demand for cod is one of the reasons why cod products are often mislabelled, and numerous observations have been made on the replacement of Atlantic cod (Gadus morhua) by cheaper species or its illegal capture in contravention of fish quotas. Fish species identification is traditionally based on morphological features, but this may be difficult in case of heat-treated or processed products, or where the species look similar, as in the Gadoid group. DNA-based approaches (using either nuclear or mitochondrial DNA) are most commonly used in this case, due to their high specificity and to the high resilience of the target molecules to food processing techniques. In this article, we identified, using an automated screening approach, novel barcode regions and their associated primers in the nuclear genome, to be used for the efficient identification of Gadoids. The barcode regions were tested on official and commercial samples, raw or mildly treated products, like frozen, or salted, as well as pre-cooked complex mixtures and processed samples, using next-generation sequencing (NGS) technique. The method proposed could complement existing fish identification strategies in establishing an efficient framework to detect and prevent frauds along the food chain.     

Effects of Added Phosphates on Lipid Stability During Salt Curing and Rehydration of Cod (Gadus morhua)

Effects of added phosphates on retardation of lipid oxidation of salted cod during processing, storage and after rehydration were investigated. Lipid hydrolysis progress and development of color, primary and secondary lipid oxidation products and fluorescence intensities were determined. Added phosphates significantly retarded lipid hydrolysis and lipid oxidation progress, resulting in lower free fatty acid , lipid hydroperoxides (PV), thiobarbituric acid-reactive substances (TBARS) as well as fluorescence intensities (δF _or and δF _aq). Significant correlation between the lipid oxidation products (PV, TBARS, δF _or and δF _aq) and yellow/brownish discoloration (b* value) of salted cod was observed. Principal component analysis showed that TBARS, b* value and δF _or were the strongest indicators of lipid oxidation during salting and storage.     

Use of Ultrasound to Determine Cod Fillet Composition

The relationships between the composition and ultrasonic properties of Atlantic cod (Gadus morhua) fillets were examined. The lipid, protein, moisture and ash contents of cod fillets were determined by official methods. The ultrasonic velocity and attenuation coefficient of the fillets were measured using a pulse-echo technique. The ultrasonic velocity of the fillets varied between 1575 and 1595 m s^?1, decreasing linearly with increasing moisture content (r² > 0.8 for 26 samples). No systematic relationship was observed between the attenuation coefficient and moisture content. Our experiments highlight the potential of using ultrasonic velocity measurements to rapidly and nondestructively determine the moisture content of cod fillets (and possibly their protein content by deduction).     

Alternate oils in fish feeds

Nearly half of the fish consumed as food worldwide are raised on fish farms rather than caught in the wild, as shown by FAO statistics. The increasing aquaculture of predatory carnivorous fish demands new sources of feed constituents, particularly oils at the moment. Common terrestrial plant oils contain only traces of the long‐chain polyunsaturated fatty acids. In connection with fish feed, especially the lack of n‐3 “marine fatty acids” is obvious. Recommendations on the required amounts of the fatty acids DHA (22:6n‐3) and EPA (20:5n‐3) exist from 1994. When plant oil‐based diets are fed during the growing phase and replaced by a fish oil‐based diet during a period prior to slaughter, most of the beneficial lipid composition of fish in terms of human dietary recommendations is restored. Little attention has been focused on the fish welfare in connection to substitution of dietary oil sources, and studies are still scarce. New fish diets will rely heavily on the use of alternate ingredients such as plant oils also for carnivorous cold‐temperate water fish species. In the future, an addition of synthetic or GMO‐produced “marine” fatty acids is a possible scenario. The aim of this review is to highlight some plant oils used in fish feeds, with special emphasis on compounds other than fatty acids. We also include some results from an ongoing study, where the effect of dietary soy oil on gonad maturation in Atlantic cod (Gadus morhua) is indicated.     

Chemical, Microbiological, and Sensory Quality of Cod Products Salted in Different Brines

ABSTRACT: Studies were carried out on the effect of different brines containing high concentrations of calcium chloride (CaCl₂, 0.8%w/w), magnesium chloride (MgCl₂, 0.4%w/w), and potassium chloride (KCl, 50%) on the chemical (chloride and moisture contents), microbial (total viable counts, total coliforms, enterococci, and staphylococci), and sensory quality of salted cod. The brines were prepared from combinations of the Ca, Mg, and K ions and sodium chloride (NaCl) at pH 6.5 and 8.5. Additionally, 3 salts (one composed solely of NaCl, another commercial sea salt from the southern Europe and, finally, a natural salt from northern Europe) were also tested. Principal component analysis structured the chemical and microbiology data in 3 clusters: (1) an extreme cluster, formed by cod brined in the commercial sea salt, which achieved the highest microbiological counts, namely 4.1 log CFU/g on plate count agar (PCA) and 1250 coliforms/g; (2) an intermediate cluster composed of cod salted in brine containing 50% NaCl, 0.4% MgCl₂, and 49.6% KCl (pH 6.5); and (3) a central cluster, including all the other treatments, which presented the lowest microbiological counts, namely 2.4 log CFU/g on PCA and 20 coliforms/g. Although the batches of the intermediate cluster presented slightly higher total viable and staphylococci counts than the central cluster, the presence of Mg and K ions improved the color of the salted product. In the assayed concentrations, CaCl₂, MgCl₂, and KCl can be used in the brining of cod without adversely affecting the microbiological and sensory quality of the salted cod.     

Quality changes during refrigerated storage of MA-packaged pre-rigor fillets of farmed Atlantic cod (Gadus morhua L.) using traditional MAP, CO2 emitter, and vacuum

ABSTRACT:  Quality changes during 3 wk of refrigerated storage (1.3 °C) were studied on pre -rigor filleted farmed Atlantic cod packed in modified atmosphere (MAP, 60% CO₂ and 40% O₂) or vacuum. The packages of MAP contained either a CO₂ emitter and low gas volume to product volume (g/p ratio) of 1.3, or a 3.9 g/p ratio and no emitter. The CO₂ level remained stable or increased in the packages with CO₂ emitter, whereas the CO₂ level in the packages with no CO₂ emitter decreased to 40% after 4 d of refrigerated storage. High levels of oxygen in the gas mixture prevented formation of trimethyl amine (TMA) during storage of the MA-packed fish, whereas the TMA content increased significantly after 10-d storage in vacuum. MA-packed samples had the highest values of 1-penten-3-ol. Sensory scores of sour, sulfur, and pungent odors were significantly higher for vacuum-packed cod compared to the 2 MA-packaging methods measured 14 d after slaughtering. No differences in sensory scores were observed between the 2 methods of MAP, and shelf life of these samples seemed to be 14 to 21 d. Cod samples packaged in vacuum packages had higher pH values compared to ordinary MAP and packages containing a CO₂ emitter. Bacterial growth was inhibited by MAP and resulted at the end of the storage period in dominance of Carnobacterium and some Photobacterium . In MA packages with high O₂ levels the Photobacterium was inhibited. It is concluded that CO₂ emitters are well suited for reduction of transport volume for MA-packaged farmed cod.