纵览衣物清洗剂技术

随着生活水平的提高，人们对自身生活质量的要求越来越高，从而促进了衣物清洗剂技术的发展。本文从这个角度阐述了衣物清洗剂从肥皂、洗衣粉到多功能环保型产品的发展过程。     

酶法提取树莓汁的研究

本试验以澳洲红、早红、美国22三个品种树莓为原料，通过不同的酶处理方法来制原果汁，优选适于制汁的品种和酶处理方法。     

General rate equations and their applications for cyclic reaction networks: multi-cycle systems

The network reduction technique and the Bodenstein approximation of quasi-stationary behavior of reaction intermediates were systematically applied to derive general yield ratio and rate equations for multi-cycle reaction networks in homogeneous catalysis. Dual-cycle reaction networks connected by a linear pathway, multi-cycle networks stemming from the same intermediate, and single-cycle with arbitrary number of pathways between two intermediates were considered. The general yield ratio and rate equations derived in this study are applicable for most enzymatic reactions and for homogeneous catalytic reactions. Examples of homogeneous catalysis were used to illustrate the application of the general yield ratio and rate equations for network elucidation.     

γ-癸内酯的酶法拆分研究

研究了脂肪酶对γ-癸内酯(GDL)对映催化选择性水解反应,考察了各种因素对酶促水解拆分过程的影响。试验结果表明,水解产物-大量的酸会抑制脂肪酶的活性,采用高浓度的磷酸盐缓冲液可有效地稳定系统的酸碱度,使酶促反应顺利进行。在磷酸缓冲溶液体系中缓冲液pH=7.8,底物浓度为0.6mol/L,反应时间2.5小时,反应温度43℃为γ-癸内酯酶促水解拆分的最佳工艺条件。     

淀粉基干燥剂的化学性质与性能

讨论了淀粉、粗玉米粉及可以被淀粉所依附的纤维素框架的化学结构及性质,它们可能成为一系列用途广泛的干燥剂。     

Enzymatic Firming of Processed Red Pepper by Means of Exogenous Pectinesterase

The objective of this investigation was to demonstrate that the firmness of a commercial vegetable product, diced and frozen red pepper (Capsicum annum var. Sendt), could be improved by the use of exogenous pectinesterase in an industrially relevant process. The diced pepper pieces 10 × 10 × 7 mm³ were infused under vacuum with a commercially available pectinesterase. The range of optimal process conditions was: 15-20°C, 45 min infusion time, a 10-25 mM CaCl₂ infusion brine, a w/w ratio of pepper fruit to infusion brine of 1.5:1, and an enzyme dosage of 30-60 pectinesterase units (PEU) per kg pepper fruit. The firmness as measured by back extrusion was improved by a factor of two to three. The effect of firming was robust and conserved after freezing and heating in a simulated household cooking process. The firming process seems easily adaptable to industrial conditions and may be applicable to other vegetable and fruit products.     

Continuous production of structured phospholipids in a packed bed reactor with lipase from <Emphasis Type="Italic">Thermomyces lanuginosa</Emphasis>

The possibilities of producing structured phospholipids between soybean phospholipids and caprylic acid by lipase-catalyzed acidolysis were examined in continuous packedbed enzyme reactors. Acidolysis reactions were performed in both a solvent system and a solvent-free system with the commercially immobilized lipase from Thermomyces lanuginosa (Lipozyme TL IM) as catalyst. In the packed bed reactors, different parameters for the lipase-catalyzed acidolysis were elucidated, such as solvent ratio (solvent system), temperature, substrate ratio, residence time, water content, and operation stability. The water content was observed to be very crucial for the acidolysis reaction in packed bed reactors. If no water was added to the substrate during reactions under the solvent-free system, very low incorporation corporation of caprylic acid was observed. In both solvent and solvent-free systems, acyl incorporation was favored by a high substrate ratio between acyl donor and phospholipids, a longer residence time, and a higher reaction temperature. Under certain conditions, the incorporation of around 30% caprylic acid can be obtained in continuous operation with hexane as the solvent. Presented at the 95th American Oil Chemists' Society Annual Meeting and Expo in Cincinnati, Ohio, May 10, 2004.     

壳聚糖固定化酶和细胞研究新进展

分析评价了壳聚糖作为固定化酶和细胞载体的特性,概述了壳聚糖凝胶固定化酶和细胞的形态及制备方法,着重介绍了近年来壳聚糖固定化酶和细胞的改进方法,并指出今后壳聚糖固定化酶和细胞的发展方向。     

Analysis of microbial adaptation at enzyme level for enhancing biodegradation rate of BTX

Catechol was found to be a common intermediate in the degradation of benzene and toluene byAlcaligenes xyhsoxidans Y234, and the ring cleavage of the catechol mediated by catechol 1,2-dioxygenase was a rate-determining step. Since benzene induced higher level of catechol 1,2-dioxygenase than toluene, the cells pre-adapted to benzene showed higher degradation rate of benzene and toluene. The degradation rate ofm-xylene was also increased significantly when benzene-adapted cells were inoculated.m-Xylene was metabolized via 3-methyl catechol which was effectively cleaved by catechol 1,2-dioxygenase.     

Electroreduction of laccase covalently bound to organothiol monolayers on gold electrodes

Cerrena unicolor laccase was immobilized on the gold electrode by covalent bonding to self-assembled monolayers of mercaptoundecanoic or mercaptopropionic acids. STM images of immobilized laccase proved high population of the laccase molecules on the monolayer modified electrode. The SERS experiments in concert with resonance Raman effect confirmed that the structure at the “blue” copper site of the immobilized protein remained intact. The accessibility of individual copper sites for electron exchange with the gold electrode surface was investigated by voltammetry. The electrode behavior of laccase is different in the presence and absence of oxygen, showing that the immobilized enzyme is reactive towards oxygen. Addition of two common mediators improved the electrical connectivity of the enzyme with the electrode, increased the catalytic efficiency of immobilized laccase and switched the onset of catalytic current to the potentials of the mediator. Immobilization of laccase on well-organized mercaptoundecanoic acid separates efficiently the enzyme from the electrode and does not allow easy access of mediators to the surface. Attachment of the enzyme at smaller distance from the electrode by means of significantly shorter spacer molecule—mercaptopropionic acid improved the efficiency of catalytic reduction of oxygen on the monolayer modified electrode.