在糖化酶发酵生产中低温保存黑曲霉菌

在糖化酶生产过程中,为了防止正常生产中黑曲霉菌种性能的变化,对菌种的一级种母进行甘油冷冻保存,在-120℃的条件下分别保存30、60、90d,然后直接接入种母培养基,待成熟后接入种子罐,投入50t发酵罐工业生产,150h左右发酵结束。产酶单位与原工艺条件相一致。     

Investigation of the use of ram horn hydrolysate for fungal protein production

Production of the fungus Aspergillus niger NRRL 330 was studied in submerged fermentation with ram horn hydrolysate (RHH) as substrate. The characteristics of RHH have been reported previously. The RHH was enriched by addition of glucose and KH₂PO₄. The effects of kinetic parameters on the biomass yield of the fungus were investigated. The optimal conditions for growth of A niger on RHH were initial pH 6.5, temperature 30 °C, fermentation time 96 h and agitation speed 150 rpm. Under these optimal conditions the initial carbohydrate content of RHH was reduced from 1.52 to 0.2% and the biomass yield was 8.9 g l^?1. The biomass contained about 48.1% protein, 5.2% fat and 9.4% ash (on a dry weight basis). The amino acid content of the biomass was compared with Food and Agricultural Organisation (FAO) and animal feed standards. The protein produced contained all the essential amino acids for animal feed, but the amounts of these amino acids were somewhat lower than those of FAO and soybean reference protein. However, the amino acid composition of the biomass was better than that of animal feed. The results with RHH were also compared with previously reported data on fungal mycelium grown on waste liquor substrate. In conclusion, it was found that RHH could be used as a substrate in the production of fungal protein for use as animal feed. Copyright © 2003 Society of Chemical Industry     

The influence of the ion content of whey on the pH-activity profile of the β-galactosidase from Aspergillus oryzae

The pH-dependence of the reaction kinetics of lactase (β-galactosidase) from Aspergillus oryzae in different reaction media is presented in terms of a two-parameter model. The lactase from A. oryzae seems to have replaced the A. niger lactase on the market owing to a better activity/price ratio and may be utilised for lactose hydrolysis in acid as well as in neutral milk products. Its pH optimum is around pH 4.5. However, in the neutral pH-range its activity depended strongly on the salt content of the substrate solution. For example, its activity in whey (pH 6.5) fell to only 30% of its expected activity in a pure lactose solution at the same pH. The whey effect was the same for both soluble and immobilised lactase. The two parameter kinetic model, which included a term for competitive product inhibition gave excellent agreement with experimental data, and may thus be useful for the prediction of reactor performance with this enzyme.     

转盘反应器固定米根霉的L－乳酸发酵

研究了米根霉的固定化方法，研制了用吸附法固定米根霉的生物转盘反应器，考察了在该反应器中培养基组成及其它操作条件对Ｌ－乳酸发酵的影响。实验结果表明，应用吸附法固定化的米根霉及生物转盘反应器进行Ｌ－乳酸发酵具有发酵速率快，Ｌ－乳酸得率高及既能用于连续发酵又能用于间歇发酵等优点     

米曲霉在牛乳中最适生长条件的研究

利用米曲霉对牛乳进行发酵,通过单因子及正交试验以菌丝体干重为指标对其在牛乳中的生长进行了研究．结果表明：接种量为4％,装液量为30mL,摇床转速为180r／min时菌丝体干重可达到最大．此外测得最大菌丝体干重时的蛋白质分解率可达35．6％．     

泸型大曲中根霉固态发酵产糖化酶条件研究

对泸型大曲中根霉菌株固态发酵产糖化酶的条件进行了研究。以糖化酶活力为评价指标,设计单因素实验,研究培养基水分含量、培养时间、培养温度对根霉产糖化酶的影响,在此基础上,利用Box—BenhnkenDesign的方法,对根霉菌株固态发酵产糖化酶的条件进行优化,结果显示泸型大曲中根霉菌株固态发酵产糖化酶的优化条件为培养温度29℃,培养基水分含量53％,培养时间164h,糖化酶的酶活力为2194．44U／g。     

酱油曲菌的选择及酱油发酵条件

研究了日本酱油生产菌AspergillusoryzaeJP DQ 1,AspergillusoryzaeJP W和我国酱油生产菌AspergillusoryzaeAS3.951的酶系。结果表明:3种菌在浓酱油曲和白酱油曲培养基上均可产生α 淀粉酶、糖化酶、纤维素外切酶、果胶酶、酸性蛋白酶和中性蛋白酶;JP W是较好的白酱油生产菌,JP DQ 1是较好的浓酱油生产菌。还对酱油酵母的生理特性进行了部分研究,发现食盐浓度对酱油酵母生长影响较大,酱油发酵过程的盐浓度不宜超过3mol／L,低于2mol／L更佳。酱油酵母的较适生长pH为4.5～5.5。     

Construction of the mutant strain in Aspergillus oryzae 3.042 for abundant proteinase production by the N+ ion implantation mutagenesis

Because of secreting large amounts of enzymes, Aspergillus oryzae was widely used in the fermentation of soy sauce in many Asian countries. Here, N⁺ ion implantation mutagenesis was applied to improve the ability of A. oryzae to secrete acid protease. Several mutants were screened using three kinds of plates (Casein medium, Czapek’s medium and carboxymethyl cellulose medium agar plates). Compared with the other mutants, the mutant A100‐8 could secrete the most protease. Acid protease activity of A100‐8 was enhanced about 44.1% at 36 h by koji fermentation test. In addition, A100‐8 was stable by periodically subculturing and maintaining on the agar slant. The mRNA expression levels of two kinds of acid protease (serine carboxypeptidase and aspartyl protease) were measured by RT‐PCR at different periods. Serine carboxypeptidase and some kinds of aspartyl protease of A100‐8 were significantly (P < 0.01) expressed higher than the control at all times.     

黑曲霉孢子灭活前后红外消光特性

黑曲霉孢子是生物气溶胶的重要组成部分,质量消光系数是研究黑曲霉孢子电磁衰减特性的重要参数。采用压片法测量了灭活前后黑曲霉孢子2.5~15 um 波段的反射光谱,并利用Krames-Kronig(K-K)关系计算了黑曲霉孢子红外波段的复折射率。基于Mie 散射理论求出了灭活前后黑曲霉孢子红外波段的质量消光系数,并对结果进行了分析和讨论。分析结果表明:3~5 um 波段,灭活后平均质量消光系数降低了4.6%,8~14 um 波段,灭活后平均质量消光系数降低了89.5%,由此可知,保持活性对于提高黑曲霉孢子的电磁衰减能力具有重要的意义。     

氮离子注入选育高效发酵木糖生产L(+)-乳酸的米根霉

为了获得能够高效发酵木糖生产L( )-乳酸的菌株,采用氮离子注入诱变方法,对出发菌株米根霉RLC41-6进行改良,获得高产L( )-乳酸菌株RQ4012,发酵周期为72h,产酸能力达74.37g/L,产酸速率达1.03g/(L.h),比RLC41-6提高了1.6倍.经过多次传代实验证明该菌株具有较好的遗传稳定性.