砂岩酸化中水化硅沉淀的影响因素分析

讨论了砂岩酸化中产生水化硅沉淀的反应机理。使高岭土与1.0%HF和多种配比的HCl HF在不同温度(20-90℃)反应不同时间(10-300分钟),用等离子吸收光谱法(ICP)测定酸液中可溶性硅的浓度(mg/L),取某时段测定值的减小量为该时段水化硅沉淀生成量,讨论了多种因素的影响,得到了如下结果和结论。反应温度越高,则高岭土与HF之间的反应越快,形成水化硅沉淀的时间越短,最终生成的沉淀量越大;在HF中加入HCl(使用土酸体系)、减小土酸中HF质量分数、加大土酸中HCl、HF质量分数比,均可使生成沉淀时间延后,使最终生成沉淀量减少。60℃时300分钟沉淀量,在1.0%HF、5.0%HCl 1.0%HF、9.0%HCl 1.0%HF中分别为482、321、201mg/L。提出了在酸化设计与施工中可以采取的6条简便易行的减少水化硅沉淀量的措施。图4表1参6。     

难处理金矿石加石灰焙烧焙砂中CaS的消除

介绍了用空气氧化预浸加石灰焙烧焙砂中的CaS，以消除其对金氰化的影响。预浸后金的氰化浸出率可从58％提高到80％以上。     

一种制备插层和无定形高岭土的新方法

利用甲醇钠强烈的夺氢作用 ,介绍了一种制备插层和无定形高岭土的方法。利用XRD为主要检测手段研究了甲醇钠的质量分数、反应温度等因素对反应的影响。结果表明 :在反应温度较低、质量分数较低的甲醇钠溶液中 ,高岭土容易被插层而膨胀 ,反之高岭土的层状结构被破坏而无定形化。红外光谱分析进一步证明了插层和无定形高岭土结构的变化     

Dispersion—flocculation studies on a Goethite-clay system

Dispersion–flocculation studies on a Goethite–clay system using flocculants were carried out as a function of flocculant concentrations, pH of slurry, time of agitation and dispersant dosage. Also, the effects of pH and polymer concentrations on the adsorption behaviour of the system were investigated. Results show that well flocculated goethite was preferentially obtained from 4% goethite/kaolinite clay suspensions, with 50 ppm causticised starch in the slurry at pH values of 3–11·5 and with 50 ppm polyacrylamide at pH values of 3–8. Good flocs were also obtained on flocculation of the goethite suspension with 50 ppm polyacrylamide at pH values of 5–7, while the kaolinite suspension did not respond to the same dosage of causticised starch in the same pH range. Results further reveal that for the goethite/kaolinite suspension, the best results was obtained with 50 ppm polyacrylamide at pH values of 7–10. Based on the data generated in the study, it was concluded that causticised starch is a better flocculant than polyacrylamide for goethite suspensions although polyacrylamide is an excellent flocculant for kaolinite suspensions.     

残留CO2对石灰在转炉初渣中溶解的影响

 在转炉炼钢过程中,石灰快速溶解对转炉高效脱磷具有十分重要的意义,石灰溶解过程中熔渣/石灰界面处形成的2CaO·SiO₂产物层被认为是阻碍石灰溶解的关键因素。制备了具有两种不同CO₂含量的部分煅烧石灰石,采用浸泡法研究了部分煅烧石灰石在转炉初渣中的溶解行为,并与纯石灰、石灰石的溶解行为进行比较。结果表明,石灰石溶解时在液态熔渣中CaO的传质系数为石灰的2.1倍,残留CO₂质量分数为10%的部分煅烧石灰石的传质系数高达石灰石的6.7倍。在CO₂质量分数为0～43.5%时,石灰的溶解速率先增大后减小。石灰溶解过程中形成的2CaO·SiO₂层严重阻碍了FeO_x的扩散,从而减缓了石灰的溶解。与石灰不同,石灰石分解产生的CO₂能够破坏2CaO·SiO₂层并破坏自身结构,有利于熔渣的渗透,这也适用于残留CO₂的部分煅烧石灰石。制备纯石灰的过程中为了确保石灰芯部完全煅烧,因此极易导致石灰外表面发生过烧,而制备部分煅烧石灰石能在一定程度上解决表面过烧的问题。此外,与石灰石相比,部分煅烧石灰石由于表面是石灰外壳,溶解初期其表面附近的炉渣温降相对更低,能够避免溶解初期出现停滞阶段。在转炉富余热量有限的情况下,部分煅烧石灰石的石灰替换比高于石灰石,这取决于部分煅烧石灰石中的CO₂残留量。     

高岭土改性聚酯纤维

介绍了高岭土在改性聚酯中的作用、纤维级高岭土的性质以及改性聚酯的制造方法．指出了我国开发高岭土改性聚酯纤维的的前景．     

A novel depressor useful for flotation separation of diaspore and kaolinite

The floatation of the minerals diaspore and kaolinite was investigated using dodecylamine as the collector.Separating diaspore and kaolinite in a neutral pH pulp is difficult since they then have similar floatability.A depressor consisting of an AlCl3/Na2SiO3 mixture is demonstrated to solve this problem.Diaspore sinking may be seen when the ratio of AlCl3 to Na2SiO3 is 3.1.We refer to this mixture as ATNO.The influence of Al/Si ratio in the feedstock and the grain size of fed minerals on separation was examined.An Al/Si ratio in the concentrate greater than 11 may be obtained when the Al/Si ratio of the feed is between 2.53 and 4.96.However,the grain size of the diaspore greatly influences the concentrate grade.Finer grain size of the diaspore (＜40 μm)in pulp makes the flotation separation less than ideal,no matter what the kaolinite grain size.     

Preparation and mechanical properties of polypropylene fiber reinforced calcined kaolin-fly ash based geopolymer

To improve the environmental benefits and solve the problems of large shrinkage and high brittleness, the partial replacement of calcined kaolin by fly ash as a raw material for geopolymer synthesis and the influences of polypropylene (PP) fiber on the mechanical properties and volume stability were investigated. The results show that compressive strength of the geopolymer containing 33.3%(mass fraction) fly ash by steam curing at 80 °C for 6 d is improved by 35.5%. The 3-day compressive strength, flexural strength and impacting energy of geopolymers containing 0.05%PP fiber increase by 67.8%, 36.1% and 6.25%, while the shrinkage and modulus of compressibility decrease by 38.6% and 31.3%, respectively. The results of scanning electron microscopy (SEM) and the appearances of crack growths confirm that PP fiber can offer a bridging effect over the harmful pores and defects and change the expanding ways of cracks, resulting in a great improvement of strength and toughness. Foundation item: Project(2006AA06Z225) supported by the National High-Tech Research and Development Program of China     

高岭石声化学插层的XRD研究

以乙二醇、二甲基甲酰胺、二甲基亚砜及双氧水/冰醋酸等为插层剂,采用声化学法对高岭石进行了插层研究,考察了插层剂种类对高岭石插层率的影响.在此基础上,重点研究了以二甲基亚砜作为插层剂的情况下超声波功率、插层时间及插层剂的质量分数等工艺因素对插层率的影响,并采用XRD分析方法测试了高岭石的插层效率.结果表明：二甲基亚砜作为插层剂时插层率最高,插层率可达100%,二甲基甲酰胺和乙二醇次之,双氧水/冰醋酸插层率最低,插层率仅为14.9%.以二甲基亚砜为插层剂时,随着超声功率的增大,插层率先升高后降低;随着插层时间的延长,插层率呈增长趋势,而二甲基亚砜的质量分数对插层率的影响不大.在二甲基亚砜质量分数为75%、超声功率为300W、插层时间为2h的条件下,插层率达到100%,高岭石层间距从0.71nm被有效增大到1.10nm.     

Fabrication of phytic acid embellished kaolinite and its effect on the flame retardancy and thermal stability of ethylene vinyl acetate composites

A modified kaolinite by grafting with phytic acid (PA-g-Kaol) is fabricated, and it was introduced into ethylene vinyl acetate (EVA) with intumescent flame retardancy (IFR) together to improve the flame retardancy of EVA composites. The results show the limiting oxygen index value of EVA/ (18.0 wt% IFR)/ (2.0 wt% PA-g-Kaol) is 30.8%. Meanwhile, there is only one dripping produced in the vertical burning test. What's more, the flame-retardant mechanism is demonstrated by TG-IR, real-time-IR and GC–MS analysis. The results indicate that some pyrolytic products of IFR and PA-g-Kaol, like ammonia and phosphoric acid, catalyze the crosslinking of EVA and flame retardant, the resultant compact char protects the substrate from further burning.