忠武输气管道悬索跨越设计创新及探讨

忠武输气管道有4次悬索跨越,分别是蚂蝗溪悬索跨越、木龙河悬索跨越、马水河悬索跨越、野三河悬索跨越。文章介绍了这几座悬索跨越管桥设计中采用的多项新技术,如采用热聚乙烯半平行钢丝索代替以往的钢丝绳;采用钢管塔架代替以往的角钢塔架;根据地形地貌特点变换风索型式或取消塔架等。这些新技术、新设计在工程中均取得了良好的效果。另外,文章还针对悬索跨越桥面结构型式、预拱度设置、不对称荷载的影响、风索基础的设置等问题进行了探讨。     

Kinetic analysis for effect of initial substrate concentration on growth and secondary metabolite production in cultures of Nicotiana tabacum

Suspension cultures of tobacco cells were studied using airlift and rotary-drum bioreactors. The effect of initial concentrations of a major substrate, sucrose, on the growth and production of a secondary metabolite, phenolic compounds, was investigated. The dry weights and total concentrations of the phenolic compounds increased with the initial sucrose concentration in both bioreactors. Both bioreactors were found to have the same tendency for the effect of initial sucrose concentration. The structured model, presented previously was modified by considering that sucrose was hydrolyzed to glucose and fructose by an enzymatic reaction. The previous and the new models were applied to the above two sets of experimental data obtained with two bioreactors, independently. The hydrolysis of sucrose was elucidated to contribute slightly to the overall kinetics of growth and secondary metabolite production in these cultures. Furthermore, the levels of shear damage in each bioreactor were quantitatively compared based on the death rate constant, k_i, which is one of the model constants.     

消光剂TiO_2悬浮液配制工艺优化

讨论了在配制过程中减少凝聚粒子形成的有效措施。分散系统由分散器和弱搅拌组成 ,悬浮液初始浓度为 5 0 % ,分散时间应在 0 .5h以上。莫诺泵最佳转速在 85r min左右 ,球磨后TiO2 大粒子通过离心机分离出去 ,使产品中的大于 10 μm的凝聚粒子数小于 0 .4个 mg。     

轮式工程机械的行驶平稳性

根据振动理论建立了振动力学模型,并用等效刚度方法分析研究了弹性悬挂轮式工程机械行驶平稳性和振动特性。     

Design of nonlinear controllers for active vehicle suspension with state constraints

Design of active vehicle suspension has tradeoffs between three main performance metrics (passenger comfort, suspension deflection and road holding ability). It has been known that each performance can be achieved by H _∞ controller and they can be gathered by LPV (Linear Parameter Varying) method. However, because the suspension deflection limit was not explicitly considered, this limit may be exceeded. In this paper, the authors propose a “reference shaping“ based method in order to improve the control performance. In this approach, a “virtual reference” signal is imposed to the system such that the suspension deflection is kept small. The effectiveness of the approach is examined by numerical simulations. This work was presented in part at the 13th International Symposium on Artificial Life and Robotics, Oita, Japan, January 31–February 2, 2008     

车载多层减振平台的主动控制及仿真

为了研究被动悬架车载主动减振平台的低成本控制策略及其减振效果,针对一种新型长宽比较大的多层减振平台,建立了车辆被动悬架与主动减振平台的一体化全系统动力学分析模型。进而,设计了"线性被动、旋转主动"的平台控制策略,并应用MATLAB及ADAMS软件,在三种典型路面激励下,进行了仿真测试。结果表明:采用垂向线性振动的多层被动减振、旋转振动的低成本主动控制策略,被动悬架车载减振平台的减振效果明显,实现了车载减振平台的高性价比设计。     

30%三唑锡悬浮剂的研制及作用机理分析

[目的]解决30%三唑锡悬浮剂分散稳定性的问题。[方法]为提高30%三唑锡悬浮剂分散稳定性,采用流点法对不同类型的分散剂进行初步筛选并测试表面张力,通过测试SC粒径、Zeta电势、悬浮率、流变性能确定分散剂配比与用量并对分散稳定机理进行分析。[结果]与单一分散剂制备SC相比,聚羧酸盐分散剂SD-816和聚氧乙烯醚磷酸酯分散剂SD-208复配体系制备的SC性能较优,其表观黏度、Zeta电势、粒径和悬浮率分别为386 mPa·s、-37.2 mV、2.58μm及98.4%。并且提出了聚羧酸盐分散剂和聚氧乙烯醚磷酸酯分散剂对农药三唑锡可能的分散机理。[结论]聚羧酸盐SD-816和聚氧乙烯醚磷酸酯SD-208的复配体系可同时提供静电排斥作用和空间位阻,明显改善SC体系的悬浮稳定性。     

长铝公司含油废水处理工艺

根据含油废水的特性，结合中国长城铝业公司废水处理的现状及水质特点，论述了采用捞油→撇油→隔油→混凝气浮的工艺处理铝冶炼企业含油废水的可行性，并对此工艺进行了剖析。多年的运行经验证明，采用此工艺可去除水中的可浮油与乳化油，去除率可达98％左右。油浓度低于国家污水排放标准10mg／L。此工艺为铝工业废水治理开辟了一条崭新的道路。然而，此工艺在具体设计和运行管理上仍存在一些问题，有待于日臻完善。     

悬浮法合成聚丙烯腈高吸水性树脂

以偶氮二异丁腈为引发剂，用悬浮聚合法合成了交联聚丙烯腈，然后对其进行水解，得到了高吸水性聚丙烯腈。交联剂用量和水解条件对树脂吸水倍数的影响很大。树脂吸去离子水倍数为420倍，平均粒径为250μm。