| 适用于粗颗粒选别的浮选机叶轮动力学研究 |
| |
| 引用本文： | 史帅星,赖茂河,冯天然,周宏喜. 适用于粗颗粒选别的浮选机叶轮动力学研究[J]. 有色金属(选矿部分), 2011, 1(4). DOI: 10.3969/j.issn.1671-9492.2011.04.012 |
| |
| 作者姓名： | 史帅星 赖茂河 冯天然 周宏喜 |
| |
| 作者单位： | 北京矿冶研究总院,北京,100070 |
| |
| 基金项目： | 北京矿冶研究总院科研基金项目(yj-2007-08) |
| |
| 摘 要： | 粗颗粒矿物的浮选既要满足使矿物充分悬浮的强搅拌力要求,又要满足附着在矿化气泡上的矿物颗粒在强搅拌力作用下不致于脱落的要求。本文搭建了实验室动力学测试系统,研究了一种适用于粗颗粒矿物浮选的叶轮所需的流体动力学条件,在清水状态下测定了新型叶轮在浮选槽内各个流体动力学区域的流速,并与普通KYF叶轮进行对比分析,文中最后对新型叶轮在浮选槽内的浮选动力学进行了测试。通过研究表明新型叶轮在和普通KYF叶轮同一转速条件下能有效提高粗颗粒的输送高度,而其能耗却增幅较小,新型叶轮的空气分散度在1.5～2.5。
|
| 关 键 词： | 粗颗粒 流场 动力学 |
Fluid Dynamics Study of Flotation Impeller Applied to Coarse Particle |
| |
| SHI Shuaixing,LAI Maohe,FENG Tianran,ZHOU Hongxi. Fluid Dynamics Study of Flotation Impeller Applied to Coarse Particle[J]. , 2011, 1(4). DOI: 10.3969/j.issn.1671-9492.2011.04.012 |
| |
| Authors: | SHI Shuaixing LAI Maohe FENG Tianran ZHOU Hongxi |
| |
| Affiliation: | SHI Shuaixing,LAI Maohe,FENG Tianran,ZHOU Hongxi(Beijing General Research Institute of Mining and Metallurgy,Beijing 100070,China) |
| |
| Abstract: | Flotation of coarse particle demands not only strong mixing for mineral suspension,but also the mineralization bulb would not drop during ascending.This article studies the fluid dynamics required for a new type impeller applied to flotation of rough particle in the laboratory.The flow velocity of different fluid dynamics area in water are measured and compared with common KYF impeller.It is found,with no remarkable higher power consumption than common KYF impeller under the same rotate speed,the new type i... |
| |
| Keywords: | coarse particle flow field fluid dynamics |
| 本文献已被 CNKI 万方数据 等数据库收录！ |
|
