| (Al_2O_3-SiO_2)_(sf)／AZ91D镁基复合材料微弧氧化膜的制备及电化学阻抗谱分析 |
| |
| 引用本文： | 朱庆振,薛文斌,鲁亮,杜建成,刘贯军,李文芳.(Al_2O_3-SiO_2)_(sf)／AZ91D镁基复合材料微弧氧化膜的制备及电化学阻抗谱分析[J].金属学报,2011(1). |
| |
| 作者姓名： | 朱庆振 薛文斌 鲁亮 杜建成 刘贯军 李文芳 |
| |
| 作者单位： | 北京师范大学核科学与技术学院射线束技术与材料改性教育部重点实验室;北京市辐射中心;华南理工大学材料科学与工程学院; |
| |
| 基金项目： | 国家自然科学基金项目51071031; 北京市自然科学基金项目2102018资助~~ |
| |
| 摘 要： | 在硅酸盐电解液体系中,采用交流微弧氧化方法在增强体体积分数为33%的(Al_2O_3-SiO_2)_(sf)/AZ91D镁基复合材料表面制备出完整的保护性氧化膜.利用SEM,EDS和XRD分析了氧化膜的形貌、成分和相组成,测量了膜层的显微硬度分布.采用电化学阻抗谱(EIS)评价了微弧氧化表面处理前后复合材料的电化学腐蚀性能,确立了不同浸泡时间对应的等效电路.结果表明,微弧氧化膜主要由MgO和Mg_2SiO_4相组成,最大硬度达到1017 HV.氧化膜电化学阻抗模值|Z|与镁合金基体相比大幅度提高,耐腐蚀性能明显高于基体.在3.5%NaCl溶液里浸泡96 h后,EIS出现感抗弧,显示膜内部开始出现点蚀破坏.氧化膜耐蚀性由膜内致密层特性所决定.
|
| 关 键 词： | 镁基复合材料 微弧氧化膜 电化学阻抗谱(EIS) |
PREPARATION OF MICROARC OXIDATION COATING ON(Al_2O_3-SiO_2)_(sf)/AZ91D MAGNESIUM MATRIX COMPOSITE AND ITS ELECTROCHEMICAL IMPEDANCE SPECTROSCOPIC ANALYSIS |
| |
| ZHU Qingzhen,XUE Wenbin,DU Jiancheng,LI Wenfang Key Laboratory of Beam Technology , Materials Modification of Ministry of Education,College of Nuclear Science , Technology,Beijing Normal University,Beijing Beijing Radiation Center,Beijing School of Materials Science , Engineering,South China University of Technology,Guangzhou.PREPARATION OF MICROARC OXIDATION COATING ON(Al_2O_3-SiO_2)_(sf)/AZ91D MAGNESIUM MATRIX COMPOSITE AND ITS ELECTROCHEMICAL IMPEDANCE SPECTROSCOPIC ANALYSIS[J].Acta Metallurgica Sinica,2011(1). |
| |
| Authors: | ZHU Qingzhen XUE Wenbin DU Jiancheng LI Wenfang Key Laboratory of Beam Technology Materials Modification of Ministry of Education College of Nuclear Science Technology Beijing Normal University Beijing Beijing Radiation Center Beijing School of Materials Science Engineering South China University of Technology Guangzhou |
| |
| Affiliation: | ZHU Qingzhen~(1,2)),XUE Wenbin~(1,LU Liang~(1)),DU Jiancheng~(1,LIU Guanjun~(3)),LI Wenfang~(3)) 1) Key Laboratory of Beam Technology and Materials Modification of Ministry of Education,College of Nuclear Science and Technology,Beijing Normal University,Beijing 100875 2) Beijing Radiation Center,Beijing 100875 3) School of Materials Science and Engineering,South China University of Technology,Guangzhou 510640 |
| |
| Abstract: | A thick protective ceramic coating on 33% (Al_2O_3-SiO_2)_(sf)/AZ91D (volume fraction) magnesium matrix composite was prepared by the microarc oxidation (MAO) technique in silicate electrolyte. SEM, EDS and XRD were employed to analyze the surface morphology, composition and phase constituent of the coating, furthermore, the microhardness profile of the coating was also measured. The electrochemical corrosion properties of magnesium matrix composite before and after the MAO surface treatment were evaluated ... |
| |
| Keywords: | magnesium matrix composite microarc oxidation coating electrochemeical impedance spectroscopy (EIS) |
| 本文献已被 CNKI 等数据库收录！ |
|
