| 复合插层剂制备低温可膨胀石墨研究 |
| |
| 引用本文： | 田金星,周丹凤. 复合插层剂制备低温可膨胀石墨研究[J]. 武汉理工大学学报, 2012, 34(6): 87-90 |
| |
| 作者姓名： | 田金星 周丹凤 |
| |
| 作者单位： | 武汉理工大学资源与环境工程学院,武汉,430070 |
| |
| 摘 要： | 以HNO3/H3BO3/KMnO4为氧化插层体系制备低温可膨胀石墨,从HNO3用量、H3BO3用量、高锰酸钾用量、反应温度和反应时间等5个方面讨论了制备低温可膨胀石墨的最佳条件和物料配比。结果表明:制备低温可膨胀石墨的最佳反应温度为45℃,反应时间60min,石墨、HNO3、H3BO3、高锰酸钾的最佳质量比为3∶8∶1∶0.4,由此方法制得的石墨膨胀容积可达到228mL/g。该研究未使用任何含硫的试剂,因而制备的可膨胀石墨不含硫。
|
| 关 键 词： | 低温 可膨胀石墨 制备 膨胀容积 |
Preparation of Low Temperature Expansible Graphite by Composite Intercalating Agent |
| |
| TIAN Jin-xing , ZHOU Dan-feng. Preparation of Low Temperature Expansible Graphite by Composite Intercalating Agent[J]. Journal of Wuhan University of Technology, 2012, 34(6): 87-90 |
| |
| Authors: | TIAN Jin-xing ZHOU Dan-feng |
| |
| Affiliation: | (School of Resources and Environmental Engineering,Wuhan University of Technology,Wuhan 430070,China) |
| |
| Abstract: | The HNO3/H3BO3/KMnO4 oxidation intercalation system for preparing the low temperature expandable graphite was developed in this paper.To obtain the optimum conditions and the influence of the material proportion on the dosage of sulphuric acid,dosage of Boric acid,dosage of potassium permanganate,reaction temperature and reaction time were studied.The reaction was carried out at 45 ℃ for 90 min,the optimal mass ratio of graphite,sulphuric acid,Boric acid,potassium permangantate was 3∶8∶1∶0.4.The inflation volume of grapite could attain 228 mL/g.There are not any sulfur-containing reagents,thus the expansible graphite does not contain sulfur. |
| |
| Keywords: | low temperature expandable graphite preparation expansion volume |
| 本文献已被 CNKI 万方数据 等数据库收录！ |
|
