| 超声波和相转移催化剂在棕榈油皂化反应中的应用研究 |
| |
| 引用本文： | 胡爱军,刘雪,郑捷,孙连立,李洪艳.超声波和相转移催化剂在棕榈油皂化反应中的应用研究[J].中国油脂,2012,37(4):40-43. |
| |
| 作者姓名： | 胡爱军 刘雪 郑捷 孙连立 李洪艳 |
| |
| 作者单位： | 天津科技大学食品工程与生物技术学院,天津,300457 |
| |
| 基金项目： | 国家“十一五”科技支撑计划项目(2006BAD27B03);天津东丽区科技创新专项基金项目(2010312);天津市科技计划项目(09ZHXHNC04900) |
| |
| 摘 要： | 以棕榈油为原料,对其非均相皂化反应进行了研究.对催化剂及皂化处理方式进行考察,并在此基础上选择反应温度、超声波功率、反应时间、催化剂添加量、KOH添加量进行了单因素优化实验.结果表明:相转移催化剂CTAB催化效果最好,超声波辅助搅拌处理方式最佳；单因素优化的最优皂化条件为反应温度70℃,超声波功率320 W,反应时间80 min,催化剂CTAB添加量0.5g(以每克油计),KOH添加量1.75 g(以每克油计).在最优条件下皂化率达到89.32％,是常规搅拌(无催化剂,无超声波作用)下皂化率的4.7倍,大大提高了效率.
|
| 关 键 词： | 超声波 相转移催化剂 棕榈油 皂化反应 |
Application of ultrasonic and phase transfer catalyst in saponification of palm oil |
| |
| HU Aijun
,
LIU Xue
,
ZHENG Jie
,
SUN Lianli
,
LI Hongyan.Application of ultrasonic and phase transfer catalyst in saponification of palm oil[J].China Oils and Fats,2012,37(4):40-43. |
| |
| Authors: | HU Aijun LIU Xue ZHENG Jie SUN Lianli LI Hongyan |
| |
| Affiliation: | (College of Food Engineering and Biotechnology,Tianjin University of Science & Technology, Tianjin 300457,China) |
| |
| Abstract: | The heterogeneous saponification reaction of palm oil was studied.Catalysts and saponification treatment means were investigated first,then the temperature,ultrasonic power,reaction time,dosage of catalyst and dosage of KOH were optimized by single factor experiments.The results showed that phase transfer catalyst of CTAB was the best and the best treatment means was ultrasonic combined with agitation.The optimal saponification parameters were obtained as follows: temperature 70 ℃,ultrasonic power 320 W,reaction time 80 min,dosage of CTAB 0.5 g per gram of oil,and dosage of KOH 1.75 g per gram of oil.Under the optimal conditions,the saponification rate was 89.32%,which was 4.7 times higher than that under conventional conditions(without catalyst and ultrasonic). |
| |
| Keywords: | ultrasonic phase transfer catalyst palm oil saponification reaction |
| 本文献已被 CNKI 万方数据 等数据库收录！ |
|
