Turbulence and combustion interaction: High resolution local flame front structure visualization using simultaneous single-shot PLIF imaging of CH, OH, and CH2O in a piloted premixed jet flame

High resolution planar laser-induced fluorescence (PLIF) was applied to investigate the local flame front structures of turbulent premixed methane/air jet flames in order to reveal details about turbulence and flame interaction. The targeted turbulent flames were generated on a specially designed coaxial jet burner, in which low speed stoichiometric gas mixture was fed through the outer large tube to provide a laminar pilot flame for stabilization of the high speed jet flame issued through the small inner tube. By varying the inner tube flow speed and keeping the mixture composition as that of the outer tube, different flames were obtained covering both the laminar and turbulent flame regimes with different turbulent intensities. Simultaneous CH/CH₂O, and also OH PLIF images were recorded to characterize the influence of turbulence eddies on the reaction zone structure, with a spatial resolution of about 40 μm and temporal resolution of around 10 ns. Under all experimental conditions, the CH radicals were found to exist only in a thin layer; the CH₂O were found in the inner flame whereas the OH radicals were seen in the outer flame with the thin CH layer separating the OH and CH₂O layers. The outer OH layer is thick and it corresponds to the oxidation zone and post-flame zone; the CH₂O layer is thin in laminar flows; it becomes broad at high speed turbulent flow conditions. This phenomenon was analyzed using chemical kinetic calculations and eddy/flame interaction theory. It appears that under high turbulence intensity conditions, the small eddies in the preheat zone can transport species such as CH₂O from the reaction zones to the preheat zone. The CH₂O species are not consumed in the preheat zone due to the absence of H, O, and OH radicals by which CH₂O is to be oxidized. The CH radicals cannot exist in the preheat zone due to the rapid reactions of this species with O₂ and CO₂ in the inner-layer of the reaction zones. The local PLIF intensities were evaluated using an area integrated PLIF signal. Substantial increase of the CH₂O signal and decrease of CH signal was observed as the jet velocity increases. These observations raise new challenges to the current flamelet type models.