| 微通道内二乙醇胺/乙醇溶液吸收CO2的传质性能 |
| |
| 引用本文： | 周旭,王晓静,朱春英,马友光,徐义明. 微通道内二乙醇胺/乙醇溶液吸收CO2的传质性能[J]. 化工学报, 2016, 67(7): 2901-2906. DOI: 10.11949/j.issn.0438-1157.20151821 |
| |
| 作者姓名： | 周旭 王晓静 朱春英 马友光 徐义明 |
| |
| 作者单位： | 1. 天津大学化工学院, 化学工程联合国家重点实验室, 天津化学化工协同创新中心, 天津 300072;2. 中建安装工程有限公司, 江苏 南京 210000 |
| |
| 基金项目： | 国家自然科学基金项目（21276175，91434204，21306127）。 |
| |
| 摘 要： | 利用高速摄像仪实验研究了微通道内二乙醇胺（DEA）/乙醇溶液吸收CO2的传质过程。采用图像法得到微通道内气泡的体积变化，根据微通道进出口压力，计算得到了气液两相从开始接触到平衡时的平均传质系数k。分别考察了气液相流量和DEA浓度对传质系数的影响。结果表明：传质系数随着液相流量和溶液中DEA浓度增大而增大。对于给定的液相流量和DEA浓度，k随着气相流量增大而增大并逐渐趋于一个恒定值。提出了一个传质系数预测式，预测值和实验结果吻合良好。
|
| 关 键 词： | 微通道 传质 CO2 二乙醇胺 吸收 |
| 收稿时间： | 2015-12-02 |
| 修稿时间： | 2016-03-30 |
Mass transfer performance of CO2 absorption into DEA/ethanol solution in microchannel |
| |
| ZHOU Xu,WANG Xiaojing,ZHU Chunying,MA Youguang,XU Yiming. Mass transfer performance of CO2 absorption into DEA/ethanol solution in microchannel[J]. Journal of Chemical Industry and Engineering(China), 2016, 67(7): 2901-2906. DOI: 10.11949/j.issn.0438-1157.20151821 |
| |
| Authors: | ZHOU Xu WANG Xiaojing ZHU Chunying MA Youguang XU Yiming |
| |
| Affiliation: | 1. State Key Laboratory of Chemical Engineering, Collaborative Innovation Center of Chemical Science and Engineering Tianjin, School of Chemical Engineering and Technology, Tianjin University, Tianjin 300072, China;2. China Construction Installation Engineering Co. Ltd., Nanjing 210000, Jiangsu, China |
| |
| Abstract: | A high-speed camera was used to investigate the mass transfer process of CO2 chemical absorption into diethanolamine (DEA)/ethanol solution in microchannel. The volume evolution of the bubbles in the microchannel was obtained by the image-analysis method. By means of the gas pressure at the inlet and outlet of the microchannel, the average mass transfer coefficient (k) from the contact of two phases to equilibrium was attained. The influences of flow rates of gas and liquid and DEA concentration on the mass transfer coefficient were investigated. The experiment results indicated that k increased with increasing liquid flow rate and DEA concentration. For a given liquid flow rate and DEA concentration, k increased gradually up to a constant value with increasing gas phase flow rate. A correlation for estimating k was proposed and the calculated values by the present model agreed well with the experimental data. |
| |
| Keywords: | microchannel mass transfer CO2 diethanolamine absorption |
|
| 点击此处可从《化工学报》浏览原始摘要信息 |
|
点击此处可从《化工学报》下载免费的PDF全文 |
|
