| 三元乙丙橡胶硫化胶粉改性聚丙烯的研究 |
| |
| 引用本文： | 陈文青,黄承亚,钱丽丽. 三元乙丙橡胶硫化胶粉改性聚丙烯的研究[J]. 弹性体, 2008, 18(1): 38-40 |
| |
| 作者姓名： | 陈文青 黄承亚 钱丽丽 |
| |
| 作者单位： | 华南理工大学,材料科学与工程学院,广东,广州,510640 |
| |
| 基金项目： | 华南理工大学与广州市兴宇橡塑五金制造有限公司合作项目 |
| |
| 摘 要： | 采用三元乙丙橡胶（EPDM）与EPDM硫化胶粉复合作为聚丙烯（PP）抗冲改性剂,研究了EPDM硫化胶粉和交联剂DCP用量对PP复合材料性能的影响。结果表明,PP复合材料的拉伸强度和弯曲强度随着硫化胶粉含量的增加而提高,冲击强度明显改善;而DCP用量增加对PP复合材料的拉伸强度和弯曲强度产生不利影响,少量DCP有助于提高PP复合材料的冲击强度;由DSC分析可知,硫化胶粉使PP熔体的结晶温度明显提高。
|
| 关 键 词： | 三元乙丙橡胶 硫化胶粉 聚丙烯 增韧 |
| 文章编号： | 1005-3174(2008)01-0038-03 |
| 修稿时间： | 2007-09-15 |
Study On improving PP/EPDM composite by vulcanized EPDM crumb rubber |
| |
| CHEN Wen-qing,HUANG Cheng-ya,QIAN Li-li. Study On improving PP/EPDM composite by vulcanized EPDM crumb rubber[J]. China Elastomerics, 2008, 18(1): 38-40 |
| |
| Authors: | CHEN Wen-qing HUANG Cheng-ya QIAN Li-li |
| |
| Affiliation: | (College of Material Science and Engineering,South China University of Technology,Guangzhou 510640,China) |
| |
| Abstract: | Different Ethylene Propylene Diene Monomer（EPDM） crumb rubber dosage, and vary concentration of crosslinking agent were studied in the PP/EPDM （mass ratio was 70/30） composite. Results showed that tensile strength, flexural strength increased with the increase of crumb rubber. Also, the crumb rubber improved the impact strength of the composite at a certain content. The antioxidant improved the properties of composite greatly. With the increase of DCP, the tensile strength and flexural strength were decreased, but at the appropriate dosage it contributed to the increase of impact strength. DSC analysis showed that when used crumb rubber to replace part of raw rubber in PP/EPDM had higher crystallization enthalpy than that had no crumb rubber. |
| |
| Keywords: | Ethylene Propylene Diene Monomer（EPDM） crumb rubber Poly Propylene（PP） toughening |
| 本文献已被 维普 万方数据 等数据库收录！ |
|
