Phosphate Type Affects the Quality of Injected Catfish Fillets

ABSTRACT:  Catfish fillets were injected to 115% over green weight prior to tray-packing and storage at 4 °C for 1, 4, 8, and 11 d. Fillets were evaluated for yields, surface color, pH, cooking loss, tenderness, purge loss, and shelf-life. All phosphate treatments increased ( P  < 0.05) fillet tenderness, but the agglomerated blend of sodium phosphates (AGSP) increased ( P  < 0.05) pH and yields, and decreased ( P  < 0.05) CIE  L * and CIE  b * values. Psychrotrophic plate counts (PPC) of fillets treated with the agglomerated blend of polyphosphates (AGPP) were lower ( P  < 0.05) than the control at each storage time, but PPC of all samples reached 7 log CFU/g by day 8 of storage. All agglomerated phosphates and STP (sodium tripolyphosphate) improved yields and quality when compared to the nonmarinated control. However, AGSP was the most effective phosphate at increasing pick-up and yields and decreasing cooking loss due to the pH effect that causes more water to be trapped within the food system. Major quality differences may not have occurred between STP and agglomerated phosphates (other than AGSP) since injection relies solely on pH and ionic strength for marinade pickup, whereas tumbling also relies on mechanical action, which relies more on the presence of various phosphate chain lengths and solubility to impact yields. All phosphate treatments improved the quality of tray-packed, refrigerated catfish fillets that were enhanced through multineedle injection. However, AGSP also increased fillet pH, optimized yields, and improved color.
Practical Application: Use of an agglomerated phosphate blend with a high pH (AGSP) maximized the yield of catfish fillets that were marinated through multineedle injection. In addition, STP and agglomerated phosphate blends increased the yield and tenderness of catfish fillets when compared to the nonmarinated control.     

Evaluation of Poultry Protein Isolate as a Food Ingredient: Physicochemical Properties and Sensory Characteristics of Marinated Chicken Breasts

The possibilities of replacing soy protein isolate (SPI) and reducing the amount of phosphate in marinated chicken breasts using poultry protein isolate (PPI) were investigated. PPI, prepared from mechanically separated turkey meat through the pH‐shift technology, was used as a marinade ingredient for chicken breasts at 2 different concentrations (1.0% and 1.5%, w/w on a dry weight basis). Product characteristics were compared to samples marinated with salt, phosphate, or SPI. All the 5 treatments were subjected to instrumental and sensory analyses. Tumbling yield, drip, and cooking losses as well as expressible moisture showed that PPI can be used as a substitute for SPI in brine. The sensory analysis revealed that there were no differences among treatments in terms of appearance, color, flavor, saltiness, juiciness, tenderness, and overall acceptability of the marinated chicken breasts. However, chicken breasts marinated with phosphate had significantly higher aroma acceptability scores than those treated with 1% PPI.     

Effects of Various Phosphates on the Palatability, Appearance and Storage Traits of Flaked and Formed Restructured Beef Steaks

Seven blends (9.1 kg raw meat) were formulated with 0.75% NaCl and 0.25% or 0.5% sodium tripolyphosphate (STP), sodium hexa-metaphosphate (SHMP) or sodium acid pyrophosphate (SAPP). Steaks from all blends were “slightly” to “moderately” desirable in flavor and overall satisfaction scores. Steaks made with STP had higher shear force values and work required to shear values than all other restructured steaks indicating an increase in binding occurred with added STP. Restructured steaks formulated with 0.5% STP or SHMP had more desirable raw color scores than the control or steaks made with SAPP. Storage life of all phosphate added restructured steaks was past 90 days frozen storage, and steaks containing STP had thiobarbituric acid values below 1.0 at 120 days storage.     

Effects of Conjugated Linoleic Acid, Salt, and Sodium Tripolyphosphate on Physical, Sensory, and Instrumental Color Characteristics of Beef Striploins

ABSTRACT:  USDA Select striploins (IMPS 180; n = 24) were cut into thirds (anterior, medial, and posterior) and assigned to 1 of 8 treatments utilizing a randomized incomplete block design. Treatments included (1) control (C); (2) 1.5% conjugated linoleic acid (conjugated linoleic acid = CLA) (CGA); (3) 0.4% sodium tripolyphosphate (PHO); (4) 0.5% salt (SAL); (5) 0.4% sodium tripolyphosphate, 0.5% salt (SPH); (6) 0.4% sodium tripolyphosphate, 1.5% CLA (PCL); (7) 0.5% salt, 1.5% CLA (SCL); and (8) 0.4% sodium tripolyphosphate, 0.5% salt, 1.5% CLA (SPC). Treatments were injected with solutions to 110% (10% pump) of their original weight. Treatments with CLA had higher ( P < 0.05) marbling scores than treatments that did not. Not including SAL, treatments with salt, or phosphate or a combination of the two had higher tenderness values when sampled by panelists. Fresh steaks with inclusion of CLA had greater amounts ( P < 0.05) of the CLA isomers than steaks not having CLA. Cooked steaks having CLA also had greater amounts ( P < 0.05) of CLA, except for SCL, which were not different ( P > 0.05) from the non-CLA treatments. Day was a significant source of variability for a *, b *, and saturation index. Treatment × day interactions were significant ( P < 0.05) for hue angle and L * values. These data suggest that inclusion of CLA can increase amounts of CLA isomers without major deleterious effects to instrumental, physical, and quality characteristics of beef striploin steaks.     

TEXTURAL PROPERTIES AND COLOR CHARACTERISTICS OF RESTRUCTURED BEEF STEAKS WITH SELECTED BINDERS AND NOMEAT ADJUNCTS

Restructured steaks were evaluated using subjective and objective texture and color analyses. Treatments included: intact muscle, restructured steaks with no additives, salt/sodium tripolyphosphate (NaCl/STP), calcium alginate, crude myosin extract (CME) with 0.1% Nad and 0.4% STP [low salt & phosphate (LSP)], CME with 1.0 NaCl and 0.4% STP [high salt & phosphate (HSP)], surimi LSP and surimi HSP. Restructured steaks made from CME (HSP) or surimi (HSP) exhibited superior (P < 0.05) sensory textural evaluation, tensile strength values, cooking loss properties, color and color stability (subjective and objective) when compared to other restructured steaks except CME (LSP) and NaCl/STP (in some parameters). Restructured steaks made with CME or surimi in combination with 1% NaCl and 0.4% STP improved or maintained textural properties as well as color and color stability of restructured steaks.     

EFFECT OF PHOSPHATE AND PECTIN ON QUALITY AND SHELF-LIFE OF MARINATED CHICKEN BREAST

Fresh split chicken breasts were injected with 5% sodium acid pyrophosphate (SAPP), 5% sodium tripolyphosphate (STPP), 2.5% Genu pectin (GENU), or the combination of 5% SAPP with 2.5% GENU and 5% STPP with 2.5% GENU. Calcium lactate (0.1 M) solution was sprayed on the surface of chicken marinated in pectin. Marinated samples were stored at 4C for 7 days to evaluate changes in the psychrotrophic bacterial count and quality. STPP injected chicken breast had highest (α=0.05) marinade pickup, net weight increase, cook yield and moisture content. SAPP injected chicken had intermediate marinade pickup, but lowest retention in the muscle among all treatments. Marinades with pectin or pectin combined with phosphate had lower pickup but higher marinade retention compared with SAPP injected breasts. The water holding capacity (WHC) of STPP and GENU injected cooked chicken breast was higher than SAPP injected samples or control. All marinated chicken breasts had significantly lower shear force than noninjected control. Neither phosphate nor pectin had a significant influence on microbial activity of marinated chicken.     

BIOGENIC AMINES FORMATION IN SARDINE MARINADE DURING REFRIGERATED STORAGE

Biogenic amines (tyramine, putrescine, cadaverine, histamine, spermidine, spermine) in sardine marinade were investigated. Sardine were beheaded, gutted, filleted, washed and marinated by immersing the fish into solutions containing 2 and 4% acetic acid and 10% NaCl for 24 h. Biogenic amine content, sensory scores and pH values of marinated sardine were recorded during the storage at 4C for up to 5 months. Biogenic amine content in marinated sardine was higher than in raw material. There were significant (P<0.05) differences in biogenic amine content between acetic acid concentrations of 2% and 4% just after marinating. Initial values of biogenic amines in marinade with 4% acetic acid were significantly (P<0.05) lower than those in marinade with 2% acetic acid. The contents of tyramine***, putrescine and histamine in sardine marinade decreased in the first 2–3 months of storage, followed by continuous increase up to 5 months of the storage. After decrease in the first month, cadaverine level did not significantly change. According to results, the marination process influences biogenic amine accumulation.     

EFFECTS OF FAT LEVEL AND COOKING METHODS ON PHYSICAL AND SENSORY CHARACTERISTICS OF RESTRUCTURED BEEF STEAKS

Trimmed top rounds from 9 Angus steers were flaked and formed into restructured steaks containing 15, 20, or 25% fat. The steaks were cooked in a microwave oven (MW) on a preheated browning dish or broiled in a conventional oven (CO). Microwave cooking required less time and energy. Decreased time and energy for cooking also related to increased fat levels. Cooking losses and penetration hardness values were greater for the MW steaks. Cooking losses increased and penetration hardness values decreased with increasing fat level. MW steaks appeared more well-done and were harder, less moist, and more resistant to chewing. As fat level increased softness and moistness scores also increased. Consumer panelists found all steaks to be equally acceptable, suggesting the potential for the development of portion- and fat-controlled restructured steaks for microwave cooking.     

Dielectric Properties and Thermal Conductivity of Marinated Shrimp and Channel Catfish

Peeled shrimp (Peneaus spp.) and channel catfish (Ictalutus punctatus) fillets were either mixed with commercial lemon pepper marinade and vacuum tumbled at 4°C for 30 min or soaked in 2% tripolyphosphate solution overnight. Dielectric constant and loss factor of marinated seafood and the penetration depth of microwaves were functions of temperature. When cooking temperature increased, the dielectric constant increased, while the loss factor and depth of penetration decreased. Because of the large variation in thermal conductivity measured for individual shrimp, no correlation between thermal conductivity and temperature was found. At constant temperature, thermal conductivity of 2% sodium tripolyphosphate-treated shrimp was higher than that of both marinated and nonmarinated shrimp as a result of higher moisture content. However, no difference in thermal conductivity was found between marinated and nonmarinated shrimp or catfish.     

THE EFFECT OF ORGANIC ACID MARINATION ON TENDERNESS, COOKING LOSS AND BOUND WATER CONTENT OF BEEF

Longissimus muscle obtained from beef carcasses was used in this research. Initially, 0.596, 1.0% and 1.5% lactic and citric acid solutions were prepared. Meat was marinated in these solutions (1:4 w/v) in polyethylene bags at 4C for 72h. Bound water, pH, weight gain, cooking loss and Warner Bratzler shear (WBS) were evaluated. Differential Scanning Calorimetry (DSC) was used to determine the bound water content in meat samples. The latent heat of melting (ΔH_m) and bound water were found to be functions of moisture content of marinated meat. There was a significant decrease in pH due to marination. Compared to lactic acid, the samples marinated with citric acid held less water. The WS values in control samples were higher than in marinated samples. Cooking loss was lower in samples marinated with lactic acid compared to citric acid marinated samples.     

Polysaccharides as Alternative Moisture Retention Agents for Shrimp

Phosphates are used as moisture retention agents (MRAs) by the shrimp industry. Although they are effective, phosphates are expensive, need to be listed on a food label, and overuse can often lead to a higher product cost for consumers. Polysaccharides were researched as alternative MRAs. Polysaccharides are usually inexpensive, are considered natural, and can have nutritional benefits. Research was conducted to determine whether polysaccharides yielded similar functional impacts as phosphates. Treatments included a 0.5% fibercolloid solution isolated from citrus peel, an 8% pectin solution, a 0.5% xanthan gum (XG) solution, a 1% carboxymethyl cellulose solution, and conventionally used 4% sodium tripolyphosphate (STP). Experimental treatments were compared to a distilled water control to gauge effectiveness. Freezing, boiling, and oven drying studies were performed to determine how moisture retention in shrimp differed using these different treatments. Water activity was measured to determine any potential differences in shelf life. Solution uptake was also determined to understand how well the treatments enhanced water binding. For moisture loss by freezing, 4% STP and the 0.5% fibercolloid solution functioned the best. The 4% STP treated shrimp lost the least amount of moisture during boiling. The 0.5% fibercolloid and 0.5% XG treatment outperformed phosphates in respect to moisture uptake ability. None of the treatments had a major effect on water activity. All treatments were rated similar in consumer sensory acceptability tests except for pectin, which was rated lower by the sensory panel. Overall, polysaccharides were found to be viable alternatives to phosphates.     

传统卤豆干工艺优化及其对风味物质的影响

针对传统卤豆干卤制不透、产品质量不稳定等问题,以大方县本地黄豆为原料,采用卤汁与压榨成型耦合技术生产卤豆干,并经单因素实验和正交试验优化生产条件,研究了新工艺对卤豆干风味、品质及营养物质的影响。结果表明:采用新工艺生产,卤汁与豆花浸渍比1:1,食盐添加量1.5%,浸渍时间10 min,卤豆干风味最佳,感官评分为90.42。此时豆干外表光滑,口感细腻,风味突出,硬度及弹性优良。与传统豆干相比,NaCl含量由36.35 mg/100 g降低至24.01 mg/100 g,挥发性风味物质由优化前27种提升至31种,芳香族类物质和其他类物质含量明显提升,卤汁与压榨成型耦合生产卤豆干工艺可行。     

Penetration of Sodium Tripolyphosphate into Fresh and Prefrozen Peeled and Deveined Shrimp

The distribution of sodium tripolyphosphate (STP) in peeled and deveined shrimp tails after treatment was investigated using P³² labeled STP. Fresh and frozen brown (Penaeus aztecus) and fresh and frozen white (Penaeus setiferus) shrimp were used in the study. Shrimp were treated in solutions of either 0.5%, 1%, 5%, or 10% STP that had been prepared using P³² labeled STP diluted with “cold” STP. The duration of treatment was either 20 sec, 1 min, 5 min, or 20 min. When shrimp were treated in 0.5% and 1% STP solutions, a phosphate concentration gradient was evident in the shrimp muscle. After such treatments, STP was shown to accumulate on the surface of the muscle preventing further STP uptake. At higher STP concentrations (5% and 10% solutions) prolonged time treatments overcame the concentration gradient as STP became equally distributed through the shrimp muscle (4.8 mm). No difference in the STP penetration mechanism between fresh and prefrozen treated shrimo was evident.     

By-products from herbs essential oil production as ingredient in marinade for turkey thighs

Herb decoctions—the aqueous extract of rosemary, sage and thyme, left as by-product after steam distillation of essential oils, were investigated as a source of antioxidants in marinades for turkey thigh meat. Lipid oxidation after marinating, cooking and chill storage (warmed over flavour, WOF) was assessed by thiobarbituric acid-reactive substances (TBARS), GC-MS and sensory judgement on marinated and untreated meat. Results showed that marinating with herb decoctions, which exerted antioxidant activity (free radical scavenging), was an effective means of retarding lipid oxidation in raw and cooked meat. Meat from the rosemary marinade had the lowest TBARS values and volatile levels, while the control samples showed the highest values throughout the marinating, cooking and storage period. Oxidative changes in meat marinated with thyme and sage were significantly more advanced than in meat marinated with rosemary decoction. The partial least squares regression (PLS-R) showed that control samples were strongly related to the oxidation variables (volatiles, TBARS, rancidity) while the marinated meat had high scores for spicy and acidic odour and flavour. Results indicated that antioxidants contained in herb decoction, could be exploited in marinades to prevent rancidity in stored, heat-treated turkey meat products.     

Enhancing palatability traits in beef chuck muscles

Thirty-six USDA Select complexus, latissimus dorsi, rhomboideus, serratus ventralis (SEV), splenius, subscapularis, supraspinatus (SUS), and triceps brachii (TRB) muscles were studied. Muscles were assigned to one of four treatments: control, marinated, needle-pumped, and vacuum-tumbled to reach 10% brine pick-up after treatment. The solution was formulated to have 0.5% of sodium chloride and 0.4% of sodium tripolyphosphate in the end product. Steaks from the SEV, SUS, and TRB muscles were cooked on a grill and the other five muscles were oven-roasted whole, all of them cooked to an internal temperature of 71°C. Sensory evaluations and Warner-Bratzler shear force (WBSF) determinations were conducted immediately after cooking (Day-1), and after being cooked and stored frozen for 60 days (Day-60). For the Day-60 evaluation, samples were reheated using a microwave oven. The needle-pumped treatment reduced WBSF values compared to the control in 3 out of 8 muscles (P<0.05). The marinated treatment appeared to have the greatest influence on juiciness and was different from the control in 7 of 8 muscles (P<0.05). Comparing treated muscles to the control, tenderness was increased in 4 out of 8 muscles when needle pumped (P<0.05). Brine treatment reduced sensory detected connective tissue only in 2 of 8 muscles. More off-flavors were detected by the panel for marinated samples from six of eight muscles. All muscles had lower values for WBSF, less connective tissue and off-flavors, and higher juiciness, overall tenderness, and beef flavor intensity on Day-1 than Day-60. The needle-pumped method was slightly superior to the marinated and vacuum-tumbled treatments even though the differences were not always consistent. But, regardless of the application method, palatability traits were generally enhanced by brine treatments.     

Palatability of bison semimembranosus and effects of marination

The present study was conducted to investigate the palatability of bison semimembranosus muscle (SM) and the effects of injection with sodium chloride and sodium tripolyphosphate on cooking yield, colour, shear force and consumer acceptability. Twenty paired SM were obtained from 10 intact male bison (aged 24-30 months); each of these muscles was divided longitudinally into two sections. One section was injected to 110% of its original weight to contain 0.5% sodium chloride and 0.3% sodium tripolyphosphate, while the other was kept as a non-injected control. HunterLab a* (redness) and b* (yellowness) values did not differ (P>0.05) between injection treatments; however, injected steaks had lower L* values (darker) compared to controls. Control samples from bison SM were very lean and high in protein but not very tender. Marination by injection was able to significantly reduce shear force values of SM; that is, injected steaks/roasts had significantly (P<0.001) lower shear force values (63.9 N) compared to control samples (102.3 N). Cooking yields for the steaks/roasts from the injected sections were significantly (P<0.001) higher compared to those from control non-injected sections when cooked to either 71 or 77?°C. Bison samples cooked by moist-heat had significantly (P<0.001) lower cooking losses and shear force values compared to those cooked by dry-heat. As expected, steaks/roasts were more tender and had higher cooking yields when cooked to a medium level of doneness (71?°C) compared to an internal temperature of 77?°C (well done). A panel of 80 consumers preferred injected steaks cooked to 77?°C endpoint over other combinations, followed by non-injected steaks cooked to 71?°C, whereas injected steaks cooked to 71?°C and non-injected steaks cooked to 77?°C were equally but least preferred. Hence, injection seems to be protecting against moisture loss at high end-point cooking temperatures.     

Effect of rapid thawing on the meat quality attributes of USDA select beef strip loin steaks

The objective was to determine the meat quality effects of rapidly thawing beef steaks in a water bath. Frozen beef strip loins (n = 24) were cut into steaks sequentially from the rib end and identified by anatomical location (anterior, middle, posterior) within the loin. Within location, steaks were randomly assigned to conventional (C; 18 to 20 h, 4 °C) or rapid thawing methods. Rapid thawing methods, fast (20 min, 20 °C) or very fast (11 min, 39 °C), were conducted in a circulating water bath. The physical, thawing, cooking, color, and texture characteristics of each steak were recorded. Data were analyzed as a randomized complete block design with a 3 thawing treatments × 3 locations factorial analysis with loin as a block. No location by thawing method interaction was detected (P > 0.05) for the measured variables. Compared to C steaks, rapidly thawed steaks exhibited lower thaw drip loss (P < 0.001) and higher a* values (P < 0.001). Thawing treatment did not influence L*, b*, cook yield, or shear force. Steaks from the posterior end had higher (P < 0.001) surface to volume ratios that may have contributed to the higher thaw loss (P < 0.01), longer cooking time (P < 0.001), lower cooking yield (P < 0.001), and higher shear force (P < 0.02) compared to steaks from the anterior and middle portions of the loins. These data indicate that beef steaks taken from the entire length of the loin can be rapidly thawed in a water bath following food safety guidelines with minimal impact on meat quality. Practical Application: Freezing rate and frozen storage effects on meat quality have been well documented; however, there is comparatively little information on the meat quality effects of rapid thawing within food safety guidelines. This study demonstrates that beef strip loin steaks can be rapidly thawed in as few as 11 min without affecting texture or cooking yield, while reducing thaw drip loss. Thus, rapid thawing may enhance the apparent juiciness of steaks for consumers and provide an effective method for maintaining consistent control of experimental conditions for researchers.     

Determination of 3-MCPD in grilled meat using pressurized liquid extraction and gas chromatography–high resolution mass spectrometry

An analytical method for the determination of free 3-monochloropropane-1,2-diol (3-MCPD) in grilled meat using pressurized liquid extraction, derivatisation using phenylboronic acid, and gas chromatography/high resolution mass spectrometry was developed. The limit of quantification was 1???g/kg. Using this method, the contents of 3-MCPD in grilled steaks (collar) were analysed for different grilling conditions. Charcoal, an electric grill, and a gas grill were used for grilling collars. Further parameters investigated were the pre-treatment of meat (untreated, salted, marinated with oil or emulsion marinade), the use of aluminium grill trays, and a lid. For grilled steaks, contents of 3-MCPD in the range of <1 to 365???g/kg (median 16???g/kg) were detected. The highest contamination was found for a steak pre-treated with an oily marinade grilled on a charcoal grill with a closed lid. Consuming such a steak will exhaust the tolerable daily intake of 2???g/kg body weight for 3-MCPD to about 26?%.     

SENSORY AND PHYSICOCHEMICAL CHARACTERISTICS OF PRECOOKED, MICROWAVE-REHEATABLE STEAKS

Precooked, small-portion, microwave-reheatable steaks were processed from three grades (US Choice, US Select⁺, and US Select^-) of top round beef. Marinated/tenderized samples were compared to nonmarinated/nontenderized controls from each grade. Untrained consumers (n=102) rated the sensory attributes, overall acceptability, and willingness to purchase the steaks at various settings (fast food, restaurant/cafeteria, supermarket). Marination and tenderization improved the sensory attributes, overall acceptability, and consumers' willingness to purchase the steaks, regardless of the grade from which they were prepared. Marinated/tenderized steaks from the US Select grade were more acceptable than nonmarinated/nontenderized steaks from the US Choice grade. Marinated/tenderized steaks from each grade required less force and energy to cut, contained about 3% more moisture and 0.5% less fat, and had more cooking loss than their control counterparts. However, consumers rated the marinated/tenderized products as being more tender, juicy, flavorful and more acceptable overall than controls.     

Functional, Sensory, and Microbiological Properties of Restructured Beef and Emu Steaks

Beef and emu steaks were restructured with 5% fibrinogen/0.25% thrombin (F), 0.5% algin/0.5% calcium lactate (A), or 0.5% phosphate/1.5% salt (P). P and A treatments had higher cooked binding strengths and cook yields than the F treatments (P < 0.05). The pH and cook yields of restructured emu were higher than beef (P < 0.05). Binding strength of emu was lower than beef in all binding systems (P < 0.05). F solution had an aerobic plate count (APC) of 39,000/g and increased the microbial count in restructured emu steaks from 940 to 7500/g (P < 0.05). Cooking to 60°C reduced APC to < 250/g (P < 0.05) with progressively greater bacterial kill after cooking to 66°C or 75°C.