The influence of controlled atmosphere and vacuum packaging upon chilled pork keeping quality

A total of 48 pork loin section (1 kg) with normal inherent muscle quality were utilized to evaluate and compare the effects of a vacuum packaging system and a CO(2) controlled atmosphere packaging system on keeping quality of chilled pork stored at -1·5°C. Results indicated based upon appearance CO(2) packaged porl loin had a storage life of greated than 15 weeks and vacuum packaged pork loid had a storage life of slightly over 12 weeks. However, off-flavor development coinciding with lactic acid bacteria reaching maximum numbers presently restricts the actual storage life of pork loin stored at -1·5°C to 9 weeks in both packaging treatments. Therefore, if microbial contamination on the commercial product can be reduced significantly to prevent spoilage organisms, including lactics, from rapidly growing to maximum numbers, storage life of pork loin at -1·5°C can be extended sufficiently to accomodate all domestic and export applications using either vacuum or CO(2) packaging.     

Influence of dietary creatine monohydrate and carcass cooling rate on colour characteristics of pork loin from different pure breeds

Increased creatine content in the muscle may delay postmortem (pm) lactate formation and postpone pH decline, hence potentially affect the colour of pork. The influence of dietary supplementation with 0 or 50 g creatine monohydrate (CMH)/d for 5 days prior to slaughter and two cooling rates of pig carcasses on the colour characteristics of pork loin from purebred Duroc and Landrace pigs was investigated. CMH increased the content of creatine phosphate in pork loin measured immediately following bleeding, delayed early pm pH decline and gave rise to less red and yellow colour, probably due to induction of a more pronounced oxidative muscle metabolism. A faster cooling rate pm induced darker and less yellow colour in loins from Duroc and Landrace pigs, while only loins from Landrace became less red. Loins from Duroc pigs were darker, less red and less yellow than loins from Landrace pigs, due to slower pH decline and a higher ultimate pH in these loins. Colour stability of pork loin during chill storage, measured as oxidation to metmyoglobin, was not affected by dietary CMH, cooling rate or pig breed. Consequently, the registered differences in colour between treatments during storage were merely due to the degree of initial blooming, and more attention to factors of importance for the degree of blooming should be in focus in future studies of factors of importance for meat colour.     

Cholesterol oxidation products in irradiated raw meat with different packaging and storage time

The effect of irradiation and packaging conditions on the formation of cholesterol oxidation products (COPs) as well as lipid oxidation products was determined in raw turkey leg, beef, and pork loin meat during 7 days of storage. Ground turkey leg, beef, and pork loin muscles were prepared as patties. The patties were individually packaged either in oxygen-permeable or impermeable bags, irradiated at 0 or 4.5 kGy using a Linear Accelerator, and stored at 4°C. The COPs such as 7-hydroxycholesterol, 7β-hydroxycholesterol, and 7-ketocholesterol were detected in fresh raw meats at 0 day at the level of 10.9 to 49.2 μg/g lipid. After 7 days of storage, other COPs such as epoxides, 20-hyroxycholesterol, and choletanetriol were formed in mainly aerobically packaged and irradiated raw meats. Packaging effect was more crucial on the cholesterol and lipid oxidation than irradiation. In aerobically packaged and irradiated meats, turkey leg muscles had higher COPs value than beef or pork did. COPs and thiobarbituric acid reactive substances (TBARS) values had a strongly positive correlation in turkey leg and pork. But, cholesterol oxidation in beef proceeded in irradiated and aerobically stored samples despite of its low level of TBARS value.     

Cryogenic chilling of pork carcasses: Effects on muscle quality, bacterial populations and palatability

Two experiments were conducted to determine the effects of cryogenic chilling on the carcass shrinkage, meat quality, bacterial condition and palatibility of pork. In experiment I, pork sides were chilled at 1°C (n = 20), or immersed in liquid nitrogen (LN) for 1 or 3 min prior to placement in a 1°C cooler. Muscle temperature in the loin was significantly lower at 2 and 6 h post mortem in treated compared to control sides, and loin muscle pH was higher (P < 0·05) at 6 h post mortem in sides immersed for 3 min in LN. Carcass side shrinkage was reduced from 29·3 g kg(-1) in control sides to 20·9 and 13·5 g kg(-1) in sides dipped in LN for 1 and 3 min. Chilling treatment had no significant effect on the survival of mesophilic bacteria on carcass sides, on meat colour, drip loss, protein solubility or sarcomere length, but sides dipped for 1 min in LN has a higher muscle shear value than control sides. In experiment II, carcass sides from halothane positive (H+) and negative (H-) pigs were conventionally chilled (n = 49), immersed in LN for 3 min (n = 23), or electrically stimulated and chilled in LN for 3 min (n = 26). Similar results for temperature, pH, colour, protein solubility and drip loss in loin muscle were found to those in experiment I. Laboratory taste panel results showed that chilling treatment had no effect on palatability. Genotype produced meaningful differences in most palatability attributes with H+ pigs having less tender, less juicy and less desirable flavour than pork from H- pigs. Laboratory studies with inoculated fresh muscle slices showed that a 3 min immersion in LN resulted in a 10-fold reduction in the aerobic spoilage pseudomonads, but effects upon other spoilage bacteria and potential human pathogens were less pronounced. It was concluded that cryogenic chilling using LN reduced carcass shrinkage during cooling, but had no consistent effects on meat quality, palatability or bacterial numbers on the carcass. In contrast, genotype had a significant effect on most pork quality and palatability attributes.     

Changes in fatty acid composition and improved sensory quality of backfat and meat of pigs fed bacterial protein meal

A total of 48 pigs (11.4 and 107.2 kg initial and final weight) were used to evaluate increasing dietary levels of bacterial protein meal (BPM) produced on natural gas (0, 50, 100, or 150 g kg⁻¹) on fatty acid composition, sensory properties, and susceptibility of pork to lipid oxidation. Increasing levels of BPM to diets increased the content of C16:1 fatty acids in backfat and muscle and total monounsaturated fatty acids in muscle, but decreased the content of polyunsaturated fatty acids and iodine value in backfat and muscle. Pigs fed diets containing BPM had reduced thiobarbituric acid reactive substances (TBARS) value in backfat and muscle, reduced intensity of odor and rancid odor and taste in pork after short-time storage, and reduced off-odor and off-taste after intermediate-time storage. To conclude, adding BPM to diets for pigs changed the fatty acid profile, improved the oxidative stability, and sensory quality of pork.     

Effect of packaging atmosphere and pH on the virulence and growth ofYersinia enterocoliticaon pork stored at 4°C

Growth and virulence of pathogenicYersinia enterocoliticawere investigated on high (pH>6.0) and normal (pH<5.8) pH pork packaged in modified atmospheres and stored at 4°C. Modified atmospheres used in the study were vacuum packaging and saturated CO₂. Pork was packaged in a high gas barrier packaging film and examined over a 30-day period. Phenotypic characteristics were used to detect the presence of the virulence plasmid ofY. enterocoliticaafter exposure to the pork packaging and storage regimen. Phenotypic characteristics ofY. enterocoliticaisolates from pork loin stored at 4°C for 30 days that were studied included Congo red uptake, calcium dependence and autoagglutination in methyl red Voges–Proskauer broth and tissue culture medium. Numbers ofY. enterocoliticaon the lean surface of high pH pork slices increased approximately 2.7logcfucm⁻²when vacuum packaged and stored at 4°C for 30 days. Storage of inoculated normal pH pork in 100% CO₂resulted inY. enterocoliticaremaining in the lag phase over the storage period. Virulence ofY. enterocoliticawas maintained in 25 to 35% of isolates following storage for 30 days at 4°C in vacuum- and CO₂-packaged meats and was not affected by pH of the pork loin.     

EFFECTS OF DIETARY GLYCINE BETAINE ON BLOOD CHARACTERISTICS AND PORK QUALITY

This study was conducted to determine the effects of dietary glycine betaine on pork quality and blood characteristics. A total of 80 female pigs (Landrace  ×  Yorkshire  ×  Duroc) were randomly allotted into one of four experimental diet groups. Each group of pigs fed with a commercial diet (control) added with 0.2 g glycine betaine (T1), 0.4 g glycine betaine (T2) and 0.6 g glycine betaine (T3)/kg diet during 40 days. Glycine betaine concentrations in plasma and loin muscle were significantly increased by dietary glycine betaine; however, triglyceride concentration in serum was decreased by dietary glycine betaine. Creatine phosphokinase concentrations in plasma had no significant difference among the dietary groups. Redness ( a* ) was significantly higher in T2 and T3; however, at the first and seventh days of storage, redness ( a* ) was not significantly different between dietary groups. Shear force was significantly higher in dietary glycine betaine groups at the first day of storage. Cholesterol content was significantly lower in T2 and T3, whereas T1 was not significantly different compared with the control group. In fatty acid composition, the ratio of saturated fatty acids was increased, whereas unsaturated fatty acids were decreased by dietary glycine betaine.

PRACTICAL APPLICATIONS

Glycine betaine is an amino acid (trimethylglycine) present in most organisms, and is an obligatory intermediate in the catabolism of choline. Glycine betaine has been reported to affect some aspects of pork qualities. As a result of this study, dietary glycine betaine should improve meat redness and reduce cholesterol. However, dietary glycine betaine did not influence creatine phosphokinase levels in plasma. These results will be helpful to the pork industry and meat scientists for improving meat qaulity.     

Effect of Duroc content, sex and ageing period on meat and eating quality attributes of pork loin

This study was conducted to determine the effect of percentage Duroc content of entire male and female pigs and ageing period on meat and eating quality attributes of pork loin (M. longissimus thoracis et lumborum). A total of 84 pigs [entire males (n=42) and female (n=42)] of 0% Duroc (100% Large White), 50% Duroc (Duroc×Large White) or 100% Duroc (n=14 pigs per sex×genotype combination) were slaughtered at a liveweight of 100 kg. Steaks from the M. longissimus lumborum of female pigs were aged for either 2 or 7 days post-slaughter and evaluated using a consumer taste panel. Eating quality attributes of tenderness, flavour and overall liking of pork loin steaks from female pigs were not (P>0.05) influenced by Duroc content. Pork from 100% Duroc pigs was juicier (P=0.05) and had a higher (1.84%, P=0.05) intramuscular fat content than pork from 0 and 50% Duroc pigs (1.40 and 1.25%, respectively). Pork from entire male pigs had a lower (P<0.001) intramuscular fat content, was darker (P<0.01) in colour and recorded higher (P<0.01) Warner Bratzler shear force values compared with pork from female carcasses. Ageing pork loin steaks in vacuum bags for 7 days improved tenderness (P<0.01), flavour (P<0.05) and overall liking (P<0.05) compared with steaks aged for 2 days post-slaughter. Ageing of pork steaks for 7 days post-slaughter improved eating quality attributes far more effectively than increasing percentage Duroc content of pigs, which only influenced consumer scores for juiciness.     

Effects of Dietary Rape Seed Oil, Copper(II) Sulphate and Vitamin E on Drip Loss, Colour and Lipid Oxidation of Chilled Pork Chops Packed in Atmospheric Air or in a High Oxygen Atmosphere

The effect of addition of rapeseed oil (canola), CuSO(4) and vitamin E (all-rac-α-tocopheryl acetate) to pig diets on pork meat quality (lipid oxidation, colour and drip loss) was studied. Pigs were reared on ten different diets, either a control diet (no supplementation of rapeseed oil, CuSO(4) or vitamin E) or 6% rapeseed oil diets supplemented with CuSO(4) (0, 35 or 175mg/kg) and vitamin E (0, 100 or 200mg all-rac-α-tocopheryl acetate/kg). The natural content of vitamin E originating from feed ingredients amounted to 9-23mg vitamin E (α-tocopherol) per kg feed. Muscle vitamin E levels reflected the dietary intake and pigs fed the control diet had significantly lower levels than pigs fed rapeseed oil diets. The quality of fresh pork chops packed in air or in 80% O(2):20% CO(2) was followed during chill storage for 8 and 13 days, respectively. Colour, as measured by tristimulus colorimetry of pork chops packed in 80% oxygen atmosphere, was significantly improved with respect to redness when compared to chops packed in air, regardless of dietary treatment. The low vitamin E content in pigs fed the control feed significantly decreased a values and the oxidative stability of pork chops during chill storage compared to the other feeding groups. Packing of chops in a high-oxygen atmosphere increased lipid oxidation, especially in chops with low levels of vitamin E. Supplementation of rapeseed oil diets with 100 or 200mg vitamin E significantly decreased lipid oxidation of chill stored chops. Supplementation with CuSO(4) did not influence meat quality attributes (drip loss, colour stability and lipid oxidation) for any of the storage conditions.     

Static, Controlled (CO2) Atmosphere Packaging of Retail Ready Pork

Wrapped boneless pork loin roasts and slices were stored at 4°in bulk under constant CO₂ concentrations of 50% and 100% for 1 and 2 wks. Samples stored under 50% CO₂ for 2 wks could subsequently be displayed (aerobic) for 3 days without becoming unacceptable or for 6 days if previously held under 100% CO₂ for 14 days. Aerobic shelf-life at 4°of the latter samples equalled that of fresh pork chops under simulated retail display. Physicochemical characteristics during storage did not limit acceptability. Reusable master packs have application for distribution of retail ready cuts under controlled atmosphere packaging.     

Effect of oxidized dietary lipid and vitamin E on the colour stability of pork chops

The effect of oxidized corn oil and vitamin E (α-tocopheryl acetate) in pig diets on the oxidative stability of muscle lipids and on the surface colour characteristics of fresh and previously frozen pork chops in refrigerated storage was investigated. Lipid oxidation (TBARS values) and surface redness (Hunter 'a' values) were significantly influenced (P < 0·01) by dietary α-tocopheryl acetate levels but not by degree of oxidation of dietary corn oil. Lipid oxidation and colour deterioration during refrigerated storage were greater in previously frozen chops compared to fresh chops. TBARS values were lower and Hunter 'a' values higher in pork chops from pigs fed 100 and 200 mg α-tocopheryl acetate/kg diet compared to pigs fed 10 mg/kg diet after 2, 4, 6 and 8 days of refrigerated storage. Hunter 'a' values were significantly correlated (P < 0·01) with the logarithm of TBARS values. The results suggest that oxidation of myoglobin precedes oxidation of muscle lipids in pork chops stored at 4°C.     

Evaluation of the antioxidant potential of grape seed and bearberry extracts in raw and cooked pork

The effect of grape seed extract (GSE) and bearberry (BB), on lipid oxidation (TBARS, mg malondialdehyde (MDA)/kg muscle), colour (CIE ‘a’ redness value), pH, microbial status (log₁₀CFU colony forming units/g pork) and sensorial properties of cooked pork patties was investigated. GSE (0–1000 μg/g muscle) and BB (0–1000 μg/g muscle) were added to raw pork (M. longissimus dorsi) patties which were stored in modified atmosphere packs (MAP) (75% O₂:25% CO₂) for up to 12 days at 4 °C. Cooked pork patties were stored in MAP (70% N₂:30% CO₂) for up to 4 days at 4 °C. Mesophilic plate counts and pork pH were unaffected by GSE and BB. GSE and BB addition decreased (P < 0.05) lipid oxidation (TBARS) in raw pork patties on days 9 and 12 of storage, relative to controls. Antioxidant activity of GSE and BB was observed in cooked pork patties demonstrating the thermal stability of GSE and BB. The ‘a’ redness values of raw and cooked pork patties marginally increased with increasing GSE concentration. The sensory properties of cooked pork patties were unaffected by GSE and BB addition. Results obtained demonstrate the potential for using health promoting nutraceuticals in meat and meat products.     

3种天然香辛料液对冷却肉的保鲜效果

利用超声波辅助提取香辛料液,得到八角、白胡椒、肉桂的不同质量浓度水提取液,用以处理冷却猪通脊肉,并考查其在0～4℃贮藏条件下的保鲜效果.通过测定菌落总数、TVB-N值、汁液流失率、感官评分等指标,对冷却猪肉新鲜度进行综合评价.结果表明:八角、白胡椒、肉桂的水提取液质量浓度分别为0.2、0.05、0.05g/100mL时,对冷却猪肉具有良好的保鲜效果.在单因素试验的基础上,进行正交试验,通过感官评分和1/TVB-N值进行综合评价.结果表明:0.2g/100mL八角、0.02g/100mL白胡椒、0.1g/100mL肉桂复合保鲜液对冷却猪肉的保鲜效果较好.     

Effects of Different Chilling Methods on Hot Processed Vacuum Packaged Pork

Longissimus muscle (loin section) was removed from each side of 24 pork carcasses within 20 min postmortem. Each muscle was divided in half (N = 96 sections), vacuum packaged and allotted to one of four treatments: (1) normal chilling, (2) propylene glycol immersion, (3) crust freezing, or (4) high temperature conditioning and four storage intervals (N = 6) or 0, 7, 14 or 28 days. Rapid chilling with propylene glycol increased (P<0.05) purge. Shear force values were increased when loins were rapidly chilled (P<0.05) but few sensory differences were observed. Off-odor scores increased (P<0.05) with increasing storage time. Normal chilling resulted in lighter muscle color scores than rapidly chilled loin sections. Rapid chilling does not have a beneficial effect on palatability or shelf life of hot-processed fresh pork.     

Microbial, physical-chemical and sensory spoilage during the refrigerated storage of cooked pork loin processed by the sous vide method

The aim was to study spoilage during the refrigerated storage of cooked pork loin processed by the sous vide method. Samples were packaged under vacuum into polyamide-polypropylene pouches, cooked at an oven temperature/time of 70 °C/12 h, chilled at 3 °C and stored at 2 °C for 0, 5 or 10 weeks. Microbial (psychrotrophs, lactic acid bacteria, Enterobacteriaceae, moulds and yeasts), physical–chemical (pH, water activity, TBARS, acidity, L^*a^*b^* colour, texture profile analysis and shear force) and sensory (appearance, odour, flavour, texture and acceptance) parameters were determined. The results showed that sensory spoilage preceded microbiological spoilage of sous vide pork loin. Counts bellow 1 log cfu/g of psychrotrophs, anaerobic psychrotrophs, Enterobacteriaceae and lactic acid bacteria were detected in any control week, while moderate counts (2–3 log cfu/g) of moulds and yeasts were found. Minor changes in water activity, lipid oxidation, CIELab colour, hardness, cohesiveness or gumminess were associated with spoilage of pork loin, only decreases of lactic acid, springiness and shear force were observed. The pork loin was unacceptable after 10 weeks. This loss of acceptance was mainly due to the deterioration of meaty flavour and odour, although the loss of appearance, juiciness and firmness also contributed. Moderate warmed-over and rancidity were detected. The sensory analysis was the most effective method for determining the shelf life of the sous vide pork-based dishes.     

Effects of pork meat cut and packaging type on lipid oxidation and oxidative products during refrigerated storage (8 degrees C)

ABSTRACT:  Lipid oxidation and oxidative products as affected by pork meat cut, packaging method, and storage time were evaluated during refrigerated storage. Pork belly had higher pH and thiobarbituric acid reactive substance (TBARS) values than pork loin, and aerobic-packaged belly had higher TBARS than vacuum-packaged counterparts. Loin had higher free fatty acid (FFA) values than belly, and increased FFA values were observed with increased storage time. Peroxide values increased up to 7 d and decreased thereafter. Volatile compounds such as alkanes, aldehydes, ketones, and alcohols with high volatility in belly were higher than those in loin. Nonanoic acid, ethyl ester in belly, and hexadecanoic acid in loin might be considered as indices of lipid oxidation. Overall, vacuum packaging was better than aerobic packaging to retard lipid oxidation and production of oxidative products, and loin was more sensitive to lipid oxidation than belly.     

Location of and post‐mortem changes in some cytoskeletal proteins in pork and cod muscle

The cytoskeletal proteins actin, nebulin, spectrin, desmin, vinculin and talin were labelled immunohistochemically in sections of muscle from commercially available pigs and cod (Gadus morhua) taken pre‐rigor and from samples stored for several days. Actin, nebulin and spectrin gave similar labelling patterns in both pork and cod muscle which remained the same in stored samples. Desmin was intensely labelled at the cell boundaries and within the body of the cells in both pork and cod in the initial and the stored samples. Vinculin was readily labelled in pork muscle but showed only diffuse labelling in fish. Labelling for talin in pork muscle was intense at the sarcolemma but was not present in samples stored for 4 days. In contrast, the label for talin was concentrated at the myotendinous junction of the cod muscle throughout the storage period. These are the first reports of the detection and location of spectrin and vinculin in fish muscle and of the location of talin. The results are discussed in terms of muscle structure, function and post‐mortem tenderisation. © 2000 Society of Chemical Industry     

Effect of modified atmospheres on microbiological, color and sensory properties of refrigerated pork

Pork loin samples were stored (4 °C) in nylon polyethylene plastic bags using different modified atmospheres packaging (MAP): vacuum, 100% CO₂ 99% CO₂ + 1% CO, 100% O₂ or 100% CO followed by vacuum. Throughout the storage period Pseudomonas growth was limited in loins packaged in all MAPs evaluated, except for 100% O₂. Psychrotrophs reached 10⁷ CFU g⁻¹ after 20 days of storage except for the loin samples in 100% O₂ MAP that present count above 10⁸ CFU g⁻¹. The 1% CO/99% CO₂ atmosphere was best for preserving the desirable pork loin color and the L* and a* values remained similar to the fresh meat values using this MAP. Pork loins in 99% CO₂/1% CO MAP obtained the highest consumer acceptance scores after 24 h of storage. These samples and those treated with CO and then vacuum packaged received the greatest acceptance scores even after 20 days of storage.     

Effects of distribution packaging method and storage time on the physical properties and retail display characteristics of pork

The sensory characteristics of pork chops from bone-in loins and Boston butts (n = 65 each) were affected little by primal loin and the butt packaging method (paper wrap, vacuum pack and gas flush) and storage time (7, 10 and 14 days) under industry conditions. However, loin chops fabricated from vacuum-packaged loins after 14 days of storage had less (P < 0·05) discoloration and two-toning than chops fabricated from other loins. All loin chops were placed in retail display and overwrapped with a polyvinyl chloride film after fabrication at each storage time. Vacuum-packed butts stored for 10 and 14 days produced chops with less discoloration and two-toning, and higher overall appearance scores (P < 0·05) compared to chops from paper-wrapped or gas-flushed cuts. Vacuum-packaging resulted in higher quality retail cuts than paper-wrapped or gas-flushed packaging. Thus, it is recommended that the pork industry and retail distribution system utilize vacuum-packaging as the primary method to store and ship fresh pork before retail sale.     

Decolouration and lipid oxidation changes of vacuum-packed Iberian dry-cured loin treated with E-beam irradiation (5 kGy and 10 kGy) during refrigerated storage

The effect of irradiation (0, 5 and 10 kGy) on the oxidative and colour stability of vacuum-packed Iberian dry-cured loin slices from pigs fed on concentrate feed (CON) or free-range reared (FRG) stored under refrigerated storage was studied. Irradiation treatment increased lipid oxidation, measured as TBA-RS values and hexanal content of dry-cured loins. It also increased redness (CIE a) and lightness (CIE L) of dry-cured loins. Refrigerated storage reduced the differences due to irradiation treatment of instrumental colour values like lightness. However, the decrease of redness during storage was more marked in irradiated than in non-irradiated dry-cured loin. Storage increased differences in TBA-RS values between irradiated and non-irradiated FRG dry-cured loin, while the opposite trend was found for CON dry-cured loins. In addition, no differences in the hexanal content were found after 30 days of refrigerated storage. Therefore, the storage of Iberian dry-cured loin in absence of oxygen by using a vacuum packaging could be an adequate method to reduce changes associated to irradiation treatment in Iberian dry-cured loin.

Industrial relevance

Iberian dry-cured loin is a high sensory quality meat product with increasing projection in external markets Irradiation has shown to be an effective method to control pathogen and spoilage microorganisms in meat and meat products. However, e-beam irradiation can promote colour and oxidation changes that could modify their sensory characteristics. The study aimed the evaluation of e-beam irradiation at two levels (5 and 10 kGy) — higher doses than those that could be necessary to control pathogen microorganisms in this kind of product — on colour changes and lipid oxidation at vacuum-packed slices of Iberian dry-cured loin during subsequent extended chilled storage. E-beam treatment induced changes in colour and lipid oxidation in sliced Iberian dry-cured loin immediately after treatment and subsequent refrigerated storage.