掺纳米白炭黑对新拌和硬化水泥基材料性能的影响

通过TEM,SEM,BET和激光粒度分析测试,对比研究了沉淀法纳米白炭黑(precipitated silica,PS)与纳米SiO2微粉(nano-silica powder,NS)的纳米特性及其团聚特性,并通过流变、凝结时间、强度和氯离子渗透深度测定,研究了掺PS和NS对新拌和硬化水泥基材料性能的影响及机理.结果表明:PS的团聚程度远大于NS,未经球磨分散处理时呈双峰粒度分布,团聚颗粒粒径很大,D50和D90分别高达58.187 μm和105.326 μm,大大超过52.5水泥的颗粒粒度.NS掺量低于1.0％时对水泥净浆稠度影响不大,但PS掺量对净浆稠度有明显影响,低于0.75％时缓慢增长,超过1％时则明显增大.掺PS和NS均可促进水泥水化,在1.0％掺量范围内,随PS掺量增加,水泥砂浆的强度和抗氯离子渗透性能均可得以有效改善.     

硼掺合料对水泥浆体性能的影响

研究了不同含硼添加剂对水泥浆体凝结时间、抗压强度、抗折强度、结合水含量及碱度的影响,并采用XRD和SEM测试手段分析了硬化浆体微观结构,着重考察了硼元素的引入方式对水泥水化性能的影响。研究表明:硼砂、硼酐及硼玻璃粉对水泥浆体性能的影响存在很大差异。硼砂具有明显的缓凝作用;硼酐稍延缓了水泥的凝结时间,但严重影响了水泥石的力学性能,主要可能是硼酐中可溶性硼与水泥水化后的钙离子形成致密的水化硼酸钙膜,覆盖在水泥颗粒表面,阻止了水泥颗粒与外部溶液的接触,使水泥水化反应无法正常进行;而硼玻璃粉对水泥的凝结时间和力学性能均不存在不良影响。     

Probing development of microstructure of early cement paste using 1H low-field NMR

Development of microstructure of early cement paste (0–6 h) was investigated with ¹H low-field NMR. It was found that T ₂ (transverse relaxation time) distributions of fresh cement paste were bimodal and two peaks were ‘long component’ and ‘short component’. Separation degree of two peaks was a sign of exchange of water within flocculation and outside flocculation. Factors such as water cement ratio, specific surface area and dosage of superplasticizer had influences on the separation degree: the separation degree increased with the water cement ratio; the separation degree of cement paste prepared with cement with a high specific surface area was zero; dosage of superplasticizer will decrease separation degree. Results also suggested that T ₂ distribution gradually moved to the left and T ₂ of long component and initial fluidity were linearly correlated.     

Influence of Superplasticizers on Early Age Drying Shrinkage of Cement Paste with the Same Consistency

The influence of superplasticizer(SP) on the early age drying shrinkage of cement paste with the same consistency was investigated. To conduct the test, which lasted for 72 hours, three paste mixtures were used for comparison. The 72 hours early age drying shrinkage staring from the initial setting time was measured by a clock gauge. The pore size distribution was measured by Mercury Intrusion Method. The surface tension of capillary simulation liquid and mass loss of paste were also measured. The experimental results showed that the addition of SP increased the early drying shrinkage greatly. The ratios of water evaporation and the total free water in mixtures added with SPs showed great differences. SPs fined the capillary pores of paste, and the volume of pore with diameter within 50 nm was well consistent with shrinkage rate. The addition of SPs did not raise the capillary liquid surface tension. It showed that with the volume of pore with diameter within 50 nm and the ratio of water evaporation and the total free water a tolerable shrinkage result of paste added with SP could be predicted, and the elastic modulus could have an influence on the early shrinkage. These results have never been proposed before.     

Adsorption of superplasticizers in fly ash blended cement pastes and its rheological effects

The adsorption of superplasticizers in fly ash blended cement paste and its rheological effects were investigated.It is shown that the absorption of superplasticizer on portland cement particles is very different from that on fly ash particles.The fly ash particles have smooth surfaces and are negatively charged,so its adsorption capacity is weaker than the portland cement particles.The amount of adsorbed SP in the fly ash blended cement paste depends highly on the replacement proportion of portland cement with fly ash,and to a much less extent on the nature of the fly ash.However,the amount of adsorbed superplasticizer does not correspond well the ζ-potential of the solid particles,due the strong adsorbing capacities of the Portland cement particles.When fly ash replaces portland cement in the paste,the rheological behavior is radically changed,which is closely related to the fineness and density of the ash.The packing and agglomeration of the solid particles are the controlling factors on the rheological parameters of the fresh paste,instead of the amount and type of adsorbed superplasticizer.     

Relaxation study of cement based grouting material using nuclear magnetic resonance

Aiming at actual condition of poor effect of hole sealing for the reason of poor cement paste fluidity in the process of coal mine gas drainage, by adding a water reducing agent, cement paste for hole sealing was produced. The changes of initial distribution, weighted average values and total relaxation signal intensity of transverse relaxation time (T₂) of water in pure cement paste and water reducing agent added cement paste were studied with low field proton nuclear magnetic resonance (NMR). The results show that there are four peaks in T₂ distribution curves of cement paste: the first peak is related to the bound water in flocculation, the second and the third peaks are related to the water in flocculation, water reducing agent makes it extending towards the long relaxation time, increasing its liquidity, and the fourth peak is related to the free water. By using weighted average values of T₂ and total relaxation signal intensity, hydration process of cement pastes could be roughly divided into four stages: the initial period, reaction period, accelerated period and steady period. By analyzing the periods, it makes sure that the grouting process should be completed in the reaction period in the site, and the drainage process should be started in the steady period. The results have great guiding significance to the hole sealing and methane drainage.     

The Hydration Characteristics and Expansion Machanism of Expansive Cement at Low W/B Ratio

1　IntroductionAnexpansiveagentcannotonlymakethestructurehasself waterproofperformance ,butalsoreducetheshrinkageandthecrackingofconcreteeffectively .Soitisextensivelyusedincommonconcrete .However,theappli cationofexpansiveagentinhigh strengthconcreteisnotattractedmuchattention .Itisnotonlybecauseofthebondageoftraditionalviewpointthatitsshrinkagevalueofhigh strengthconcreteismuchgreaterthanthatofcom monconcrete ,butalsothedeficiencyofadequatestudyonthehydrationcharacteristicsandexpansivemechan…     

The hydration characteristics and expansion machanism of expansive cement at low<Emphasis Type="Italic">W/B</Emphasis> ratio

The hydration characteristics and expansion impetus of three kinds of cement paste under free-and confined-curing conditions were investigated, which were respectively mixed with three different kinds of expansive agent at low W/B ratio. The results show that the hydration products of pure cement paste and paste mixed with expansive agent are same, but the amount of hydration products, un-hydrated C₃S and C₂S are obviously different at the same hydration age. At 3 d age, the amount of CH in pure cement paste is less than that of paste mixed with expansive agent, but it is reverse when at 28 d age. The amount of AFt at 3d and 28d age in pure cement paste is less than those of paste mixed with expansive agent. Regardless of under free- or confined-curing condition, the amount of ettringite produced varies little since 3d age. The joint effect of the tumefaction of gel-ettringite due to water absorption and the expansive pressure on the pore caused by the crystalloid ettringite is the cause of the volume expansion of cement paste, and the former effect is much greater than the latter. LU Lin-nu : Born in 1972 Funded by 973 High-tech Project of China (No. 2001CB610704-2) and the Natural Science Foundation of Hubei Province(No. 2002AB075)     

结合分形理论的水泥絮凝研究

目的对水泥絮凝进行定量化研究,找出其微观结构与宏观性质的联系.方法用“激光颗粒分布测量仪”测试了不同水泥絮凝颗粒的粒度分布,分析了各絮凝颗粒的分形特征,探讨了分形维数与水泥比表面积、净浆流动度的关系.结果水泥絮凝颗粒的粒度分布具有很好的自相似性,属于典型的无规三维分形体;且分形维数越大,比表面积越大,水泥净浆流动度越小.结论用分形维数对抽象的水泥絮凝粒度分布进行定量描述是可行的,从分形维数可以推断出比表面积和净浆流动度等宏观性质的变化趋势.     

Influence of thickeners on cement paste structure and performance of engineered cementitious composites

Hydroxypropyl methylcellulose (HPMC) and amphoteric polyacrylamide (ACPAM) were respectively used to prepare engineered cementitious composite (ECC) which exhibits strain-hardening behavior under uniaxial tension. The connections between cement paste structure and the performance of the composite in fresh and hardened state were investigated, aiming at achieving the desirable workability at a given solids concentration. The experimental results of viscosity and microstructure of cement pastes show that the intimate connections between flocculation groups lead to the growing increase in viscosity. The results of deformability and fiber dispersion demonstrate that fiber dispersion coefficient is a comprehensive index which can reflect the performance of deformability as well as uniformity. And the desirable fresh mixture can be achieved by optimizing the viscosity of cement paste. At last, the ductile strain-hardening performance of the ECC prepared with HPMC or ACPAM was investigated through uniaxial tensile test.     

聚合物-水泥基注浆材料早期流变及水化特性

为制备满足复杂地层加固工程需求的高性能水泥基注浆材料,探究以偏铝酸钠(SA)、聚羧酸(Sp)及高吸水性树脂(SAP)为组分的聚合物体系及其掺量对新拌水泥浆体流变特性与泌水率的影响,并采用水化放热监测与倒置荧光显微技术,对不同体系下水泥浆体早期水化进程及微米级颗粒的悬浮分散形态进行分析.结果表明:新拌水泥浆液流动性和泌水率与SA、SAP掺量呈负相关,随Sp掺量增加而提高. Sp及SAP延缓了水泥早期水化进程,改性样延迟近1 h进入水化诱导期,诱导期内水化放热速率显著降低.在不同掺量SA的促凝效应、Sp的分散效应以及SAP的"水库"作用下,新拌水泥浆液表现为初始及经时流动度大于200 mm的高流态期可分别被控制在10、20、30 min内且析水率小于5%(稳定性浆液),接近临界期时流动度陡降、流变参数突增并迅速凝结的流变特性.结合微观结构观测结果,建立了新拌水泥浆体流变演化模型,揭示多聚合物协调效应下水泥浆体呈现分散-储水-流变-水化的早期流变机制.     

准噶尔盆地吉木萨尔凹陷二叠系芦草沟组致密油储层成岩作用与储集空间特征

利用岩芯观察、铸体薄片及荧光薄片鉴定,结合激光共聚焦显微镜、扫描电镜、X射线衍射、恒速压汞等分析测试手段,分析了准噶尔盆地吉木萨尔凹陷二叠系芦草沟组致密油储层成岩作用与储集空间特征及其相互关系。结果表明:吉木萨尔凹陷芦草沟组致密油储层主要发育碳酸盐岩类、陆源碎屑岩类、火山碎屑岩类和混积岩类等4种岩石类型,储集空间可分为次生溶孔、晶间孔和微裂缝3类; 不同岩石类型经历了不同的成岩作用过程,发育了不同类型的储集空间。①碳酸盐岩类中,泥晶云岩成分单一,压实致密,胶结作用弱,储集空间以白云石晶间孔为主; 随着粉砂质和凝灰质含量增加,压实作用变弱,长石和凝灰质发生强溶蚀,粉砂质砂屑云岩及凝灰质云岩的储集空间以长石粒内孔、铸模孔及凝灰质溶蚀孔为主。②陆源碎屑岩类中,凝灰质粉砂岩的压实作用中等,粉砂级长石颗粒粒内及边缘、分散状凝灰质溶蚀,且溶蚀孔中有大量的黏土矿物充填,储集空间以蜂窝状长石溶蚀孔、凝灰质溶蚀孔为主; 而云质泥岩压实作用强,溶蚀作用不发育,仅可见晶间孔及微裂缝。③火山碎屑岩类中,粉砂质凝灰岩、云质凝灰岩压实作用中等,长石、凝灰质易溶,但胶结物种类较多,储集空间以次生溶蚀孔为主,发育少量的晶间孔。     

Modificatin of ITZ Structure and Properties of Regenerated Concrete

1Introduction Increasingattentionispaidtotheinvestigationand applicationofregeneratedconcrete(RC)forthesustain abledevelopmentofsociety[13].TheRCispreparedwith demolitionwasteconcreteoroldconcreteastherecycled aggregate(RA).RAcontainsacertainamountofhard enedcementmortar,someofwhichhaveaformofinde pendentlumps,andothersadhereontothesurfaceofnat uralaggregate.SinceRAhasagreaterporosityanda higherwaterabsorptioncapacitythannaturalaggregate,whichhasagreaterinfluenceontheperformanceofRC;conse…     

低需水的新拌水泥浆体流变性研究

在对水泥浆体流变模型和流变性能影响因素分析的基础上，研究了外加剂掺量、SO3含量、矿渣掺量等对新拌水泥浆流变性能的影响。用旋转粘度计对新拌水泥浆进行了动态检测，低需水量水泥的新拌水泥浆具有良好的流变性能，同时它的流变模型符合宾汉姆流变模型。     

UNIFORMITY ASSESSMENT OF CARBON FIBRES DISPERSION IN CEMENT PASTE BY IMPEDANCE MEASUREMENTS

An alternating current was applied to measure the impedance of a hardened cement paste with various contents of carbon fibres. When the free water content in the hardened cement paste is 90%-98%, and the measuring frequency 500Hz, an approximate linear relationship was found between fibre content and impedance of the composite. Based on this relationship , a new attempt was made to evaluate the dispersion uniformity of carbon fibres in cement paste by impedance measurement. The standard deviation S and the coefficient of vriation S/Xi     

The Influence of Free Water Content on Dielectric Properties of Alkali Active Slag Cement Paste

The dielectric performance of alkali activated slag （AAS） cement paste was investigated in the frequency range of 1 to 1000 MHz. The experimental results showed the unstable dielectric properties of harden paste were mostly influenced by the fraction of free water in paste or absorbed water from ambient, but not including hydration water and microstructure. The free water was completely eliminated by heat treatment at 105 ℃ about 4 hours, and then its dielectric loss was depressed; but with the exposure time in air increasing, the free water adsorption in ambient air made the dielectric property of harden cement paste to be bad. The temperature and relative humidity of environment was the key factors of free water adsorption; hence, if the influence of free water on dielectric constant was measured or eliminated, the cement-based materials may be applied in humidity sensitive materials or dielectric materials domains.     

不同黏土对掺减水剂水泥净浆流动度影响

目的 研究4种不同黏土对掺聚羧酸减水剂及萘系减水剂水泥净浆流动度的影响规律并从黏土的吸附性能角度探究其影响机理.方法 采用水泥净浆流动度试验方法比较了4种黏土对掺聚羧酸减水剂水泥净浆流动度的影响,通过TOC总有机碳测试仪测定了4种黏土对聚羧酸减水剂的吸附量.结果 4种黏土对水泥净浆流动度的影响差异较大,其中钙基蒙脱土和钠基蒙脱土的掺量为2％时,掺聚羧酸减水剂水泥净浆已基本没有流动度,掺萘系减水剂的水泥净浆流动度也有所下降,但降幅稍小,而伊利土和高岭土对掺减水剂水泥净浆流动度无明显负面影响;钙基蒙脱土和钠基蒙脱土对聚羧酸减水剂的吸附量较大,伊利土、高岭土对聚羧酸减水剂的吸附能力和水泥相当.结论蒙脱土对掺聚羧酸减水剂水泥净浆流动度负面影响极为严重,而伊利土和高岭土对掺减水剂水泥净浆基本没有负面影响.     

羧酸型减水剂与水泥的相容性研究

选用含有亲水性羧基、酸酐基、磺酸基、聚环氧乙烷侧链的单体共聚合成了3种羧酸型减水剂,针对4种不同产地的P.O 42.5水泥,测定了在较低水灰比（mw/mc=0.29）下水泥净浆流动度及30 min经时变化,混凝土坍落度及180 min经时变化.净浆流动度30 min损失小于13.8%,混凝土坍落度60 min损失小于15%.3种羧酸型减水剂与不同水泥均具有良好的相容性.     

疏水改性聚丙烯酰胺的制备及其对难沉降尾矿的絮凝性能研究

摘要：采用水溶液共聚法,以甲基丙烯酸甲酯和丙烯酸丁酯为疏水单体,以K2S20。一NaHs03氧化还原体系为引发剂,制备了疏水改性型聚丙烯酰胺,探讨了改性单体用量对改性聚丙烯酰胺的分子量、不溶物含量、溶解速率等性能的影响规律,并对其在两种难沉降尾矿中的絮凝效果进行了评价．研究结果表明：疏水改性聚丙烯酰胺对不同类型的难沉降尾矿浆表现出不同的絮凝效果．     

Influence of CG With High Content of Metallic Particles as a Cement Admixture on Cement Strength

1　IntroductionCopperresidueisanindustrialby productdis chargedbycopperrefineries ,butitusuallycontainssomeusefulmetals .Forexamplecopperresiduecontains 4 %to5 %copper ,1.0 1g tgold ,2 4g tsilverand 4 2 %magne tite ,alltheseexceedthecontentforacomprehensiveutili zation .Inordertoextracttheseusefulmetals ,thecoolingtechnologyofremovingresidueisintroducedbyslowlycooling (4 8h)sothatsomemetallicionsgrow .Afteronemoreflotationforcopperandmagneticbyextractionofiron ,thedischargedresidueiscalledcopp…