Investigation of using possibility of grape pomace in wafer sheet for wheat flour substitution

In this study, grape pomace (GP), a by-product consisting of grape skins and seeds rich in dietary fibres and polyphenols, was used in wafer sheets at different concentrations [5.00 (GP5), 10.0 (GP10), and 15.0 g 100 g⁻¹ (GP15)] for the partial replacement of wheat flour (WF) and improve the functionality of wafer sheets. The GP inclusion at concentrations higher than 5.00 g 100 g⁻¹ significantly affected the texture of sheets as well as the flow behaviour of batters, resulting in softer sheets and more viscous batters (P < 0.05). Moisture contents did not significantly change after GP addition (P > 0.05). After the addition of GP, the L* values decreased and the a* values increased, making the wafers darker (P < 0.05). Moreover, under simulated in vitro digestion conditions, the bioaccessibility of total phenolic compounds in saliva, gastric juice, and intestinal juice was significantly higher than control even at the lowest GP concentration (P < 0.05). Regarding sensory properties, only smoothness and crispness were significantly affected by GP addition, and samples were found to be crisper with higher concentrations of GP. In conclusion, it is possible to partially replace the WF in wafers with GP at a concentration of 5.00 g 100 g⁻¹ to develop a product with higher functionality and nutrient content.     

Optimisation of the Amido Black assay for determination of the protein content of grape juices and wines

While the heat/chill stability of white wines cannot be predicted from the total protein concentration, this information is useful in assessing the effectiveness of fining treatments. We have adapted the Amido Black assay for use in grape juice and wine. The response of bovine serum albumin (BSA) was similar in water, model wine and model juice. The linear range of the assay (<100 mg l^?1) extends beyond protein concentrations typically found in grape juices and wines. The limit of quantification was 11.1 mg l^?1 for BSA in model wine and 7.6 mg l^?1 in model juice, while the limit of detection was found to be less than 3 mg l^?1 in either solution. In contrast to other methods of protein determination, this assay is not affected by common wine phenolic and pectic compounds or by glutathione. The mean response of BSA was similar in model juice and red and white grape juices. The mean response of BSA in red wine was lower than in white wine and model wine (p < 0.001), and there was considerable variation in response among wines. Protein concentrations determined using this method were reproducible (CV < 10%). This optimised assay can be used to monitor protein levels in grape juices and wines. © 2001 Society of Chemical Industry     

Improving the Stability of Probiotic Bacteria in Model Fruit Juices Using Vitamins and Antioxidants

Abstract: This study examined the survival of probiotic bacteria in a model fruit juice system. Three different strains of probiotic bacteria were used in this study: HOWARU Lactobacillus rhamnosus HN001, HOWARU Bifidobacterium lactis HN001, and Lactobacillus paracasei LPC 37. The probiotic bacteria were inoculated into model juice with various vitamins and antioxidants, namely white grape seed extract, green tea extract, vitamin B2, vitamin B3, vitamin B6, vitamin C, and vitamin E. The model juice without any additives was used as a control. Their viability was assessed on a weekly basis using plate count method. The model juice was made with sucrose, sodium citrate, citric acid powder, and distilled water and was pasteurized before use. Our findings showed that probiotic bacteria did not survive well in the harsh environment of the model fruit juice. However, the model juice containing vitamin C, grape extract, and green tea extract showed better survival of probiotic bacteria. The model juice containing grape seed extract, green tea extract, and vitamin C had the same initial population of 8.32 log CFU/mL, and at the end of the 6-wk storage period it had an average viability of 4.29 log CFU/mL, 7.41 log CFU/mL, and 6.44 log CFU/mL, respectively. Juices containing all other ingredients tested had viable counts of <10 CFU/mL at the end of the 6-wk storage period.     

Tannase improves gallic acid bioaccessibility and maintains the quality of mango juice

The effect of tannase on gallic acid (GA) bioaccessibility and auto-oxidative browning of mango juice was investigated. After 2 h of simulated gastric digestion, the concentration of bioaccessible GA increased (P < 0.05) 94.3 ± 7.0% in juice treated with 0.5 U mL⁻¹ tannase while juice not treated with tannase had only a 6.3 ± 3.4% increase in GA. During 2–10 h of simulated intestinal digestion, tannase treated juice continued to have a higher concentration (P < 0.05) of bioaccessible GA in comparison to juice that was not treated with tannase. The use of 167 U 100 mL⁻¹ tannase while processing mango juice did not result in any differences (P < 0.05) in browning measured at 420 nm, yet there was significantly higher (P < 0.05) GA in mango juice post-storage. Processing mango juice with tannase can help improve the bioaccessibility of mango polyphenols without hindering the quality of juice during storage.     

Gas chromatographic determination of diethylene glycol in wine, grape juice and grape-juice concentrates

A gas chromatographic method for the quantitative determination of diethylene glycol in wine, red and white grape juice, and red and white grape juice concentrates is described. The method includes continuous extraction of the diethylene glycol with ethyl acetate by the aid of a rotation perforator. Using the new generation of chemically bonded stationary phases on fused silica together with an appropriate modern cold on-column injection system coupled with an autoanalyzer and a retention gap, the GLC analysis is shown to provide adequate information for quality control purposes. Linearity, precision and recovery with the described procedure were investigated. The precision of the method was studied using a sample containing approximately 65 mg/l diethylene glycol. Twelve separate determinations were performed by the described method; the coefficient of variation was 3.9%. The detection limit of our method is 5 mg/l diethylene glycol both for wine, grape juice and grape juice concentrates. Recovery data are based on wine, grape juice and grape juice concentrates fortified with diethylene glycol at different levels. The ranges of concentration used in this study were 10 mg/l to 10 g/l for wine and 10 mg/l to 100 mg/l for grape juice and grape juice concentrate. The average recovery of diethylene glycol for wine at all concentrations tested was 98.8%; coefficients of variation were between 1.6 and 8.0%. Recoveries of diethylene glycol added to grape juice at the level of 10 mg/l to 100 mg/l were 96% to 109%.     

Production of reduced-calorie grape juice jelly with gellan, xanthan and locust bean gums: sensory and objective analysis of texture

 The production of reduced-calorie grape juice jellies with gellan, xanthan and locust bean gums (LBG) was studied. Twenty formulations of grape juice jelly were prepared according to a second-order composite rotatable design (with six central points). Response surface methodology (RSM) was used to optimise jelly formulation using as independent variables: total sugar content, ranging from 14 to 46°Brix; and total gum concentration ranging from 0.30 to 0.70% (w/v), with the proportion of gums in the mixture xanthan:LBG:gellan ranging from 5:5:90 up to 45:45:10. The processing temperature used was 90°C for complete solubilisation of gums. The dependent variables were objective measures of texture and a parameter obtained from sensory analysis, the overall balance (B), which represents the overall evaluation of the jelly. The resulting polynomial equation (R ² = 0.929) revealed that a jelly produced with white grape juice, total sugar with sucrose equal to 39.3°Brix, and, 0.54% (w/v) of total gum added in the proportions of: 1:1:1.7 (gellan:xanthan:LBG) had a maximum value of B. The sensory-optimised jelly was objectively characterised for texture and the model was tested. The texture characteristics, i.e. gel hardness, cohesiveness and springiness, were found to be similar to those of a reference product, a previously developed reduced-calorie grape juice jelly with low methoxyl pectin. Received: 12 June 1997 / Revised version: 21 August 1997     

Microbial Safety and Shelf Life of UV‐C Treated Freshly Squeezed White Grape Juice

The effects of UV‐C irradiation on the inactivation of Escherichia coli K‐12 (ATCC 25253), a surrogate of E. coli O157:H7, and on the shelf life of freshly squeezed turbid white grape juice (FSWGJ) were investigated. FSWGJ samples were processed at 0.90 mL/s for 32 min by circulating 8 times in an annular flow UV system. The UV exposure time was 244 s per cycle. The population of E. coli K‐12 was reduced by 5.34 log cycles after exposure to a total UV dosage of 9.92 J/cm² (1.24 J/cm² per cycle) at 0.90 mL/s flow rate. The microbial shelf life of UV‐C treated FSWGJ was extended up to 14 d at 4 °C. UV exposure was not found to alter pH, total soluble solid, and titratable acidity of juice. There was a significant effect (P < 0.05) on turbidity, absorbance coefficient, color, and ascorbic acid content. Furthermore, all physicochemical properties were altered during refrigerated storage. The microbial shelf life of FSWGJ was doubled after UV‐C treatment, whereas the quality of juice was adversely affected similarly observed in the control samples.     

The influence of some non-starch polysaccharides on the metabolic response to sucrose-based and fructose-based chocolates in non-insulin-dependent diabetics

Non-insulin-dependent diabetic patients were given test meals (75 g) of conventional (sucrose-based) milk chocolate or diabetic (fructose-based), either free of non-starch polysaccharide (NSP) or supplemented with pectin (5 g (100 g)^?1), or a combination of pectin and oat fibre. The presence of pectin in the conventional formulation led to a reduction in the area under the post-prandial blood-glucose curve (P < 0.05). However, the effect was small in comparison to the reduction obtained by substituting fructose for sucrose, and the pectin-supplemented chocolate had a very viscous mouthfeel. The substitution of an insoluble form of NSP derived from oat husk for a proportion of the pectin abolished the hypoglycaemic effect of the NSP. Inclusion of NSP in fructose-based chocolate was associated with a small reduction in post-prandial fructosaemia but had no effect on the glycaemic response to this chocolate. It was concluded that viscous NSP slows the absorption of carbohydrate from chocolate. However, the necessary viscosity had an adverse effect on the palatability of the product.     

Physicochemical,sensorial and rheological characterisation of whole-fat or low-fat milk jams as influenced by calcium chloride,sodium bicarbonate and sucrose content

Rheological properties of sixteen milk jam treatments produced from commercial full-fat (3 g/100 g) and skimmed (0.15 g/100 g) cow milk by the addition of sucrose, sodium bicarbonate and CaCl₂ were examined. pH, titratable acidity, total solids and ash contents in the milk jam samples ranged from 6.2 to 6.8, 1.3 to 3.3 g/100 g, 56.7 to 70.5 g/100 g and 1.7 to 3 g/100 g, respectively, with a significant variability (P < 0.05). The flow behaviour and consistency indices ranged from 0.7 to 0.9 and 2.7 to 208 Pa.sn, respectively. Rheological measurements showed that the maximal G' × 10² value showed considerable variation (5–932 Pa). As sucrose content increased, pH and total solid content increased, whereas ash content and the L value decreased. Also, a negative correlation between pH and L* (lightness) was found (P < 0.05). Dynamic rheology showed that the jam from skimmed milk with full sucrose and without sodium bicarbonate exhibited more solid-like behaviour than the ones prepared with full sucrose and with sodium bicarbonate. In conclusion, the increase in milk fat caused a decrease in resistance of the mixture subjected to the deformation, which is very important for production of quality milk jam.     

Cashew apple juice: its use in fortifying the nutritional quality of some tropical fruits

The physico-chemical properties of some tropical fruits (pineapple, orange, grape, mango and lemon) were analyzed and compared with those of cashew apple. Cashew apple juice was found to contain the highest amount of vitamin C (203.5 mg/100 ml) of edible portion. Orange, grape, pineapple, mango and lemon contained average values of 54.7 mg, 45.0 mg, 14.70 mg, 30.9 mg and 33.7 mg vitamin C per 100 ml of juice respectively. Obviously, cashew apple juice contains almost four times the amount of vitamin C in the popular citrus fruits and more than four times as much vitamin C as in other fruits. Hence, when cashew apple was blended with other tropical fruits it boosted their nutritional quality. On the other hand, these fruits improved the acceptability of cashew juice in terms of taste and flavour. The blends, even though significantly different (P <0.05) in taste, colour and mouthfeel, were all acceptable to consumers with no significant difference (P>0.05) in overall acceptability. Received: 16 August 1999 / Revised version: 2 November 1999     

Impact of Harvesting and Processing Conditions on Green Leaf Volatile Development and Phenolics in Concord Grape Juice

ABSTRACT: The disruption of plant cell walls during fruit juice processing results in the enzymatic formation of herbaceous-smelling green leaf volatiles (GLVs). Our objective was to assess the impact of thermal processing conditions on resulting levels of GLVs (hexanal, trans-2-hexenal, hexanol, cis-3-hexenol, and trans-2-hexenol), total phenols, monomeric anthocyanins, and percent polymeric color in Concord grape juice. The effects of fruit maturity and stage of juice processing on juice GLV content was also assessed. Of the GLVs studied, only trans-2-hexenal routinely exceeded its published sensory threshold in finished juice. We observed an inverse linear correlation between berry maturity (total soluble solids) and trans-2-hexenal levels in finished juice (P < 0.05, R ²= 0.91). Trans-2-hexenal was at a maximum immediately following crushing (569 μg/kg, >30-fold over detection threshold [DT]), decreased to 100 μg/kg following depectinization, pressing, and pasteurization, and to 32 μg/kg following cold-stabilization. The loss of trans-2-hexenal could be explained primarily by its reduction to trans-2-hexenol, which increased from 53 μg/kg after crushing to 500 μg/kg after cold-stabilization. High temperature pretreatment of must immediately following crushing (“hot break”) resulted in 5- to 6-fold higher concentrations of trans-2-hexenal in the final bottled juice as compared to conventional hot press. Contrary to expectations, no significant increase in phenolics and anthocyanins were observed in hot break conditions. These results indicate that hot break procedures may thermally inactivate enzymes responsible for transforming trans-2-hexenal under normal processing conditions and potentially alter the flavor qualities of the finished Concord juice. Different equivalent pasteurization regimes (82 to 93 °C) prior to bottling had no significant effect on GLV content of the finished Concord juices (P > 0.05). Practical Application: Introducing new processing techniques to fruit juice production can potentially result in undesirable changes to organoleptic properties. We have observed significantly higher levels of trans-2-hexenal, a potent herbaceous off-flavor, in Concord grape juice prepared with an initial high temperature heat treatment (“hot break”). Concord juice producers should be cautious in using hot break processing, especially with immature fruit, as it may result in persistence of green aromas in juice.     

Dark chocolates supplemented with <Emphasis Type="Italic">Lactobacillus</Emphasis> strains

Dark chocolate masses and chocolates were supplemented with viable cells of two bacterial strains Lactobacillus caseii and Lactobacillus paracasei with potential probiotic properties, which were lyophilized in milk. Total number of live bacteria in the lyophilizate was 7.9×10⁹ cfu/g. Sucrose or isomalt and aspartame were used as bulking substances and sweeteners. Sensory attributes of these chocolates were not different from that of traditional chocolates. Calorie value of sucrose-free chocolate was lower by approximately 11.1–14.6% (dependent on their formulation) relative to chocolate sweetened with sucrose. Chocolate, which contains isomalt and aspartame can be consumed by diabetics. Numbers of live L. casei and L. paracasei cells in the examined batches of chocolate were very high and approached 10⁶–10⁷ cfu/g after 12 months of keeping at 4 and 18 °C. Neither the texture nor the total and volatile acidity of chocolate masses were changed by addition of the lyophilized preparation of Lactobacillus cells. Casson yield values of dark sucrose-free chocolate masses supplemented with this lyophilizate were decreased by approximately 3–55% (dependently on fat contents in these masses) as compared to that of analogous chocolate masses sweetened with sucrose.     

Use of commercial grape phenolic extracts to supplement solid foodstuff

Osmotic treatment (OT) has been applied to infuse phenolic compounds into a model food. Two commercial grape extracts were used as a source of phenolics, a grape seed extract (GSE) and a white grape marc extract (WGME). Three different concentrations of total phenolics were applied with and without presence of osmo-active solute (50 g/100 g and 0 g/100 g of sucrose) in the osmotic solution (OS). With a 50 g/100 g sucrose and a total phenolic content in OS ranging from 3 g/L to 15 g/L and operating time up to 8 h, the final total phenolic content in the osmo-treated model food was between 815 mg GAE/kg and 7176 mg GAE/kg. That is between the 0.5 and 1.5 times higher than that of the richest fruits. A soaking process with the same phenolic content but with no sucrose in OS led to a total phenolic content in the model food that was between 80% and 100% higher.Mass transfer of the major phenolics infused into the model food during OT and soaking process was characterized considering the diffusional approach and Peleg's model. Progress of total and individual phenolic content fitted well both models with the exception of the flavan-3-ol dimer concentration.     

Impact of Multicolored Asian Lady Beetles on the Sensory Properties of Concord and Niagara Grape Juice

ABSTRACT: The presence of Multicolored Asian Lady Beetles (MALB) in grape juice is increasingly problematic. The overall objective of this study was to determine the specific sensory impacts of MALB on Concord and Niagara grape juice. The aroma threshold for MALB-taint in both juices was determined and expressed as the best estimate threshold (BET). The aroma BET for MALB-taint in Concord grape juice was 1.8 and 0.65 MALB/L Niagara grape juice. The specific sensory attributes of the grape juices influenced by the presence of MALB were then described. In Concord grape juice, trained panelists (n = 9) found significant increases in vegetal aroma and earthy flavor as MALB concentration increased from 0.45 to 7.2 MALB/L. In Niagara grape juice, with increasing MALB concentration, trained panelists (n = 8) indicated significant decreases in honey and sweetness with corresponding increases in sourness, astringency, and vegetal and earthy aromas and flavors (P < 0.05). For both aroma and flavor, consumer rejection studies were performed using paired preference comparisons of control juice to MALB-tainted grape juice. For Concord grape juice, consumers (n = 60) rejected the aroma of MALB-tainted juice at 1.8 MALB/L and the taste/flavor of the MALB-tainted juice at 3.6 MALB/L. For Niagara juice, consumers rejected the aroma of the juice at 3.6 MALB/L. This study demonstrated the presence of MALB negatively impacts the sensory properties of Concord and Niagara grape juice. Grape juice processors may use this research for quality control measures and for establishing tolerance limits. Practical Application: The Multicolored Asian Ladybeetle (MALB), initially used for biocontrol, has been shown in previous literature to impact the sensory properties of wines. The presence of MALB in grape juice is now becoming problematic; however, there is little research describing the specific sensory impacts of MALB on grape juice. This study examined the sensory impact of MALB on both Concord and Niagara grape juice. While the threshold and trained panel evaluations from this study provide valuable sensory profile information, grape juice processors may be particularly interested in the consumer rejection of MALB-tainted grape juice as they can use this research for quality control measures and for establishing tolerance limits.     

Effect of lecithin concentration on properties of sucrose-free chocolate masses sweetened with isomalt

Rheological properties such as Casson viscosity and yield value strongly affect costs and efficiency of the chocolate making process. The addition of a proper amount of lecithin to the blend of chocolate ingredients results in a decrease of both the aforementioned parameters. However, overdosing of lecithin leads to worse sensory attributes and flow properties of the chocolate mass. Our studies on rheological properties of isomalt-containing dark chocolate masses and sucrose-containing milk chocolate masses revealed that the critical lecithin concentration was 0.9 g/100 g; and the Casson yield value of both the types of chocolate blends was enhanced above this content. The same phenomenon, i.e. chocolate thickening, was observed at lecithin concentrations of 0.4 g/100 g and 0.6 g/100 g for milk chocolate masses sweetened with isomalt, and for dark chocolate masses sweetened with sucrose, respectively.     

Chemical Characterization of Tomato Juice Fermented with Bifidobacteria

Abstract: The objective of this research was to characterize the chemical properties of tomato juice fermented with bifidobacterial species. Tomato juice was prepared from fresh tomatoes and heated at 100 °C prior to fermentation. Bifidobacterium breve, Bifidobacterium longum, and Bifidobacterium infantis were inoculated in tomato juice and kept at 35 to 37 °C for up to 6 h. Fructooligosaccharide (FOS) was added to tomato juice prior to fermentation. The analyses for brix, total titratable acidity (TTA), pH, color, and lycopene content were conducted to characterize tomato juices fermented with bifidobacterial species. Heat treatment of tomato juice did not cause any significant changes in brix, pH, and TTA. Only the redness of tomato juice was significantly increased, as the heating time increased to 30 min. The tomato juices fermented with B. breve and B. longum exhibited significant decreases in pH (3.51 and 3.80, respectively) and significant increases in TTA (13.50 and 12.50, respectively) (P < 0.05). B. infantis did not cause any significant change in the chemical properties of tomato juice. The addition of FOS further improved the fermentation of tomato juice by bifidobacterial species. The lycopene contents of tomato juice were significantly increased from 88 to 113 μg/g by heat treatment at 100 °C (P < 0.05), however did not exhibit any significant change after fermentation with bifidobacterial species.     

Preliminary studies on acidity-astringency interactions in model solutions and wines

Intensity of astringency in model solutions and wines varying in total acid and total phenols was evaluated by paired comparisons by 10 trained judges. Model solutions consisted of tannic (500, 1000, 2000 mg litre^?1) and tartaric (0, 2, 4, 6 g litre^?1) acids dissolved in aqueous solutions of ethanol (120 ml litre^?1) and sucrose (5 g litre^?1). Wine solutions were prepared by addition of citric acid (0, 0.5, 1, 2, 3 g litre^?1 as tartaric acid) to a high phenol-red wine (2645 mg litre^?1 GAE) and a moderate phenol-white wine (800 mg litre^?1 GAE). At all three levels of tannic acid, astringency of model solutions increased significantly (P<0.001) with tartaric acid concentration. Astringency of white wine also increased significantly (P<0.05) with citric acid concentration. A negative linear relation was found between relative astringency and pH at a given tannin level for both model solutions and white wine. As pH was reduced, more phenolic molecules were in the phenol form thereby increasing the likelihood of hydrogen bonding between hydroxyl groups of wine tannins and ketoimide groups of mouth proteins. The preliminary hypothesis that hydrogen bonding is the main reaction involved in the formation of protein-tannin complexes resulting in the sensation of astringency was reinforced.     

Freeze concentration of must in a pilot plant falling film cryoconcentrator

The standard methods of producing concentrated grape must are vacuum evaporation and reverse osmosis. Concentration by freezing is the system that comes closest to the ideal objective of separating water from the food product without affecting the other components. This article examines the process for freeze concentration of white must from Macabeo variety grapes.The pilot plant equipment designed at the Technical University of Catalonia is based on freezing the water content of fluids in direct contact with a cold surface. Different parameters were studied to allow tracking of the process: evolution of soluble solids and the ice production. Freeze concentration tests with forty five litters of must were made at an initial concentration of 16.4 °Brix. A final concentration of 29.5 °Brix was obtained. An average rate of 1.38 °Brix/h was obtained working at flow rates of 0.8 L/s. The ice production ranged from 1.32 to 1.05 g?m^? 2?s^? 1 as the concentration of the must increased.Industrial relevanceSometimes the must has low contents in sugars. The freeze concentration can achieve the appropriate level of concentration in some favorable conditions without losses of aroma and sensorial properties. With this purpose INCAVI (Catalonian Institute of vineyard and wine) provided 100 L of grape juice for the test presented in this article. In this work has been applied this technology to concentrate must (grape juice) obtaining promising results.     

Optimization of supercritical CO2 extraction of phytosterol-enriched oil from Kalahari melon seeds

Supercritical carbon dioxide (SC-CO₂) extraction of oil from Kalahari melon seeds was investigated in this study. Response surface methodology was applied to model and optimize the extraction, namely pressure (200–400 bar), temperature (40–80 °C), and supercritical fluid flow rate (10–20 mL/min). Well-fitting models were successfully established for oil recovery (R ² = 0.9672) and phytosterol concentration (milligrams per 100 g; R ² = 0.8150) through multiple linear regressions with backward elimination. The effect of supercritical fluid flow rate was the most significant (P < 0.05) factor that affected oil recovery but this factor had no significant (P > 0.05) effect on phytosterol concentration. The optimal processing conditions for oil recovery and phytosterol concentration were pressure of 300 bar, temperature at 40 °C, and supercritical fluid flow rate of 12 mL/min. These optimal conditions yielded a 76.3% oil recovery and 836.5 mg/100 g of phytosterol concentration. The oil content in the Kalahari melon seeds as estimated by Soxhlet extraction was around 30.5/100 g. The phytosterol concentration in the oil extracted with SC-CO₂ extraction was 94% higher than that obtained with solvent extraction.