快速法测定AES中未硫酸化物的含量

讨论了一种快速测量AES中未硫酸化物的方法。首先将配制好的AES-乙醇溶液，通过离子交换树脂，然后收集、蒸馏、干燥得到的液体，称重后即可得到未硫酸化物的含量，采用该方法比国家标准节约2．5～3h的分析时间。     

盐水中硫酸根的脱除技术

指出了盐水中硫酸根的危害，介绍了盐水生产中脱除硫酸根的主要技术方法。     

Poly(butylene terephthalate)/organoclay nanocomposites prepared by in situ interlayer polymerization and its fiber (II)

Intercalated nanocomposites with poly(butylene terephthalate) (PBT) incorporated between the montmorillonite layers were synthesized from dimethyl terephthalate and 1,4-butane diol by using an in situ interlayer polymerization. The PBT nanocomposites were melt-spun at different organoclay contents to produce monofilaments. The samples were characterized by using wide angle X-ray diffraction, electron microscopy, thermal analysis, and tensile testing. The extent of the clay layer in the PBT was confirmed by using X-ray diffraction and electron microscopy, and the clay layer was found to be highly dispersed on a nanometer scale. The addition of only a small amount of organoclay was enough to improve the thermo-mechanical properties of the PBT hybrid fibers. The hybrids were extruded with various draw ratios (DRs) to examine the tensile mechanical property of the fibers. At DR=1, the ultimate tensile strength of the hybrid fibers increased with the addition of clay up to a critical content and then decreased. However, the initial modulus monotonically increased with increasing amount of organoclay in the PBT matrix. When the DR was increased from 1 to 6, for example, the strength and the initial modulus values of the hybrids containing 3 wt% organoclay decreased linearly.     

单组分阴离子水性聚氨酯胶膜的热质研究

应用热质分析（TG）研究了单组分阴离子水性聚氨酯胶膜的耐热性能，结果表明：n（--NCO）：n（--OH）增大，胶膜的耐热性能增强；聚酯相对分子质量增加，耐高温性能降低；用DEG扩链时的耐高温性能比用DEG／TMP时的好；TDI型水性聚氨酯成膜物的耐高温性能优于IPDI型水性聚氨酯。     

Anionic Clays as Potential Slow-Release Fertilizers: Nitrate Ion Exchange

Several nitrate containing anionic clays were synthesized at different temperatures and the kinetics of NO₃ ^– release were determined to test their suitability as slow-release N fertilizers. A sample (Mg:Al = 2:1) synthesized at 60°C with smaller particle size released 75, 86 and 100% of its NO₃ ^– in 1, 3 and 7 days, respectively when equilibrated with a simulated soil solution. On the other hand, the 175°C/2 hrs sample with larger particle size released 65, 77 and 84% of its nitrate in 1, 3 and 7 days, respectively. Another anionic clay (synthesized at 175°C/24 hrs) of higher charge density (Mg:Al = 2:1) containing NO₃ ^– was equilibrated with a 0.012 N NaCl or Na₂CO₃ to test the role of different anions in releasing the NO₃ ^– anion from the interlayers. The results showed that Cl^– released more NO₃ ^– than did CO₃ ^2– from this anionic clay after all the treatment times probably as a result of the CO₃ ^2– anion blocking the release of NO₃ ^– from the interior of the crystals. When a lower charge density (Mg:Al = 3:1) sample (synthesized at 175°C/48 hrs) was equilibrated with 0.02N solution of anions the release of nitrate was as follows: Cl^– < F^– < SO₄ ⁼ CO₃ ^2–. These results suggest that the divalent SO₄ ⁼ and CO₃ ^2– anions are more effective in the release of NO₃ ^– from this lower charge density anionic clay. Time-resolved structural analysis of NO₃ ^– exchange with CO₃ ^2– in the above anionic clay using synchrotron x-ray diffraction showed that ion exchange is rapid because of small crystal size and lower charge density. Thus the release of NO₃ ^– from anionic clays is an interplay among the type of anions present in soil solution, their concentration, pH of soil solution, the charge density and crystal size of anionic clay etc.     

D301树脂分离衣康酸的工艺研究

采用弱碱性阴离子交换树脂Ｄ３０１对发酵法生产的衣康酸进行了分离研究。通过静态交换实验，研究了Ｄ３０１树脂对衣康酸的静态交换动力学，确定了传质机制和影响因素；通过动态交换实验，研究了以硫酸为洗脱剂，以氨水为再生剂的工艺过程，确定了主要工艺参数。     

基于吡咯-酰胺混合单元的阴离子受体的研究进展

综述了最近10年来对含有吡咯酰胺混合单元的阴离子受体的研究进展,重点评述了这些受体的阴离子配位性质。这些阴离子受体包括桥联二吡咯柄型二茂铁、基于联吡咯的索烃、附加有离子基团的吡咯酰胺、吡咯-2,5-二甲酰胺和吡咯-2,5-二乙酰胺。     

扩散渗析法从钛白废酸中回收硫酸

针对钛白废酸的回收,在静态扩散条件下测定了硫酸、硫酸亚铁在阴离子交换膜中的渗析系数以考察膜的分离性能。进一步考察动态扩散操作参数如流量、流量比、停留时间等对回收率及回收酸浓度的影响。研究表明,使用的阴离子交换膜具有良好的分离性能,酸盐分离系数达23.6,在水酸流量比维持在1～1.1,废酸流量维持在0.6L·h-1左右的条件下,硫酸回收率大于85%,硫酸亚铁透过率小于7%。     

有机硅骨架阴离子交换树脂的合成及应用

以等摩尔的γ-氨丙基三乙氧基硅烷与γ-氯丙基三乙氧基硅烷于140℃反应12 h,脱盐后再与1.2倍摩尔的γ-氯丙基三乙氧基硅烷150℃反应16 h,得叔胺硅氧烷预聚物,该预聚物在甲苯-甲醇-水混合溶剂中进一步聚合成含N高度交联的有机硅聚硅氧烷树脂骨架.骨架与溴乙烷在120℃的封管反应20 h,生成强碱性阴离子交换树脂(PNC树脂),交换量可达1.55 mmol·g-1.该树脂用碳酸氢根转型后于固定床反应器中在95℃、1.2 MPa、环氧乙烷与水摩尔比18、空速1.0h-1下催化环氧乙烷水合反应,连续运行72 h,环氧乙烷转化率可达96.9%,乙二醇选择性可达97.1%;交换容量损失率小于2%,溶胀率为零.     

Origin of rate bistability in Mn–O/Al2O3 catalysts for carbon monoxide oxidation: role of the Jahn–Teller effect

Peculiarities in catalytic activity in carbon monoxide oxidation as well as some structure, electronic and magnetic properties of the three oxide catalysts, Mn³⁺–O/Al₂O₃ (1), Mn³⁺–O–Fe/Al₂O₃ (Mn-substituted spinel, 2) and -Fe₂O₃/Al₂O₃ (3), were studied by kinetic measurements and by Mössbauer spectroscopy. The catalysts 1 and 2 showed a kinetic bistability with a sharp transition towards more reactive state at 200°C (ignition point). In contrast, for catalyst 3, at 200–250°C, the behavior of reaction rate against temperature did not display noticeable hysteresis. On cooling the catalysts 1 and 2, extinction was observed at about 170 and 120°C, respectively, i.e., at 30–80°C lower than the corresponding ignition points. Proximity of activation energy for the high and low activity (15–19 kJ/mol) for both Mn-containing catalysts suggests an increase in the number of active sites at high temperature with no changes in the reaction mechanism. The considerable difference between Mn-containing catalysts 1, 2 and Fe-containing catalyst 3 may be caused by Jahn–Teller (JT) type distortions of the oxygen polyhedron around Mn³⁺. A significant spontaneous axial bond stretching within the local polyhedron seems to diminish Mn–O binding energy, facilitate the participation of surface oxygen species, O_S, in the oxidation of CO by a redox mechanism and promote oxygen vacancies at the surface that would cause considerable effect on the activity. An increase in the width of the counterclockwise hysteresis loop for the catalyst 2 compared to the catalyst 1 indicates that clusters of mixed spinel provide more active sites and more labile O_S species than clusters of the binary Mn oxide.