回用水对冷却水系统316L不锈钢的腐蚀

城市污水回用作循环冷却水系统,讨论了NH3-N、COD、Cl-、SO42-等因素对316L不锈钢耐腐蚀性的影响。极化曲线表明:当NH3-N的质量浓度超过18 mg/L时,NH3-N促进了不锈钢的点蚀;COD对316L不锈钢的点蚀并无多大的影响;Cl-促进点蚀,而SO42-的质量浓度小于300 mg/L时,SO42-对其点蚀有缓蚀作用。     

落水洞对裂隙-管道介质排水过程的影响

利用自行研制的裂隙-管道介质物理模型进行多组试验,探究落水洞对介质排水过程的影响。对裂隙-管道介质按照介质空隙结构特点进行分区,引入反映介质排水过程中水体排泄快慢的单位时间排水量,进而得到对应不同介质分区和介质整体的四个单位时间排水量。利用单位时间排水量分析九种落水洞横截面积对裂隙-管道介质排水过程的影响。结果表明:落水洞横截面积的增大对裂隙-管道介质结构的影响为增大其储水空间和导水空间;落水洞横截面积的增大会加快裂隙-管道介质的排水过程,排水过程对落水洞横截面积增大的响应在横截面积的增大量达到某一阈值后才会发生,该阈值和介质空隙结构有关;排水过程的三个不同阶段的阈值不同,末期的阈值小于初期、中期的阈值。     

Horizontal wells and steam-assisted gravity drainage

Petroleum can be produced more efficiently using horizontal wells instead of conventional wells. For a typical 16 hectare well spacing, the pressure drawdown is as small as one-fiftieth of that for conventional wells. In some cases, where coning is a problem in conventional production, horizontal wells allow operation with much less coproduction of the displacing fluid. In the thermal recovery of bitumen and heavy oils, the Steam-Assisted Gravity Drainage process with horizontal production wells allows the systematic sweeping of the reservoir with economic production rates and without steam bypass. This paper described and reviews the application of horizontal wells to the production of heavy crude oils and bitumen by both non-thermal and thermal methods.     

舌片式导流管强化蒸汽冷凝传热的研究

通过对舌片式导流管强化垂直圆管内蒸汽冷凝传热研究 ,在实验范围内 ,传热系数增大3.6 4～ 5 .6 1倍、效果十分显著 ,舌片垂直节间距越小 ,舌片愈宽强化传热效率越好     

Membrane application for recovery and reuse of water from treated tannery wastewater

Secondary treated tannery wastewater contains high concentrations of Total Dissolved Solids (TDS) and other residual organic impurities, which cannot be removed by conventional treatment method. A pilot plant membrane system with a designed processing capacity of 1 m³/h, comprising of nano and reverse osmosis (RO) membrane units, accompanied by several pre-treatment operations, was evaluated in order to further treat and reuse the tannery wastewater. The maximum TD S removal efficiency of the polyamide RO membrane was more than 98%. The permeate recovery of about 78% was achieved. The water recovered from the membrane system, which had very low TDS concentration, was reused for wet finishing process in the tanneries. The reject concentrate obtained from the operation was sent to solar evaporation pans. It was evident from the study that the membrane system can successfully be applied for recovery of water from secondary treated tannery effluent, provided a suitable and effective pretreatment system prior to membrane system is employed. Combining nano and RO membranes improved the life of the membranes and permeate recovery rate.     

循环冷却水零排污运行方案的研究

对循环冷却水系统零排污的技术可行性、经济性等进行了讨论，并针对大庆炼化公司循环冷却水系统零排污方案的实施加以详细描述，对实施过程中存在的问题予以了详细说明。     

用工业废碱水处理反渗透法高含盐排放浓水

反渗透处理装置排放的浓水含盐量很高，如果不经处理直接排放势必对周围环境造成污染和水的浪费，氧化铝生产工艺废水中含有大量的碳酸钠、苛性碱等碱类物质，pH值达到13左右，回水量约2000m^3／h，用这些废水和反渗透浓水混合进行软化处理，降低浓水中的钙镁离子含量，并对难去除的硫酸盐进行稀释降低浓度，回用到蒸发循环水系统作为补充用水、氧化铝生产部分工艺用水、设备冷却用水，达到浓水回收再利用的目的。该方案实施后效果十分显著，回收反渗透浓水约60m^3／h，减少污水系统补充新水，降低生产用水费用约每年176万元。     

Sludge Pre-Treatment through Ozone Application: Alternative Sludge Reuse Possibilities for Recirculating Aquaculture System Optimization

Recirculating Aquaculture Systems (RAS) reduce water consumption by efficient filtration to maintain appropriate levels of accumulating compounds and sludge. Sludge is mechanically separated by drum filters and disposed of to the detriment of overall system water budgets. Dissolved nitrogen compounds are reduced via nitrification–denitrification filters, requiring commercial external carbon sources. The reuse of sludge after ozone pre-treatment may represent the next step in RAS optimization. The present study analyzes the content of sludge from RAS and tests ozonation as a pre-treatment for recycling as carbon source. The dissociative effect of ozone and the physicochemical changes due to ozonation lead to a significant increase in soluble carbon availability. Predominantly long-chain fatty acid (FA) (saturated and unsaturated) with 16 and 18 carbon atoms independently of the treatment were found in the profiles. Saturated FA concentrations in solution increased after 20, 40, and 60 min ozonation. The solid content of the sludge was practically unaffected by ozonation in terms of FA profile: only saturated FA slightly increases after 40 min treatment. The implications of these findings for denitrifying bacteria are discussed.

Abbreviations: Recirculating Aquaculture Systems (RAS); Advanced Oxidation Processes (AOPs)     

城市雨洪放大效应驱动因子时空演变规律分析

城市雨洪具有复杂的放大效应,引起该现象较直接的原因包括大暴雨的频繁出现、可渗透地表面积的骤减以及排蓄水能力的改变和排水管网的扩张等。以武汉市为例,选择降雨强度、不透水面积比例、排水管道密度作为洪水放大效应的驱动因子进行趋势分析和演变规律分析,计算表明:从20世纪80年代开始,暴雨雨量和历时明显增加;不透水面在20世纪90年代初增加较快;排水管道在1990~2006年间缓慢增长,2007年跳跃式增长。降雨量和历时的增加使城市洪量增大,排水压力随之上升,在一定程度上增加了内涝几率;不透水面积的逐年增多以及水体等天然蓄水区的减少,不但增加了产流量,也使汇流时间更短,且雨水管渠的建设缩短了天然汇流路径,导致城市洪水呈现峰高量大,洪峰提前的放大效应。研究成果可用于城市雨洪放大效应对其驱动因子的定量响应研究,为进一步量化城市内涝风险与驱动因子间的关系提供依据,从而为内涝风险调控措施提供技术支撑。     

改性纤维球在稠油污水回用于锅炉用水的试验

针对稠油污水回用锅炉水质的要求,采用改性纤维球滤料进行静态与动态模拟试验。对其吸附性能、截留效果及再生性能进行试验与评价。结果表明,改性纤维球是一种优良的过滤材料,滤料亲水疏油,对水中油、悬浮物颗粒等具有良好的吸附拦截作用,过滤周期长达24h,容易再生。当改性纤维球过滤器进水油、悬浮物的质量浓度分别为130、100mg/L以下时,出水均小于2mg/L,能够满足稠油污水回用锅炉的要求。