T406型脱氯剂的研制与工业应用

报导了型脱氯剂的研制、性能试验和工厂运行结果。与国内外常见同类脱氯剂的对比试验及工业应用表明, 由化工部西北化工研究院开发研制的这一新型脱氯剂具有抗压碎强度高, 净化度高, 氯容量高的特点, 可以在常温下用于气相和液相原料中氯化物的脱除。即使在低温（4℃）下, 净化后原料中氯降至左右的情况下抓容量仍高达18％以上。该脱氯剂还能同时脱除原料中的硫。T406型脱氯剂已工业应用于混合二甲苯和氢原料的脱氯, 使用效果良好。     

接种固氮菌对纤维素分解过程的影响

从纤维素分解菌与联合固氮菌的接种配比,研究了混合培养对滤纸分解的影响。试验共设6个处理样,总接种量均为10%(V/V):处理Ⅰ,2%固氮菌+8%纤维素分解菌;处理Ⅱ,4%固氮菌+6%纤维素分解菌;处理Ⅲ,6%固氮菌+4%纤维素分解菌;处理Ⅳ,10%纤维素分解菌;处理Ⅴ,10%固氮菌;CK(空白对照)。结果显示:与处理Ⅳ相比,处理Ⅰ、Ⅱ的CMC酶活力及处理Ⅰ、Ⅱ、Ⅲ的滤纸分解率有明显提高。接种固氮菌的各处理样中,培养液中氮素含量与CK相比均有显著提高(P<0.05),且培养过程中pH值比较平稳,而未接种固氮菌处理培养液的氮素则低于CK,pH急剧降低。所有处理样中,接种2%固氮菌效果最佳,培养192h,其CMC酶活力与滤纸分解率比处理Ⅳ分别提高43.4%、240%;与处理Ⅴ相比,固氮菌数有显著增加(P<0.05),培养液中氮含量提高28.0%。     

含水混酸的酯化分离试验

基于中国石化扬子石化公司化工厂醋酸装置产生大量的含水甲酸、乙酸副产品,通过试验将含水混酸进行酯化、分离,得到符合工业品规格的甲酸乙酯、乙酸乙脂。试验确定酯化塔回流比为3∶1,乙醇分批次加入,乙醇实际投入量与理论量的比为1.2。酯化分离结果:甲酸乙酯的单程收率89.5%,纯度大于97%,乙酸乙酯的单程收率80.1%,纯度大于97%。     

某砖混结构加层改造的设计

通过对某砖混结构加层改造的设计实践,介绍了加层改造的方法,分析了在加层改造过程中需解决的问题。主要包括地基及基础的处理,墙体抗压、抗震验算,节点连接处理,如何保证新结构与原结构连接的整体性,楼梯间处理,构造柱的连接等,并提出了结构加层对施工技术的要求。给出一些具体的构造大样,供工程设计参考。     

大量Li+存在的卤水体系中容量法测定Ca2+的分析方法研究

在Li 、Ca2 共存的相化学研究中,大量Li 的存在对配位滴定法测定Ca2 易产生较大干扰,致使卤水体系中钙的测定结果产生较大偏离。本文在进一步研究了用三乙醇胺作掩蔽剂消除Li 干扰的实验基础上,对高锂钙比(mLi∶mCa≥5)消除Li 的干扰,首次发现正丁醇-无水乙醇的混合液可有效掩蔽共存Li 的干扰。实验结果表明,该方法可使Ca2 分析结果相对误差不超过0.3%。样品加标回收率为99.90%~100.09%,相对标准偏差<0.2%。     

Selective oxidation of ammonia to nitrogen on transition metal containing mixed metal oxides

The selective catalytic oxidation of ammonia to nitrogen (NH₃-SCO) has been studied over hydrotalcite derived mixed metal oxides containing Cu, Co, Fe or Ni. XRD, BET, NH₃-TPD and TPR techniques were used for catalysts characterization. Results of NH₃-SCO were compared with those of selective catalytic reduction of NO with NH₃ (NO-SCR). Reaction mechanism was studied by temperature-programmed surface reaction (TPSR) and activity tests with a various contact time. Catalytic performance of the studied samples depends on both kind and loading of transition metals in the mixed metal oxide system. The Cu-containing samples have been found to be the most active catalysts of the NH₃-SCO process. Transition metal loading strongly influences distribution of ammonia oxidation products. The highest selectivity to N₂ was measured for the catalysts with the lowest transition metal content.     

Effect of mixing leaves with olives on organoleptic quality of oil obtained by centrifugation

Variable quantities of leaves were added to ripe olives prior to extraction to determine their effect on the quality of the resulting olive oil. The addition of 1–3% w/w leaves improved the organoleptic quality. An increase intrans-2-hexenal aldehyde content occurred, giving the pleasant flavor of “freshly cut grass.” This compound was produced by the enzymatic breakdown of 13-L-hydroperoxide of linolenic acid in leaf homogenates.     

利用SPR生物传感器检测缺血修饰白蛋白

缺血修饰白蛋白(IMA)的检测对心肌缺血的早期诊断和治疗具有重要意义。利用纳米金颗粒和混合巯基自组装于金膜表面上,研制了一种快速检测IMA的表面等离子体共振(SPR)生物传感器。同时比较了直接法和抑制法的检测下限。结果表明:直接检测法可以检测到393ng/L的IMA,而抑制检测法检测限小于5.0 ng/L。与现有的IMA检测方法相比,SPR生物传感器具有特异性好、检测下限低以及检测耗时短等优点。     

Properties of palm-oil-in-water emulsions: Effect of mixed emulsifiers

Palm-oil-in-water emulsions were prepared with mixtures of Tween 40 and Span 40 in various proportions. Stability and droplet-size distribution of the emulsions were monitored. Interfacial tensions of the palm oil/water interface were also determined in the presence of these emulsifier mixtures. Emulsifying efficiency of the emulsifier mixtures was assessed. No synergistic effect of Tween 40 (sorbitan monopalmitate with 18–22 moles of ethylene oxide) and Span 40 (sorbitan monopalmitate) was found on interfacial tension. Tween 40 alone (hydrophilic-lipophilic balance value 15.6) at 1.0% w/w gave palm oil emulsions that were stable for more than 30 d at 60°C. Emulsifier mixtures of Tween 40 and Span 40 with hydrophilic-lipophilic balance values in the range of 8.0–8.6 produced stable emulsions only at much higher emulsifier-mixture concentrations. The inherent nature of the oil and the accompanying natural surface-active materials present in the oil can influence the prevailing conditions at the oil/water interface and alter composition of the interfacial film and hence its stability.     

多菌灵·硫·三环唑混配对抑制水稻稻瘟病菌和纹枯病菌的协同增效作用

多菌灵、硫及三环唑混配成悬浮剂,对抑制稻瘟病菌的菌丝生长、分生孢子萌发、附着胞的形成、产孢能力及纹枯病菌菌丝生长等都具有较明显的协同增效作用,协同作用比率(SR)分别为1.64、5.58、4.30、1.81及1.73。混配剂集合了多菌灵、硫及三环唑的优点,并显示出耐雨水冲刷、持效期长的特点。田间试验亦表明其防病增产作用比较显著。