煤矿应急通信保障系统的设计

提出了一种煤矿应急通信保障系统的设计方案。该系统的核心即应急救援软件平台通过中继网关、专用转换器等设备整合井下扩播电话机、小灵通、WiFi手机、调度电话机、井下广播系统,从而实现各通信系统间的互联互通;该系统通过应急救援软件平台实现与矿井人员定位系统的互联互通、与矿井工业以太网的综合接入。实际测试结果表明,该系统具有线路管理、音频播放、一键通、广播及应急通信救援等功能,提高了应急救援工作的效率。     

智能集中润滑系统在平朔矿区的应用

分析了平朔矿区原有破碎机润滑系统使用中存在的问题,介绍了一种智能集中润滑系统的工作原理及其在平朔矿区应用中的系统配置、系统应用方案及系统维护。该智能集中润滑系统将PC和PLC与现场多点润滑泵、智能仪表和智能传感器相结合,采用多点润滑泵实现对破碎机多个点的集中润滑,采用电动加油泵实现自动补脂。实际应用表明,该智能集中润滑系统运行稳定、可靠,提高了设备使用效率,减少了日常维修工作量。     

导热油换热器预热煤粉气流的试验研究

提出在煤粉进入燃烧室之前对煤粉气流进行预热处理的新型工艺,减轻一次风对炉膛的冷却效应,加速煤粉燃烧. 设计采用导热油预热煤粉气流的带翅板管壳式换热器,搭建中试规模试验台,通过实验研究油温、油质量流量、风温、风速、煤风质量比对系统换热特性及试验台阻力特性的影响. 试验结果验证了该换热器采用导热油来预热一次风煤粉气流的技术可行性,提出的新型预热工艺具有环保节能的现实意义. 试验结果表明,当煤风质量比为0.15时,190 ℃的导热油可以将煤粉气流从58.4 ℃预热到113 ℃以上. 提出的预热工艺有利于改善煤粉气流的着火性能,促进煤粉锅炉的低负荷稳燃.     

Corrosion of Fe-10Al-Cr alloys by coal char

Corrosion of iron-base alloys at 982°C (1800°F) by coal char is observed and the phase morphologies are discussed. No sulfidation was observed at 50 hr exposure. After 100 hr internal aluminum-rich sulfides were observed along with thick outer scales of iron oxide. The species causing the hightemperature-induced corrosion are probably sulfides and sulfates, present in most coal chars. Possible mechanisms for the corrosion are also discussed.Department of Materials Science and Mineral Engineering.     

微细粒技术在洁净煤技术中的作用和地位

从煤加工利用对颗粒粒度及其分布的要求，解离度对超纯煤的制备以及煤炭组分工业化分离的影响等方面论述了微细粒技术在洁净煤技术中的作用和地位。研究表明煤的粒度及其分布对水煤浆制备及其利用，燃烧等有极其重要的影响；     

Some aspects of the role of coal thermoplasticity and coke structure in coal gasification. 2. The effects of pressure and heating rate on dilatometric parameters and optical anisotropy development

An examination of the influence of pressure and heating rate on the thermoplastic properties of a weakly coking coal and of coal with various pitch-like additives was carried out using a high pressure dilatometer. Pressure up to 4 MPa markedly increased the swelling properties and increased the plastic range by decreasing the softening temperature, but the effects of pressure were strongly influenced by rate of heating with high heating rates enhancing the effects. Additions of tar or pitch also enhanced swelling at low pressure. The solid carbonization residues from the dilatometer were examined by polarized light microscopy to determine the content and composition of optically anisotropic species. The anisotropic content was increased by increases in pressure and heating rate and pitch additives enhanced the anisotropic content, especially at low pressure, without affecting the composition of the anisotropy. No direct correlations exist between the dilatometric parameters and the optical anisotropy but their dependence on the conditions emphasizes that when considering high pressure gasification of coal, it is necessary to obtain data under appropriate conditions.     

气流床水煤浆气化技术的应用现状及开发进展

气流床水煤浆气化是煤高效、洁净利用的一项关键技术。简述了具有代表性的气流床水煤浆气化技术的应用现状及开发进展,并分析了影响水煤浆气化的主要因素,如烧嘴、耐火砖、进料系统、激冷环等,提出了一些改进措施。     

中国洁净煤技术发展重点及对策

阐述中国洁净煤技术发展现状及存在问题。指出洁净煤技术发展重点是能在较短时间内显著提高煤炭利用效率、有效控制污染物排放的技术 ;能对当前和未来优化能源结构发挥作用 ,有利于解决石油供需矛盾 ,保障能源安全并有产业化发展前景的技术。对洁净煤技术的发展和政策引导提出建议     

Microwave plasma combustion of coal

Microwave plasma is studied as an alternative to oil or gas fuel for ignition and stabilisation of burning of lean coal. The study is performed on an experimental set-up, which includes a burner with a microwave plasma generator, coal and air supply systems, and measurement equipment. Power and thermochemical characteristics of the coal-plasma interaction have been measured and analysed. The obtained results indicate an essential intensification of ignition and combustion processes in the microwave burner compared to those in conventional burners. In particular, it has been demonstrated that the microwave energy consumption is only about 10% of the required expenditure of oil or gas, measured in heat equivalent. A design of an industrial microwave-plasma burner is proposed. Prospects of such burner for applications at industrial boilers of power plants are discussed.     

Fourier transform infrared study of high-purity maceral types

A suite of density-differentiated macerals from several coals was analysed by Fourier transform infrared spectroscopy to obtain information on the nature and magnitude of the variations exhibited by the various maceral fractions. The most characteristic change between maceral groups was the variation in aliphatic hydrogen content, with exinite ? vitrinite ? inertinite. Since the separation technique (density gradient centrifugation) generally provided a number of fractions within a maceral group region, some of these were also analysed. In a series of density fractions from a low rank vitrinite, it was found that the aliphatic hydrogen content decreased as the density increased. The inertinites also exhibited a decrease in aliphatic hydrogen. The inertinite C—O bands had extinction coefficients different from those of vitrinites or exinites. The data suggest that quite profound variations in organic structure as determined by FT-i.r. spectroscopy can exist within a maceral group, so that for the most critical work on coals it is necessary to take this into account.