会泽铅锌矿方铅矿、闪锌矿和黄铁矿的浮游性研究

本文考查了ZnSO4和可溶性淀粉对方铅矿、闪锌矿和黄铁矿浮游性的影响，为会泽铅锌矿铅硫异步等可浮工艺提供了理论依据。试验结果表明，在乙黄药浮选体系中，ZnSO4和可溶性淀粉强烈抑制闪锌矿，而对方铅矿和黄铁矿的浮游性影响不大，且两者的浮游性相近。     

硫化钠诱导浮选的应用研究

研究了闪锌矿、方铝矿和黄铁矿的硫化钠诱导浮选行为．研究发现，硫化钠的加入．使得黄铁矿、方铝矿的可净性变好．通过在湖北某矿山的实践表明，硫化钠诱导浮选可以使得Ph－Zn分离效果好，回收率提高，同时回收了硫精矿．     

西北某难选铅锌矿石浮选试验

西北某铅锌矿是一个矿物成分复杂、铅锌矿物分布极不均匀、嵌布粒度细微、嵌布关系复杂、单体解离难度大、脉石矿物硬度高的大型难选铅锌矿床。为确定该资源的开发利用方案,采用优先浮选工艺对该矿石进行了选矿试验。结果表明,在磨矿细度为-0.074 mm占85%的情况下,采用1粗1扫3精选铅(铅精选前再磨至-0.045mm占95%)、1粗1扫2精选锌、中矿顺序返回的闭路流程处理该矿石,可取得铅品位为60.45%、含锌8.90%、铅回收率为75.95%的铅精矿以及锌品位为51.60%、含铅0.31%、锌回收率为87.39%的锌精矿,该选矿工艺方案是该矿石的高效开发利用方案。     

Effect of particle size on the surface oxidation and flotation behavior of galena particles in lime system

ABSTRACT

In this research, the effect of particle size on the surface oxidation and flotation behavior of galena in the lime system was studied. Coarse (?0.074 + 0.038 mm), intermediate (?0.038 + 0.025 mm) and fine (?0.025 mm) galena particles were used in the experiment. The dissolution tests, flotation tests, and sorption tests were accomplished. Through further analysis by XPS, the effect of particle size and lime was observed. The decrease of mineral particle sizes increased the adsorption ratio of collector and the dissolution of galena, while the hydrophilic product OH^?/Ca(OH)⁺ produced by dissolution occupied the dominant position, which led to the minerals hydrophilic.     

Investigation into the flotation response of refractory molybdenum ore to depressant mixtures:A case study

In this paper, bulk flotation followed by separation was investigated to concentrate purified molybdenite product from Jinduicheng molybdenum ores(Shanxi province, China). The bench scale tests mainly focussed on separation of molybdenite from other sulfide minerals using the new type of depressants.The effect of each single depressant, including organic depressant-modified dextrin(MD), P-Nokes reagent(PN) and sodium trithiocarbonate(ST), and their mixtures on galena, chalcopyrite and other sulfide ores, was examined in turn by changing the concentrations used in cleaner flotation tests. Closed circuit experiments were carried out under the optimal condition and satisfying recovery and grade of molybdenite concentrate could be achieved(86.294% and 53.157%, respectively). A potential reagent regime was developed, with more environmental friendly and more economical advantages due to the introduction of modified dextrin.     

某低品位含银铅锌硫化矿优先浮选研究

某含银铅锌硫化矿含铅1.66%、含锌1.63%、含银12.3 g/t,铅锌含量低,矿物单体粒度小且嵌布不均匀,单体解离困难。为了给该矿石的铅、锌、银资源开发利用提供技术依据,对其进行了选矿试验。结果表明:采用铅锌优先浮选流程,在磨矿细度为-74μm占70%条件下,铅粗选以25号黑药为捕收剂,硫酸锌为抑制剂;锌粗选以石灰为p H值调整剂,丁基黄药为捕收剂,硫酸铜为活化剂,YS为抑制剂;铅锌系统各经一次粗选三次精选两次扫选作业,闭路试验可获得铅品位70.35%、含锌3.48%、含银292.00 g/t、铅回收率96.59%、银回收率51.11%的铅精矿和锌品位43.84%、含铅0.32%、含银32.20 g/t、锌回收率86.60%、银回收率8.08%的锌精矿,铅锌分离效果较好,银在铅精矿和锌精矿中总回收率达到59.19%。     

四川某铅锌矿浮选试验研究

四川某铅锌矿主要回收元素为铅、锌。根据该矿石中铅锌矿石的矿物组成和有用矿物嵌布特征,此次试验采用先铅后锌的优先浮选流程,实现了铅、锌的有效分离回收。获得了铅品位和回收率分别为58.51%和69.22%的铅精矿,锌品位和回收率分别为49.38%和90.29%的锌精矿。     

Pressure leaching of a lead-zinc-silver concentrate with nitric acid at moderate temperatures between 130 and 170 °C

The aim of this investigation was to study the oxidative leaching of lead and silver from a lead-silver concentrate containing galena, sphalerite, pyrite and argentite in nitric acid solutions above the melting point of sulfur (119 °C). The elemental sulfur formed was expected to agglomerate, thereby slowing its oxidation to sulfate and inhibiting the precipitation of lead and silver sulfate.The experimental conditions employed 0.13-0.65 M nitric acid, which is 3 to 15 times the stoichiometric amount needed to form sulfur, at temperatures between 130 and 170 °C. Higher acid concentrations have a favorable effect on silver and lead dissolution at 130 °C with about 90% Ag and 80% Pb extracted into 0.65 M nitric acid within 90 min. However, an increase in temperature caused a decline in the extraction of both metals, due to the greater amount of sulfate produced. Pyrite was found to oxidize directly to akaganeite and sulfate ion and promotes the formation of plumbo- and argento-jarosite. X-ray diffraction analyses of the leach residues show the presence of anglesite (PbSO₄), plumbo-jarosite (PbFe₆(SO₄)₄(OH)₁₂), elemental sulfur (S-β) and akaganeite (FeO(OH)). Enhanced silver extraction was obtained when the oxidation was carried out in the presence of citrate ion which was added to complex with lead and silver ions.     

某铅锌矿浮选试验研究

试验的样品是以铅锌为主并伴生铜硫等的多金属硫化矿。根据矿石特性,本次试验采用"先铅后锌"的优先浮选流程,选铅尾矿进行再磨控制锌入选细度,铅浮选过程中使用Zn SO4、Na2SO3及Na2S2O3的组合药剂抑制闪锌矿的上浮,通过实验室闭路浮选试验,得到铅精矿的品位和回收率分别为73.92%和84.72%,锌精矿的品位和回收率分别为49.11%和67.01%,且铅锌互含量达标。氧化锌占总锌的32.18%是导致锌回收率不高的主要原因。     

分子模拟技术在铜铅分离机理研究中的应用

为了更好的揭示药剂与黄铜矿、方铅矿之间的作用原理,从量子化学入手,利用Materials Studio(MS)软件建立捕收剂、抑制剂在铜铅矿物表面的吸附模型,通过分子模拟技术模拟计算了真空环境下药剂分子与铜铅矿物的相互作用能。从原子尺度揭示了抑制剂在铜铅分离中的抑制机理,研究表明吸附能的差异是导致抑制剂选择性抑制的根本原因。